IllustrationDRIVER SIDE HEATED SEAT HEATS UP TO THE POINT OF INJURY. UNUSABLE. *TR
2005 BMW X3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 BMW X3 do not stand out strongly from the model-year median of 86.
About this comparison →How this year compares
Owner complaints by model year
Compare all X3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1325–50K
1650–75K
2275–100K
26100–150K
9150K+
93 reports with mileage · 10 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seats. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports18 fire reports17 injury reports
What owners actually said
103 reportsTL* THE CONTACT OWNS A 2005 BMW X3. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V384000 (AIR BAGS). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 52,000. ..UPDATED 10/21/14 *BF
I BELIEVE THE STEERING ANGLE SENSOR (AKA SZL) IN MY 2005 BMW X3 IS FAULTY AND THUS POSES A SERIOUS SAFETY RISK GIVEN ITS ROLE IN PROVIDING INPUTS TO THE DYNAMIC STABILITY CONTROL (DSC) SYSTEM. IT CERTAINLY WARRANTS INVESTIGATION. MY VEHICLE HAS GONE INTO AN UNCONTROLLED SKID ON THREE OCCASIONS, EACH TIME WHILE TRAVELING DOWNHIL…
Read full complaint
I BELIEVE THE STEERING ANGLE SENSOR (AKA SZL) IN MY 2005 BMW X3 IS FAULTY AND THUS POSES A SERIOUS SAFETY RISK GIVEN ITS ROLE IN PROVIDING INPUTS TO THE DYNAMIC STABILITY CONTROL (DSC) SYSTEM. IT CERTAINLY WARRANTS INVESTIGATION. MY VEHICLE HAS GONE INTO AN UNCONTROLLED SKID ON THREE OCCASIONS, EACH TIME WHILE TRAVELING DOWNHILL AT MODERATE SPEEDS ON CURVES. (ONLY ONCE DID IT DO SO FOLLOWING A LIGHT RAIN; ON ALL OTHER OCCASIONS THE PAVEMENT WAS DRY.) LUCKILY, NO ACCIDENTS OR INJURIES ENSUED. I FIRST NOTICED THE PROBLEM THE YEAR I PURCHASED THE VEHICLE USED IN 2010; THE PREVIOUS OWNER LIKEWISE HAD NOTICED THE ISSUE AND INFORMED ME OF IT AT THE TIME I PURCHASED THE VEHICLE. TODAY, SEPT. 15, 2014, MY LOCAL BMW DEALER PROPOSED REPLACING THE STEERING ANGLE SENSOR (SZL) IN OUR VEHICLE, SAYING A READOUT OF THE FAULT CODES DETECTED FAULTS IN THE SENSOR. I HAVE ELECTED TO REPLACE THE SENSOR AT A COST OF $1098. BASED ON THE SERIOUSNESS OF THE ISSUE, WHICH SOME CURSORY INVESTIGATING ON MY PART APPEARS TO BE A PROBLEM SHARED BY MULTIPLE OWNERS OF SIMILAR MODEL/YEAR VEHICLES, I URGE THE NHTSA TO INVESTIGATE. THANK YOU. *TR
I WAS DRIVING HOME FROM WORK ON I-90 IN WASHINGTON STATE AND FELT A SUDDEN PAINFUL SHARP PIN POINT SENSATION IN MY LEFT UPPER OUTER POSTERIOR THIGH. I THOUGHT I WAS BEING STUCK BY A PIN OR SOMETHING SHARP. I PUT MY HAND DOWN TO PULL OUT THE SHARP OBJECT AND THEN FELT A SMALL SPOT IN MY SEAT THAT WAS BURNING HOT. I ALMOST LOS…
Read full complaint
I WAS DRIVING HOME FROM WORK ON I-90 IN WASHINGTON STATE AND FELT A SUDDEN PAINFUL SHARP PIN POINT SENSATION IN MY LEFT UPPER OUTER POSTERIOR THIGH. I THOUGHT I WAS BEING STUCK BY A PIN OR SOMETHING SHARP. I PUT MY HAND DOWN TO PULL OUT THE SHARP OBJECT AND THEN FELT A SMALL SPOT IN MY SEAT THAT WAS BURNING HOT. I ALMOST LOST CONTROL OF MY CAR FROM THE SEVERITY OF THE PAIN IN MY FINGERS AND THIGH. I TURNED OFF THE SEAT HEATER AND THE HOT SPOT WENT AWAY QUICKLY. WHEN I GOT HOME I TURNED THE HEATER ON AGAIN - AND THE SAME THING HAPPENED. I HAD A DIME SIZED RED BURN MARK ON MY THIGH. THIS WAS ONLY A MINOR INJURY, BUT I AM LUCKY I DID NOT RECEIVE A MORE SERIOUS BURN, AND THAT A FIRE DID NOT START AND THAT I WAS NOT IN AN ACCIDENT. THIS IS AN EXTREMELY DANGEROUS DEFECT. *TR
FRONT PASSENGER SIDE AIR BAG IS TURNED OFF (LIGHT NOTIFICATION), WHEN NO ONE IS IN PASSENGER SEAT AND NO ITEMS ARE ON SEAT THE WARNING LIGHT GOES ON AND BUZZER WILL NOT STOP, AS IF SOME WEIGHT IS ON SEAT. BMW HAS ISSUED RECALL FOR THIS PROBLEM (76536 & 72651), BUT NOT FOR THIS VIN. THIS IS A SEVERE SAFETY ISSUE SINCE AIRBAG IS…
Read full complaint
FRONT PASSENGER SIDE AIR BAG IS TURNED OFF (LIGHT NOTIFICATION), WHEN NO ONE IS IN PASSENGER SEAT AND NO ITEMS ARE ON SEAT THE WARNING LIGHT GOES ON AND BUZZER WILL NOT STOP, AS IF SOME WEIGHT IS ON SEAT. BMW HAS ISSUED RECALL FOR THIS PROBLEM (76536 & 72651), BUT NOT FOR THIS VIN. THIS IS A SEVERE SAFETY ISSUE SINCE AIRBAG IS TURNED OFF BY CAR AND CAN NOT BE TURNED ON BY DRIVER OR PASSENGER. ALSO, HAVE TO HAVE SEAT BELT ACTIVATED ALL THE TIME. HAVE NOTICED THAT SEVERAL PEOPLE HAVE MADE THIS SAME COMPLAINT ONLINE AND BMW HAS NOT CORRECTED ISSUE.
I TOOK MY VEHICLE FOR AN OIL CHANGE AND OTHER MINOR SERVICES AND THE MECHANIC ADVISED "SRS LIGHT ON FOR PASSENGER SEAT OCCUPANCY SENSOR". THE PASSENGER AIR BAG ON-OFF LAMP AND THE AIR BAG WARNING LAMP HAVE BOTH BEEN ILLUMINATED SIMULTANEOUSLY FOR SEVERAL MONTHS. I CALLED BMW CUSTOMER RELATIONS AND WAS ADVISED THAT MY VEHICLE DOE…
Read full complaint
I TOOK MY VEHICLE FOR AN OIL CHANGE AND OTHER MINOR SERVICES AND THE MECHANIC ADVISED "SRS LIGHT ON FOR PASSENGER SEAT OCCUPANCY SENSOR". THE PASSENGER AIR BAG ON-OFF LAMP AND THE AIR BAG WARNING LAMP HAVE BOTH BEEN ILLUMINATED SIMULTANEOUSLY FOR SEVERAL MONTHS. I CALLED BMW CUSTOMER RELATIONS AND WAS ADVISED THAT MY VEHICLE DOES NOT FALL UNDER THE CURRENT FRONT SEAT OCCUPANT PROTECTION MAT RECALL. *TR
UPON TURNING ON MY DRIVER SIDE HEATED SEAT WITHIN 2 MINUTES OF DRIVING STARTED TO SMELL A BURNING AND THEN A BURN/SHOCKING SENSATION ON LEFT THIGH. ADJUSTED WHILE DRIVING THEN REALIZED MY SEAT WAS BURNING ME ON THE LEFT LEG. PULLED OVER AND GOT OUT OF CAR AND SAW MY SEAT WAS SMOLDERING (SMOKE AND BURNING). REALIZED IT MUST BE…
Read full complaint
UPON TURNING ON MY DRIVER SIDE HEATED SEAT WITHIN 2 MINUTES OF DRIVING STARTED TO SMELL A BURNING AND THEN A BURN/SHOCKING SENSATION ON LEFT THIGH. ADJUSTED WHILE DRIVING THEN REALIZED MY SEAT WAS BURNING ME ON THE LEFT LEG. PULLED OVER AND GOT OUT OF CAR AND SAW MY SEAT WAS SMOLDERING (SMOKE AND BURNING). REALIZED IT MUST BE THE HEATED SEAT. TURNED OFF SEAT WARMER AND WAITED FOR 5 MINUTES AND REALIZED HAD A SMALL HOLE THROUGH MY PANTS. AFTER SEAT COOLED, DROVE HOME AND INSPECTED A BURN HOLE BETTER AT HOME AND PUT ICE ON A 1ST TO 2ND DEGREE BURN ON MY LEFT UPPER THIGH. *TR
WHILE DRIVING TO WORK (APPROX. 2 MILE TRIP) ON A COLD MORNING (OUTSIDE TEMP 18 DEG F) TURNED ON DRIVER'S SIDE HEATED CAR SEAT AT MAXIMUM SETTING. PRIOR TO THIS INCIDENT, THE SEAT HEATER HAD FUNCTIONED PROPERLY ALTHOUGH LEFT SIDE OF SEAT ALWAYS SEEMED TO SOMEWHAT HOTTER THAN REST OF SEAT. WITHIN 1.5 MILE, SEAT BECAME EXTREMELY HO…
Read full complaint
WHILE DRIVING TO WORK (APPROX. 2 MILE TRIP) ON A COLD MORNING (OUTSIDE TEMP 18 DEG F) TURNED ON DRIVER'S SIDE HEATED CAR SEAT AT MAXIMUM SETTING. PRIOR TO THIS INCIDENT, THE SEAT HEATER HAD FUNCTIONED PROPERLY ALTHOUGH LEFT SIDE OF SEAT ALWAYS SEEMED TO SOMEWHAT HOTTER THAN REST OF SEAT. WITHIN 1.5 MILE, SEAT BECAME EXTREMELY HOT ON LEFT SIDE OF SEAT BOTTOM 2/3 BACK FROM FRONT AND I BEGAN TO SMELL A STRONG BURNING PLASTIC ODOR IN THE CAR. I IMMEDIATELY TURNED OFF SEAT HEATER. ARRIVED AT OFFICE AND UPON INSPECTION, DISCOVERED A BLACKENED BURNT SPOT ON THE SEAT LEATHER AT THE LOCATION WHERE EXTREME HEAT HAD BEEN. *TR
DRIVER SEAT HEAT MAT GOT TOO HOT CAUSING SMOKE, DAMAGE TO CLOTHING, AND SKIN INJURY IN LESS THAN A MINUTE AFTER TURNING THE SYSTEM ON HIGH. THE SEAT HAD BEEN FUNCTIONING NORMALLY THE DAY BEFORE. THE SEAT COVER IS VISIBLY DAMAGED AT A SINGLE POINT ABOUT THE SIZE OF A QUARTER. THE SPOT IS ON THE LEFT SEAT PAN BOLSTER 2/3'S BACK …
Read full complaint
DRIVER SEAT HEAT MAT GOT TOO HOT CAUSING SMOKE, DAMAGE TO CLOTHING, AND SKIN INJURY IN LESS THAN A MINUTE AFTER TURNING THE SYSTEM ON HIGH. THE SEAT HAD BEEN FUNCTIONING NORMALLY THE DAY BEFORE. THE SEAT COVER IS VISIBLY DAMAGED AT A SINGLE POINT ABOUT THE SIZE OF A QUARTER. THE SPOT IS ON THE LEFT SEAT PAN BOLSTER 2/3'S BACK FROM THE FRONT EDGE OF THE SEAT PAN. *TR
DRIVER'S SEAT AT LEFT LEG BOLSTER AREA HEATS UP WHEN SEAT HEATER ELEMENT IS ACTIVATED. SHOCKING OR BURNING SENSATION IS FELT DUE TO OVERHEAT PROBLEM. *TR
Official recalls
108V384000 · Air Bags:frontal
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).