IllustrationLEAKING EGR COOLER. DEALER STATED THAT IF ISSUE IS NOT REPAIRED A POTENTIAL FIRE HAZARD EXISTS. A RECALL WAS ISSUED FOR VIN SPECIFIC VEHICLES BUT OTHERS WITH THE SAME ISSUE ARE NOT COVERED BY THE RECALL.
2011 BMW X5 Diesel Sav
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Other model years Selected year
Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
125–50K
650–75K
1175–100K
11100–150K
2150K+
35 reports with mileage · 9 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports2 injury reports
Fuel/propulsion System complaints
9 reports2016, MARCH 03 - DIESEL EXHAUST FUMES IN CABIN. MAG BMW DEALER REPLACED FAULTY: INTAKE TEMP SENSOR FAULT # 004BC6 AND FUEL PRESUPLY LINE: FAULTS #004BDA AND 004BDC. SCR TANK FAULT 0046F9 WAS NOT REPAIRED BY BMW.
2017 JULY - DIESEL EXHAUST FUMES IN CABIN. MAG BMW DEALER REPLACED FAULTY EGR COOLER AND EGR VALVE SECOND TIME.
2017 DEC - DIESEL EXHAUST FUMES IN CABIN. MAG BMW DEALER REPLACED EGR PRE-COOLER, AND INTAKE TURBO LINE.
2018 MARCH - DIESEL EXHAUST FUMES IN CABIN. MAG BMW DEALER REPLACED INTAKE TURBO LINE, SECOND TIME.
2018 DEC 14 - DIESEL EXHAUST FUMES IN CABIN. MAG BMW DEALER FOUND FAULTY INTAKE MANIFOLD AND OIL TURBO LINE.
DTC P20EE: FAULT FOR FUEL FILTER HEATER (REPLACE HEATER). SIMILAR RECALL TO 2009 DIESEL X5 FAULTY FUEL FILTER HEATER, WHICH COULD REMAIN ON AFTER ENGINE WAS SHUT OFF LEADING TO A POTENTIAL FIRE.
RECENTLY PURCHASED 2011 BMW X5D. VEHICLE HAD 147, 068 MILES. AFTER DRIVING AT HIGHWAY SPEED FOR LESS THAN 100 MILES FROM THE PURCHASE POINT, CEL CAME ON. THE SELLER WAS NOTIFIED ONLY TO TELL ME THAT A SENSOR READING NEEDED TO BE CHECKED AND THE VEHICLE WAS FINE TO CONTINUE TO DRIVE. A WEEK LATER A CERTIFIED BMW MECHANIC INFORMED…
Read full complaint
RECENTLY PURCHASED 2011 BMW X5D. VEHICLE HAD 147, 068 MILES. AFTER DRIVING AT HIGHWAY SPEED FOR LESS THAN 100 MILES FROM THE PURCHASE POINT, CEL CAME ON. THE SELLER WAS NOTIFIED ONLY TO TELL ME THAT A SENSOR READING NEEDED TO BE CHECKED AND THE VEHICLE WAS FINE TO CONTINUE TO DRIVE. A WEEK LATER A CERTIFIED BMW MECHANIC INFORMED ME THAT THE DIAGNOSTIC READING INDICATED NOX FAULT 4BFO. REDUCING AGENT ACTIVE TANK SENSOR SIGNAL 4BAC. THROTTLE VALVE ACTUATOR 4687. AS WELL AS 3 OTHER FAULTS RELATING TO THESE. ONE OF THESE SENSORS IS IN THE ACTIVE TANK AND COULD BE ASSOCIATED WITH AN MALFUNTION OF EMISSION SYSTEM AND EMISSION VIOLATIONS WHICH COULD RENDER THE MOTOR TO BE DISABLED. BMW CLAIMS THAT NO RECALL ON THE ISSUE HAS BEEN RECORDED. I RESEARCHED THE ISSUE TO FIND THAT BMW HAS ANNOUNCED A RECALL ON THE SCR SYSTEM AFFECTING THE DEF MIXER AND THE EGR SYSTEM. ALL OF THESE ISSUES WILL RESULT IN EMISSIONS FAILURE AND SUBSEQUENT ENVIRONMENTAL HARM.
I HAVE A 2011 BMW X5 335D WITH A LITTLE OVER 73K MILES. JUST RECENTLY MY CHECK ENGINE LIGHT CAME ON AND AFTER A TRIP TO THE SHOP THE TECHS SAID IT WAS DUE TO A FAULTY DEF (DIESEL EXHAUST FLUID) SENSOR. UNFORTUNATELY THIS PART IS ~$930 AND IS ON A NATIONAL BACK ORDER. I ASKED IF THE PART IS A MANUFACTURE RECALL, BUT IT'S NOT. I'M…
Read full complaint
I HAVE A 2011 BMW X5 335D WITH A LITTLE OVER 73K MILES. JUST RECENTLY MY CHECK ENGINE LIGHT CAME ON AND AFTER A TRIP TO THE SHOP THE TECHS SAID IT WAS DUE TO A FAULTY DEF (DIESEL EXHAUST FLUID) SENSOR. UNFORTUNATELY THIS PART IS ~$930 AND IS ON A NATIONAL BACK ORDER. I ASKED IF THE PART IS A MANUFACTURE RECALL, BUT IT'S NOT. I'M MIND BOGGLED BECAUSE I HAD THE EGR REPLACED TWICE UNDER MANUFACTURE RECALL FREE OF CHARGE, BUT THIS DEF SENSOR ISN'T. HOW CAN THIS BE?.?.? THIS PART HAS TO DO WITH EMISSIONS STANDARDS AND DUE TO THE PART BEING UNAVAILABLE I'M FORCED TO DRIVE WITH A CHECK ENGINE LIGHT UNTIL THE SHOP IS ABLE TO GET THE PART. WHO KNOWS WHAT FURTHER DAMAGE THIS WILL DO TO THE X5 AND WORST OFF, IF I DON'T GET THIS REPAIRED SOON, I'LL FAIL A SMOG CHECK AND CAN'T DRIVE MY CAR AT ALL. I'M HOPING THE NHTSA OR EPA FOLKS CAN VIEW THIS AS A MANUFACTURE RECALL ISSUE DUE TO A FAULTY PART AND TO MEET EPA STANDARDS....UPDATED 11/13/15 *BF UPDATED 1/4/2016*JS
Official recalls
216V311000 · Power Train:driveline:driveshaft
May 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2011 X5 xDrive 35i, xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles manufactured April 5, 2010, to November 20, 2010, 2011 X5 xDrive35d diesel vehicles manufactured April 7, 2010, to November 20, 2010, and 2011 X6 Active Hybrid vehicles manufactured April 15, 2010, to November 17, 2010. The affected vehicles have a front driveshaft universal joint that may not seal out water and debris from getting in and damaging the joint, which could lead to its failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on July 8, 2016. Owners may contact BMW customer service at 1-800-525-7417.
11V332000 · Engine And Engine Cooling:engine:diesel
Jun 23, 2011
BMW IS RECALLING CERTAIN MODEL YEAR 2011, X5 DIESEL SPORTS ACTIVITY VEHICLES (SAV) MANUFACTURED FROM MARCH 31, 2011, THROUGH MAY 19, 2011. DUE TO A COMPONENT MANUFACTURING ERROR AT THE SUPPLIER, THE WELDS IN THE BELT TENSIONER COULD HAVE INCIPIENT CRACKS. OVER TIME, THIS COULD LEAD A MALFUNCTION OF THE BELT TENSIONER.
Consequence & remedy
Consequence: IF THE BELT TENSIONER FAILS, THERE COULD BE A SUDDEN LOSS OF POWER STEERING ASSISTANCE, IF POWER STEERING ASSIST IS LOST, MANUAL STEERING CAPABILITY IS STILL RETAINED AND COULD INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ENGINE BELT TENSIONER FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417, OR VIA EMAIL AT CUSTOMERRELATIONS@BMWUSA.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ18001 · Idler Pulley Bolt Failure
Opened Apr 18, 2018 · Closed Dec 1, 2018
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Additional source detail variants (3)
Steering
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Steering:hydraulic Power Assist:hose, Piping, And Connections
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Steering:hydraulic Power Assist System
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.