I WAS DRIVING HOME FROM WORK ON I-90 IN WASHINGTON STATE AND FELT A SUDDEN PAINFUL SHARP PIN POINT SENSATION IN MY LEFT UPPER OUTER POSTERIOR THIGH. I THOUGHT I WAS BEING STUCK BY A PIN OR SOMETHING SHARP. I PUT MY HAND DOWN TO PULL OUT THE SHARP OBJECT AND THEN FELT A SMALL SPOT IN MY SEAT THAT WAS BURNING HOT. I ALMOST LOS…
Read full complaint
I WAS DRIVING HOME FROM WORK ON I-90 IN WASHINGTON STATE AND FELT A SUDDEN PAINFUL SHARP PIN POINT SENSATION IN MY LEFT UPPER OUTER POSTERIOR THIGH. I THOUGHT I WAS BEING STUCK BY A PIN OR SOMETHING SHARP. I PUT MY HAND DOWN TO PULL OUT THE SHARP OBJECT AND THEN FELT A SMALL SPOT IN MY SEAT THAT WAS BURNING HOT. I ALMOST LOST CONTROL OF MY CAR FROM THE SEVERITY OF THE PAIN IN MY FINGERS AND THIGH. I TURNED OFF THE SEAT HEATER AND THE HOT SPOT WENT AWAY QUICKLY. WHEN I GOT HOME I TURNED THE HEATER ON AGAIN - AND THE SAME THING HAPPENED. I HAD A DIME SIZED RED BURN MARK ON MY THIGH. THIS WAS ONLY A MINOR INJURY, BUT I AM LUCKY I DID NOT RECEIVE A MORE SERIOUS BURN, AND THAT A FIRE DID NOT START AND THAT I WAS NOT IN AN ACCIDENT. THIS IS AN EXTREMELY DANGEROUS DEFECT. *TR
NHTSA ODI #10584212
107,100 miles · Feb 28, 2014
Seats
UPON TURNING ON MY DRIVER SIDE HEATED SEAT WITHIN 2 MINUTES OF DRIVING STARTED TO SMELL A BURNING AND THEN A BURN/SHOCKING SENSATION ON LEFT THIGH. ADJUSTED WHILE DRIVING THEN REALIZED MY SEAT WAS BURNING ME ON THE LEFT LEG. PULLED OVER AND GOT OUT OF CAR AND SAW MY SEAT WAS SMOLDERING (SMOKE AND BURNING). REALIZED IT MUST BE…
Read full complaint
UPON TURNING ON MY DRIVER SIDE HEATED SEAT WITHIN 2 MINUTES OF DRIVING STARTED TO SMELL A BURNING AND THEN A BURN/SHOCKING SENSATION ON LEFT THIGH. ADJUSTED WHILE DRIVING THEN REALIZED MY SEAT WAS BURNING ME ON THE LEFT LEG. PULLED OVER AND GOT OUT OF CAR AND SAW MY SEAT WAS SMOLDERING (SMOKE AND BURNING). REALIZED IT MUST BE THE HEATED SEAT. TURNED OFF SEAT WARMER AND WAITED FOR 5 MINUTES AND REALIZED HAD A SMALL HOLE THROUGH MY PANTS. AFTER SEAT COOLED, DROVE HOME AND INSPECTED A BURN HOLE BETTER AT HOME AND PUT ICE ON A 1ST TO 2ND DEGREE BURN ON MY LEFT UPPER THIGH. *TR
NHTSA ODI #10566437
101,720 miles · Dec 3, 2013
Seats
WHILE DRIVING TO WORK (APPROX. 2 MILE TRIP) ON A COLD MORNING (OUTSIDE TEMP 18 DEG F) TURNED ON DRIVER'S SIDE HEATED CAR SEAT AT MAXIMUM SETTING. PRIOR TO THIS INCIDENT, THE SEAT HEATER HAD FUNCTIONED PROPERLY ALTHOUGH LEFT SIDE OF SEAT ALWAYS SEEMED TO SOMEWHAT HOTTER THAN REST OF SEAT. WITHIN 1.5 MILE, SEAT BECAME EXTREMELY HO…
Read full complaint
WHILE DRIVING TO WORK (APPROX. 2 MILE TRIP) ON A COLD MORNING (OUTSIDE TEMP 18 DEG F) TURNED ON DRIVER'S SIDE HEATED CAR SEAT AT MAXIMUM SETTING. PRIOR TO THIS INCIDENT, THE SEAT HEATER HAD FUNCTIONED PROPERLY ALTHOUGH LEFT SIDE OF SEAT ALWAYS SEEMED TO SOMEWHAT HOTTER THAN REST OF SEAT. WITHIN 1.5 MILE, SEAT BECAME EXTREMELY HOT ON LEFT SIDE OF SEAT BOTTOM 2/3 BACK FROM FRONT AND I BEGAN TO SMELL A STRONG BURNING PLASTIC ODOR IN THE CAR. I IMMEDIATELY TURNED OFF SEAT HEATER. ARRIVED AT OFFICE AND UPON INSPECTION, DISCOVERED A BLACKENED BURNT SPOT ON THE SEAT LEATHER AT THE LOCATION WHERE EXTREME HEAT HAD BEEN. *TR
NHTSA ODI #10554732
131,450 miles · Nov 24, 2013
SeatsInjury
DRIVER SEAT HEAT MAT GOT TOO HOT CAUSING SMOKE, DAMAGE TO CLOTHING, AND SKIN INJURY IN LESS THAN A MINUTE AFTER TURNING THE SYSTEM ON HIGH. THE SEAT HAD BEEN FUNCTIONING NORMALLY THE DAY BEFORE. THE SEAT COVER IS VISIBLY DAMAGED AT A SINGLE POINT ABOUT THE SIZE OF A QUARTER. THE SPOT IS ON THE LEFT SEAT PAN BOLSTER 2/3'S BACK …
Read full complaint
DRIVER SEAT HEAT MAT GOT TOO HOT CAUSING SMOKE, DAMAGE TO CLOTHING, AND SKIN INJURY IN LESS THAN A MINUTE AFTER TURNING THE SYSTEM ON HIGH. THE SEAT HAD BEEN FUNCTIONING NORMALLY THE DAY BEFORE. THE SEAT COVER IS VISIBLY DAMAGED AT A SINGLE POINT ABOUT THE SIZE OF A QUARTER. THE SPOT IS ON THE LEFT SEAT PAN BOLSTER 2/3'S BACK FROM THE FRONT EDGE OF THE SEAT PAN. *TR
NHTSA ODI #10553620
92,000 miles · Nov 19, 2013
SeatsInjury
DRIVER'S SEAT AT LEFT LEG BOLSTER AREA HEATS UP WHEN SEAT HEATER ELEMENT IS ACTIVATED. SHOCKING OR BURNING SENSATION IS FELT DUE TO OVERHEAT PROBLEM. *TR
NHTSA ODI #10552915
83,000 miles · Nov 6, 2013
SeatsInjury
I TURNED ON THE HEATED SEAT FEATURE ON MY 2005 BMW X3 AND ABOUT 5 MINUTES LATER MY LEG STARTED TO GET VERY HOT. I REACHED DOWN WITH MY HAND AND IT WAS SO HOT THAT IT BURNT MY HAND. I STARTED TO SMELL SMOKE AND QUICKLY TURNED OFF MY HEATED SEAT. WHEN I GOT HOME I LOOKED ON MY DRIVER SEAT AND NOTICED A SMALL BROWN BURNT SPOT ON…
Read full complaint
I TURNED ON THE HEATED SEAT FEATURE ON MY 2005 BMW X3 AND ABOUT 5 MINUTES LATER MY LEG STARTED TO GET VERY HOT. I REACHED DOWN WITH MY HAND AND IT WAS SO HOT THAT IT BURNT MY HAND. I STARTED TO SMELL SMOKE AND QUICKLY TURNED OFF MY HEATED SEAT. WHEN I GOT HOME I LOOKED ON MY DRIVER SEAT AND NOTICED A SMALL BROWN BURNT SPOT ON THE LEFT SIDE CUSHION OF MY DRIVER SIDE SEAT. THANKFULLY I NOTICED IT RIGHT AWAY, IF IT WAS ON ANY LONGER I'M NOT SURE WHAT WOULD HAVE HAPPENED! THIS IS VERY DANGEROUS AND I COULD HAVE BEEN BADLY BURNT. *TR
NHTSA ODI #10551082
79,000 miles · Jun 6, 2013
Seats
WHEN I USE THE HEATED SEAT ON THE DRIVERS SIDE, THERE IS A HOT SPOT THAT GETS SO HOT IF YOU DON'T ROLL ONTO YOUR RIGHT HIP YOU WILL GET A SERIOUS BURN. *TR
NHTSA ODI #10515512
148,500 miles · Mar 31, 2013
Seats
WHILE USING THE HEATING DEVICE FOR THE SEATS I SMELLED SOMETHING BURNING AND FELT HEAT ON MY PANTS. I TURNED THE HEATING DEVICE OFF. THERE WAS A SMALL BURN STAIN LEFT ON THE SEAT, WHICH HAS TURNED INTO A SMALL HOLE. *TR
NHTSA ODI #10505123
92,245 miles · Mar 17, 2013
SeatsInjury
UPON DRIVING MY X3 I TURNED ON MY DRIVERS SIDE SEAT HEATER AND WITHIN A FEW MINUTES IT STARTED GETTING SO HOT THAT IT BEGAN TO BURN THE TOP PART OF MY LEFT LEG. I HAD TO TURN IT OFF AND LIFT MY LEG OFF THE SURFACE OF THE SEAT A BIT UNTIL IT COOLED OFF. IT APPEARS THERE IS A PROBLEM ON THE LEFT SIDE OF THE SEAT (BOLSTER). IT HAP…
Read full complaint
UPON DRIVING MY X3 I TURNED ON MY DRIVERS SIDE SEAT HEATER AND WITHIN A FEW MINUTES IT STARTED GETTING SO HOT THAT IT BEGAN TO BURN THE TOP PART OF MY LEFT LEG. I HAD TO TURN IT OFF AND LIFT MY LEG OFF THE SURFACE OF THE SEAT A BIT UNTIL IT COOLED OFF. IT APPEARS THERE IS A PROBLEM ON THE LEFT SIDE OF THE SEAT (BOLSTER). IT HAPPENS NOW EVERYTIME I ATTEMPT TO USE IT...I HAVE OWNED THIS VEHICLE FROM DAY ONE AND NEVER HAD THIS PROBLEM BEFORE. I HAVE NOT SMELLED ANY BURNING ODORS YET BUT THERE IS A SERIOUS PROBLEM WITH THE SEAT. MY WIFE HAS EXPERIENCED THE SAME THING !...THIS NEEDS TO BE ADDRESSED BY BMW AND CORRECTED BEFORE THERE IS A FIRE OR BODILY INJURY. SO FOR SAFETY REASONS AND PREVENTING BURNS I AM UNABLE TO USE THIS FEATURE I PAID SO DEARLY FOR...I WILL BE CONTACTING THE DEALERSHIP ON MONDAY TO ADVISE THEM OF THIS PROBLEM. *TR
NHTSA ODI #10503317
99,000 miles · Feb 3, 2013
Air BagsSeats
I HAD JUST STARTED THE CAR AND THE AIRBAG LIGHT CAME ON IN THE INSTRUMENT CLUSTER. THE PASSENGER AIR BAG ON/OFF LIGHT WAS ALSO ILLUMINATED. FROM THAT TIME ON BOTH LIGHTS ARE ON AND I'M CONCERNED THAT WE DON'T HAVE A PASSENGER AIRBAG. I'M GUESSING IT HAS SOMETHING TO DO WITH THAT SENSOR THAT TELLS IF SOMEONE IS SITTING IN THE …
Read full complaint
I HAD JUST STARTED THE CAR AND THE AIRBAG LIGHT CAME ON IN THE INSTRUMENT CLUSTER. THE PASSENGER AIR BAG ON/OFF LIGHT WAS ALSO ILLUMINATED. FROM THAT TIME ON BOTH LIGHTS ARE ON AND I'M CONCERNED THAT WE DON'T HAVE A PASSENGER AIRBAG. I'M GUESSING IT HAS SOMETHING TO DO WITH THAT SENSOR THAT TELLS IF SOMEONE IS SITTING IN THE PASSENGER SEAT. *TR
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
2005 BMW X3 Problems, Complaints & Recalls | Skip That Year
Illustration