NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
103 reports178,000 miles · Aug 10, 2021
Seat Belts
The contact owns a 2005 BMW X3. The contact stated while starting the vehicle, the air bag warning light was illuminated. The contact read the owner’s manual and saw that the failure indicated that the driver’s side seat belt receiver was faulty. The dealer was made aware of the failure and ordered the driver’s side seat belt re…
Read full complaint
The contact owns a 2005 BMW X3. The contact stated while starting the vehicle, the air bag warning light was illuminated. The contact read the owner’s manual and saw that the failure indicated that the driver’s side seat belt receiver was faulty. The dealer was made aware of the failure and ordered the driver’s side seat belt receiver replacement part. The dealer originally informed the contact that the repair would be free of charge but later informed the contact that she had to pay for the repair. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 178,000.
NHTSA ODI #11428513
180,000 miles · May 25, 2020
Electrical SystemFire
VEHICLE CAUGHT FIRE AND BURNED TO THE GROUND TAKING MY OTHER CAR WITH IT. THIS HAPPENED WHILE PARKED AFTER WASHING THE CARPETS.
NHTSA ODI #11325900
104,700 miles · Jun 17, 2019
Engine
TL* THE CONTACT OWNS A 2005 BMW X3. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS PURCHASED USED ON MAY 28, 2019. LEITH PORSCHE (700 AUTOPARK BLVD, CARY, NC 27511) DIAGNOSED AND REPAIRED THE CHECK ENGINE INDICATOR, BUT THE FAILURE RECURRED. THE DEALER STATED THAT IF THE CHECK ENGINE INDICATOR IL…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW X3. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS PURCHASED USED ON MAY 28, 2019. LEITH PORSCHE (700 AUTOPARK BLVD, CARY, NC 27511) DIAGNOSED AND REPAIRED THE CHECK ENGINE INDICATOR, BUT THE FAILURE RECURRED. THE DEALER STATED THAT IF THE CHECK ENGINE INDICATOR ILLUMINATED AGAIN, THE CONTACT SHOULD TAKE THE VEHICLE TO A BMW DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 104,700.
NHTSA ODI #11220637
168,000 miles · Feb 5, 2019
Seats
RIVER'S SEAT HEATING UNIT OVERHEATS WHEN ON HIGH SETTING, TO THE POINT OF BURNING SKIN THROUGH THE SEAT AND CLOTHING. LOWER LEFT LUMBAR . PER SERVICE SHOP, THE SEAT HEATER GRID IS BROKEN, CAUSING 40 DEGREE HIGHER TEMPERATURES THAN NORMAL IN THE LEFT LEG AREA. ONGOING ISSUE, NOT A SINGLE OCCURRENCE
NHTSA ODI #11174407
90,000 miles · Jan 9, 2019
Air Bags
ALL OTHER 2005 BMW X3 HAVE A RECALL EXCEPT FOR MINE. I HAVE HAD MY AIRBAG LIGHT COME ON TWICE. I HAVE HAD MY SEAT SENSOR ON MY PASSENGER SIDE REPLACED ONCE. I FEEL LIKE THE RECALL SHOULD COVER MY VEHICLE.
NHTSA ODI #11166103
175,000 miles · Aug 9, 2018
Seats
THE DRIVER SEAT HEATING ELEMENT BURNT A HOLE THROUGH THE LEATHER SEAT. THIS HAPPENED WHILE I WAS DRIVING AND WEARING MY SEAT BELT. I FELT THE HEAT THROUGH MY CLOTHES AND I WAS AFRAID IT WOULD CATCH MY CLOTHES ON FIRE. I PULLED OVER UNSTRAPPED MY SEAT BELT AND EXAMINED THE SEAT TO FIND THE HOLE BURNT THROUGH.
NHTSA ODI #11118745
118,000 miles · Apr 30, 2018
Electrical SystemSeatsFire
TL* THE CONTACT OWNS A 2005 BMW X3. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT NOTICED A BURNING ODOR INSIDE THE VEHICLE. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED SMOKE COMING FROM THE FRONT SEAT LUMBAR CUSHION OF THE DRIVER'S SEAT. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO TAYLOR BMW (4180…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW X3. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT NOTICED A BURNING ODOR INSIDE THE VEHICLE. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED SMOKE COMING FROM THE FRONT SEAT LUMBAR CUSHION OF THE DRIVER'S SEAT. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO TAYLOR BMW (4180 WASHINGTON RD, EVANS, GA 30809, (706) 868-6400) WHERE IT WAS DIAGNOSED THAT THE FRONT DRIVER'S SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.
NHTSA ODI #11091068
85,000 miles · Jan 25, 2018
SeatsFire
DAUGHTER TURNED ON VEHICLE, TURNED ON HEATED DRIVERS SEAT, AS SHE WAS DRIVING ON A CITY STREET, BEGAN TO SMELL SOMETHING BURNING, PULLED CAR OVER & GOT OUT, LEFT VEHICLE RUNNING, CONTINUED TO SMELL BURNING AND BEGAN TO SEE SMOKE. SAW THAT A BURN HOLE WAS FORMING IN THE LEFT SIDE, BOTTOM OF LEATHER SEAT. TURNED SEAT HEATER OFF …
Read full complaint
DAUGHTER TURNED ON VEHICLE, TURNED ON HEATED DRIVERS SEAT, AS SHE WAS DRIVING ON A CITY STREET, BEGAN TO SMELL SOMETHING BURNING, PULLED CAR OVER & GOT OUT, LEFT VEHICLE RUNNING, CONTINUED TO SMELL BURNING AND BEGAN TO SEE SMOKE. SAW THAT A BURN HOLE WAS FORMING IN THE LEFT SIDE, BOTTOM OF LEATHER SEAT. TURNED SEAT HEATER OFF AND SMELL AND SMOKE DIMINISHED. UPON INSPECTION OF HE CLOTHING IT WAS ALSO DISCOVERED THAT THE SEAT BEGAN TO BUT A HOLE IN HER OUTER JACKET. IT DID NOT BURN THROUGH HER CLOTHING AND SHE WAS NOT INJURED (THANKFULLY).
NHTSA ODI #11064879
144,000 miles · Jan 23, 2018
Air BagsElectrical SystemService Brakes
THE CAR IS HAVING A TRIAD OF LIGHTS WITH NO PROBLEM FOUND. KEEP GETTING 4X4, ABS, BRAKE, AND NOW MY PASSENGER SEAT AIRBAG WARNING LIGHTS. AND RESEARCHING ONLINE I FOUND THAT SMILIAR YEAR MODELS WERE RECALLED FOR THE AIRBAG SENSOR.
NHTSA ODI #11064318
126,000 miles · Dec 13, 2017
Power Train
IT LOOKS LIKE THAT THE SHIFTING OF THE AUTOMATIC TRANSMISSION IN BMW X3, 2005 3.0L ARE KIND OF DELAYED. I NOTICED WHILE I PUSH THE GAS PEDAL AND SPEED IS ACCELERATING REAL WELL TO THE POINT WHEN GEAR SUPPOSED TO BE SWITCHED BUT IT DOES NOT HAPPEN. I HAVE TO TEMPORARILY, FOR ONE SEC, REDUCE THE GAS ACCELERATION AND THEN IT IS S…
Read full complaint
IT LOOKS LIKE THAT THE SHIFTING OF THE AUTOMATIC TRANSMISSION IN BMW X3, 2005 3.0L ARE KIND OF DELAYED. I NOTICED WHILE I PUSH THE GAS PEDAL AND SPEED IS ACCELERATING REAL WELL TO THE POINT WHEN GEAR SUPPOSED TO BE SWITCHED BUT IT DOES NOT HAPPEN. I HAVE TO TEMPORARILY, FOR ONE SEC, REDUCE THE GAS ACCELERATION AND THEN IT IS SHIFTING. AS A RESULT, THE CAR DRIVES IS ON LOWER GEARS THAN IT SHOULD. THE ENGINE RMP IS ALWAYS ON A HIGH SIDE. I AM WONDERING WHAT CAN BE DONE TO RESOLVE THIS ISSUE. WILL THE CHANGE OF THE TRANSMISSION OIL CHANGE THIS BEHAVIOR. I HAVE SEEN BLOG WHICH TALK ABOUT EGS UPDATE BMW X3.
NHTSA ODI #11054457
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Illustration