NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
5 reportsClear category filterMileage unknown · Dec 23, 2025
Air Bags
The Front Passenger Seat Occupancy Sensor Mat (CIS) in my 2018 BMW X3 failed at 56,000 miles. This failure is confirmed by the specific BMW fault code 930A1C (Seat Occupancy Detector Malfunction) stored in the Advanced Crash Safety Module (ACSM). The component is currently installed in the vehicle and available for inspection. T…
Read full complaint
The Front Passenger Seat Occupancy Sensor Mat (CIS) in my 2018 BMW X3 failed at 56,000 miles. This failure is confirmed by the specific BMW fault code 930A1C (Seat Occupancy Detector Malfunction) stored in the Advanced Crash Safety Module (ACSM). The component is currently installed in the vehicle and available for inspection. This defect poses a severe safety risk: the system fails to consistently detect a seated front passenger. As a result, the passenger airbag may be disabled and fail to deploy in a collision, significantly increasing the risk of injury or death. The dashboard displays a "Passenger Restraint System" malfunction warning, accompanied by an airbag light and chime. The issue is intermittent and load-dependent. It triggers specifically when an adult passenger occupies the seat for extended periods (e.g., highway driving), indicating a physical fatigue failure of the sensor mat grid under compression. I diagnosed the fault using BMW factory-level diagnostics. However, both the local BMW dealership and BMW North America have refused to cover the diagnosis or repair under the existing warranty extension (SIB 72 01 25) for this exact component, stating my specific VIN is excluded despite the vehicle exhibiting the known safety defect.
NHTSA ODI #11706711
Mileage unknown · Mar 18, 2025
Air BagsSeats
For about 1 year now when there is someone in the passenger seat the car will randomly stop recognizing the seat is occupied and deactivate the air bags on the passenger side front. I took the car to bmw where it was diagnosed as a faulty seat mat. I called bmw corporate to try to get this issue resolved and they were unable to …
Read full complaint
For about 1 year now when there is someone in the passenger seat the car will randomly stop recognizing the seat is occupied and deactivate the air bags on the passenger side front. I took the car to bmw where it was diagnosed as a faulty seat mat. I called bmw corporate to try to get this issue resolved and they were unable to cover it under any warranty. After the battery replacement the car has lost all communication with the passenger seat safety restraints and now has a permanent air bag light
NHTSA ODI #11648941
Mileage unknown · Feb 26, 2025
Air Bags
Passenger Seat Occupancy mat in the seat failed which disabled the passenger airbags. So it is very unsafe to drive the car now. This problem applies to many other BMW cars for which the warranty was extended. Unfortunately my car is not included in the warranty extension and out of pocket cost to repair it is $2500. I can’t aff…
Read full complaint
Passenger Seat Occupancy mat in the seat failed which disabled the passenger airbags. So it is very unsafe to drive the car now. This problem applies to many other BMW cars for which the warranty was extended. Unfortunately my car is not included in the warranty extension and out of pocket cost to repair it is $2500. I can’t afford to fix it. I believe that many other owners experience the same problem leading them to drive unsafe cars or disabling the system using aftermarket solutions. I truly believe that for the safety reasons BMW should extend the warranty for the model of my car.
NHTSA ODI #11645117
Mileage unknown · Aug 14, 2024
Air BagsSeats
Passneger occupancy sensor keeps failing due to a known issue with BMW X3 G01. Seat wiring circuit keeps experiencing electrical problems and failing to detect passenger. This can lead to airbags not deploying in the event of collision. Third time the issue has been repaired and customer was responsible for almost $1200 in costs…
Read full complaint
Passneger occupancy sensor keeps failing due to a known issue with BMW X3 G01. Seat wiring circuit keeps experiencing electrical problems and failing to detect passenger. This can lead to airbags not deploying in the event of collision. Third time the issue has been repaired and customer was responsible for almost $1200 in costs
NHTSA ODI #11608576
2,000 miles · Nov 9, 2018
Air BagsSeat BeltsSteering
2018 BMW X3 M40I: UPON START UP THE VEHICLE DISPLAYS A WARNING 'SEATBELT RESTRAINT SYSTEM MALFUNCTION.' THE CAR THE ENTERS A LIMP MODE AND SAYS TO DRIVE TO THE NEAREST BMW SERVICE CENTER AND THAT SOME SAFETY FEATURES ARE UNAVAILABLE. POWER ASSIST STEERING NO LONGER WORKS, AND THE VEHICLE DEFAULTS TO 4WD MODE. ADDITIONALLY, IT FU…
Read full complaint
2018 BMW X3 M40I: UPON START UP THE VEHICLE DISPLAYS A WARNING 'SEATBELT RESTRAINT SYSTEM MALFUNCTION.' THE CAR THE ENTERS A LIMP MODE AND SAYS TO DRIVE TO THE NEAREST BMW SERVICE CENTER AND THAT SOME SAFETY FEATURES ARE UNAVAILABLE. POWER ASSIST STEERING NO LONGER WORKS, AND THE VEHICLE DEFAULTS TO 4WD MODE. ADDITIONALLY, IT FURTHER STATES AIRBAG FUNCTIONALITY IS LIMITED, AND CRASH AVOIDANCE IS UNAVAILABLE, BUT THAT DRIVING IS STILL POSSIBLE! WHAT'S DISTURBING IS THAT I DISCOVERED THAT MANY OTHER LATE MODEL BMW OWNERS ARE REPORTING THIS SAME ISSUE. THE FEW THAT HAVE HAD IT RESOLVED SAID IT'S A SENSOR FAILURE IN ONE OF THE FRONT SEATS. THIS SENSOR IS TIED TO THE RESTRAINT SYSTEM AND THE AIRBAG. BMW SERVICE CENTER HAS ATTEMPTED TO FIX THIS MALFUNCTION ON MY X3 ON THREE SEPARATE OCCASIONS WITHOUT SUCCESS. I AM WORRIED THAT MY AIRBAGS OR SEATBELT WILL FAIL IN A COLLISION.
NHTSA ODI #11150446
Official recalls
11Oct 15, 2024
BMW of North America, LLC (BMW) is recalling certain 2018-2022 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3 M vehicles. The attachment for the rear cargo rail may become damaged in a rear crash and result in the cargo rail detaching.
Consequence & remedy
Consequence: Interior rear cargo rail detachment during a crash can increase the risk of injury.
Remedy: Dealers will replace the rear cargo rail attachment bolts, free of charge. Owner notification letters were mailed December 12, 2024. Owners may contact BMW customer service at 1-800-525-7417. Vehicles in this recall were previously remedied for this issue under recall number 24V-534 and will need to have the new repair completed.
Jul 17, 2024
BMW of North America, LLC (BMW) is recalling certain 2018-2023 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3 M vehicles. The attachment for the interior cargo rail may become damaged in a rear crash and result in the cargo rail detaching.
Consequence & remedy
Consequence: Interior cargo rail detachment during a rear crash can increase the risk of injury.
Remedy: Dealers will replace the rear cargo rail attachment bolts, free of charge. Owner notification letters were mailed January 2, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jul 8, 2021
BMW of North America, LLC (BMW) is recalling certain 2018-2019 X3 sDrive30i, X3 xDrive30i, X3 M40i and 2019 X4 xDrive30i, and X4 M40i vehicles. The front passenger seat occupant classification system may have been improperly assembled, which could result in the misclassification of the seat as unoccupied, and deactivate the front air bag.
Consequence & remedy
Consequence: A deactivated front air bag will not deploy in the event of a crash, increasing the risk of injury.
Remedy: Dealers will replace the seat foam, which includes the occupant classification system, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:sensor:occupant Classification:front Passenger
BMW of North America, LLC (BMW) is recalling certain 2018-2019 X3 sDrive30i, X3 xDrive30i, X3 M40i and 2019 X4 xDrive30i, and X4 M40i vehicles. The front passenger seat occupant classification system may have been improperly assembled, which could result in the misclassification of the seat as unoccupied, and deactivate the front air bag.
Consequence: A deactivated front air bag will not deploy in the event of a crash, increasing the risk of injury.
Remedy: Dealers will replace the seat foam, which includes the occupant classification system, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Air Bags:frontal
BMW of North America, LLC (BMW) is recalling certain 2018-2019 X3 sDrive30i, X3 xDrive30i, X3 M40i and 2019 X4 xDrive30i, and X4 M40i vehicles. The front passenger seat occupant classification system may have been improperly assembled, which could result in the misclassification of the seat as unoccupied, and deactivate the front air bag.
Consequence: A deactivated front air bag will not deploy in the event of a crash, increasing the risk of injury.
Remedy: Dealers will replace the seat foam, which includes the occupant classification system, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Mar 18, 2020
BMW of North America, LLC (BMW) is recalling certain 2019-2020 X4 xDrive30i and X4 M40i, and 2018-2020 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3M vehicles. The instrument panel casing may not have been tightened properly to the passenger air bag.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, the air bag could damage the instrument panel and cause small pieces of the panel to strike the driver or other occupants, increasing the risk of injury.
Remedy: BMW will notify owners, and dealers will replace the instrument panel casing, free of charge. The recall began May 15, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
BMW of North America, LLC (BMW) is recalling certain 2019-2020 X4 xDrive30i and X4 M40i, and 2018-2020 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3M vehicles. The instrument panel casing may not have been tightened properly to the passenger air bag.
Consequence: In the event of a crash necessitating air bag deployment, the air bag could damage the instrument panel and cause small pieces of the panel to strike the driver or other occupants, increasing the risk of injury.
Remedy: BMW will notify owners, and dealers will replace the instrument panel casing, free of charge. The recall began May 15, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Electrical System: Instrument Cluster/panel
BMW of North America, LLC (BMW) is recalling certain 2019-2020 X4 xDrive30i and X4 M40i, and 2018-2020 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3M vehicles. The instrument panel casing may not have been tightened properly to the passenger air bag.
Consequence: In the event of a crash necessitating air bag deployment, the air bag could damage the instrument panel and cause small pieces of the panel to strike the driver or other occupants, increasing the risk of injury.
Remedy: BMW will notify owners, and dealers will replace the instrument panel casing, free of charge. The recall began May 15, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Sep 27, 2019
BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: The lack of an image in the back-up camera display increases the risk of a crash.
Remedy: BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.
Jul 31, 2019
BMW of North America, LLC (BMW) is recalling certain 2018-2019 X3 sDrive30i, xDrive30i and M40i and 2019 X4 xDrive30i and M40i vehicles. The front seatback frames may have been improperly welded, allowing the seatback to unexpectedly fold forward or rearward.
Consequence & remedy
Consequence: In the event of a crash, there is an increased risk of injury if the seatback folds forward or rearward.
Remedy: BMW will notify owners, and dealers will replace the front seats, free of charge. The recall began September 27, 2019. Owners may contact BMW customer service 1-800-525-7417.
Jul 6, 2018
BMW of North America, LLC (BMW) is recalling certain 2018-2019 BMW X3 sDrive30i, X3 xDrive30i, X3 M40i and certain 2019 X4 xDrive30i and X4 M40i vehicles. The rear brake caliper pistons on these vehicles may have an insufficient coating, potentially reducing rear brake performance.
Consequence & remedy
Consequence: A reduction of braking performance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will bleed the rear brake circuit, free of charge. The recall began August 31, 2018. Owners may contact BMW customer service at 1-800-525-7417.
Jun 21, 2018
BMW of North America, LLC (BMW) is recalling certain 2018 BMW X3 xDrive30i and X3 M40i vehicles. The rear turn signals on the outboard side panel will illuminate red, while the inboard turn signals simultaneously illuminate amber. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Turn signals that flash multiple colors may confuse other drivers, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the rear turn signal lights, and replace if necessary, free of charge. The recall began August 20, 2018. Owners may contact BMW customer service at 1-800-525-7417.
Jun 6, 2018
BMW of North America, LLC (BMW) is recalling certain 2018-2019 BMW X3 xDrive30i, X3 sDrive30i, and X3 M40i vehicles equipped with the "Active Lane Keeping Assistant" option. The steering wheel may be incompatible with the lane keeping assistant function and may not detect if the driver's hands are off the wheel.
Consequence & remedy
Consequence: If the sensors do not properly detect the driver's hands are off the wheel, the driver may not be alerted by one or more warning signals, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the steering wheel, replacing it if necessary, free of charge. The recall began on July 19, 2018. Owners may contact BMW customer service at 1-800-525-7417.
Mar 7, 2018
BMW of North America, LLC (BMW) is recalling certain 2018 BMW X3 xDrive30i and X3 M40i vehicles. The rear spoiler may not have been properly attached during assembly, or may be missing screws, possibly causing the spoiler to detach while driving.
Consequence & remedy
Consequence: If the spoiler detaches while driving, it can become a road hazard, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the spoiler, correcting its attachment as necessary, free of charge. The recall is expected to begin May 1, 2018. Owners may contact BMW customer service at 1-800-525-7417.
Nov 15, 2017
BMW of North America, LLC (BMW) is recalling certain 2018 230i, 230i xDrive, M240i, M240i xDrive, M2, and X3 xDrive 30i SAV vehicles. These vehicles may have an error in the software for the instrument panel, causing the display to not properly illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."
Consequence & remedy
Consequence: If the display does not illuminate during start up or does not illuminate various control and warning symbols while driving, it can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will update the instrument cluster display software, free of charge. The recall is expected to begin January 8, 2018. Owners may contact BMW customer service at 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration