IllustrationRIVER'S SEAT HEATING UNIT OVERHEATS WHEN ON HIGH SETTING, TO THE POINT OF BURNING SKIN THROUGH THE SEAT AND CLOTHING. LOWER LEFT LUMBAR . PER SERVICE SHOP, THE SEAT HEATER GRID IS BROKEN, CAUSING 40 DEGREE HIGHER TEMPERATURES THAN NORMAL IN THE LEFT LEG AREA. ONGOING ISSUE, NOT A SINGLE OCCURRENCE
2005 BMW X3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 BMW X3 do not stand out strongly from the model-year median of 86.
About this comparison →How this year compares
Owner complaints by model year
Compare all X3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1325–50K
1650–75K
2275–100K
26100–150K
9150K+
93 reports with mileage · 10 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seats. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports18 fire reports17 injury reports
Seats complaints
48 reportsTHE DRIVER SEAT HEATING ELEMENT BURNT A HOLE THROUGH THE LEATHER SEAT. THIS HAPPENED WHILE I WAS DRIVING AND WEARING MY SEAT BELT. I FELT THE HEAT THROUGH MY CLOTHES AND I WAS AFRAID IT WOULD CATCH MY CLOTHES ON FIRE. I PULLED OVER UNSTRAPPED MY SEAT BELT AND EXAMINED THE SEAT TO FIND THE HOLE BURNT THROUGH.
TL* THE CONTACT OWNS A 2005 BMW X3. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT NOTICED A BURNING ODOR INSIDE THE VEHICLE. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED SMOKE COMING FROM THE FRONT SEAT LUMBAR CUSHION OF THE DRIVER'S SEAT. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO TAYLOR BMW (4180…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW X3. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT NOTICED A BURNING ODOR INSIDE THE VEHICLE. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED SMOKE COMING FROM THE FRONT SEAT LUMBAR CUSHION OF THE DRIVER'S SEAT. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO TAYLOR BMW (4180 WASHINGTON RD, EVANS, GA 30809, (706) 868-6400) WHERE IT WAS DIAGNOSED THAT THE FRONT DRIVER'S SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.
DAUGHTER TURNED ON VEHICLE, TURNED ON HEATED DRIVERS SEAT, AS SHE WAS DRIVING ON A CITY STREET, BEGAN TO SMELL SOMETHING BURNING, PULLED CAR OVER & GOT OUT, LEFT VEHICLE RUNNING, CONTINUED TO SMELL BURNING AND BEGAN TO SEE SMOKE. SAW THAT A BURN HOLE WAS FORMING IN THE LEFT SIDE, BOTTOM OF LEATHER SEAT. TURNED SEAT HEATER OFF …
Read full complaint
DAUGHTER TURNED ON VEHICLE, TURNED ON HEATED DRIVERS SEAT, AS SHE WAS DRIVING ON A CITY STREET, BEGAN TO SMELL SOMETHING BURNING, PULLED CAR OVER & GOT OUT, LEFT VEHICLE RUNNING, CONTINUED TO SMELL BURNING AND BEGAN TO SEE SMOKE. SAW THAT A BURN HOLE WAS FORMING IN THE LEFT SIDE, BOTTOM OF LEATHER SEAT. TURNED SEAT HEATER OFF AND SMELL AND SMOKE DIMINISHED. UPON INSPECTION OF HE CLOTHING IT WAS ALSO DISCOVERED THAT THE SEAT BEGAN TO BUT A HOLE IN HER OUTER JACKET. IT DID NOT BURN THROUGH HER CLOTHING AND SHE WAS NOT INJURED (THANKFULLY).
WHEN I TURNED ON THE DRIVER'S SIDE SEAT HEATER, THE SEAT HEATER BURNED THROUGH AND BURNED A HOLE THROUGH MY CLOTHES
PASSENGER AIR SAYS OFF WHEN A PASSENGER IS IN SEAT ## VIN PASSED ## BMW X3 2005 ##
BOTH SEATS. PURCHASED THIS VEHICLE WITH 183K MILES. WAS GETTING COLD OUT, TURNED ON THE HEATED SEAT FUNCTION AND NOTICED A BURNING SMELL UPON DRIVING DOWN THE COUNTRY ROADS FROM MY HOUSE. THE SIDE OF THE DRIVERS SEAT MELTED THROUGH. COULD SEE IT GLOWING INSIDE OF THE SEAT. SOMEONE HAD DONE A SEAT REPAIR PREVIOUSLY TO COVER THIS…
Read full complaint
BOTH SEATS. PURCHASED THIS VEHICLE WITH 183K MILES. WAS GETTING COLD OUT, TURNED ON THE HEATED SEAT FUNCTION AND NOTICED A BURNING SMELL UPON DRIVING DOWN THE COUNTRY ROADS FROM MY HOUSE. THE SIDE OF THE DRIVERS SEAT MELTED THROUGH. COULD SEE IT GLOWING INSIDE OF THE SEAT. SOMEONE HAD DONE A SEAT REPAIR PREVIOUSLY TO COVER THIS ISSUE. APPROX. 1 YEAR LATER I WAS DRIVING DOWN THE HIGHWAY WHEN MY PASSENGER HAD TURNED ON HIS HEATED SEAT. HE STARTED YELLING AND NOTICED THE SEAT HAD BURNED THROUGH THE LEATHER. LUCKILY NO ACCIDENTS WERE CAUSED.
THE LEFT SIDE OF THE DRIVERS SIDE SEAT HEATER HAS OVERHEATED AND BURNED THROUGH THE LEATHER AND MY PANTS. THERE APPEARS TO BE SIMILAR COMPLAINTS ON THIS WEBSITE AND A NHTSA RECALL BULLETIN NUMBER 04V575000 FOR OLDER 5 SERIES VEHICLES. I THINK THIS INVESTIGATION SHOULD BE EXPANDED SINCE SO MANY PEOPLE HAVE EXPERIENCED THIS BEHAVI…
Read full complaint
THE LEFT SIDE OF THE DRIVERS SIDE SEAT HEATER HAS OVERHEATED AND BURNED THROUGH THE LEATHER AND MY PANTS. THERE APPEARS TO BE SIMILAR COMPLAINTS ON THIS WEBSITE AND A NHTSA RECALL BULLETIN NUMBER 04V575000 FOR OLDER 5 SERIES VEHICLES. I THINK THIS INVESTIGATION SHOULD BE EXPANDED SINCE SO MANY PEOPLE HAVE EXPERIENCED THIS BEHAVIOR.......UPDATED 12/03/15*BF *TR
TWO MINUTES AFTER TURNING ON DRIVER'S SIDE SEAT HEATER, I BEGAN TO SMELL SOMETHING BURNING. LOWER LEFT LUMBAR SECTION OF THE SEAT WAS EXTREMELY HOT, FELT HOT INSTANTLY EVEN THROUGH A WINTER COAT AND SWEATSHIRT. IMMEDIATELY TURNED THE SEAT HEATER OFF. EXTREMELY CONSIDERED THE CAR WOULD CATCH FIRE. CAR HAS 102,000 MILES. NO VISI…
Read full complaint
TWO MINUTES AFTER TURNING ON DRIVER'S SIDE SEAT HEATER, I BEGAN TO SMELL SOMETHING BURNING. LOWER LEFT LUMBAR SECTION OF THE SEAT WAS EXTREMELY HOT, FELT HOT INSTANTLY EVEN THROUGH A WINTER COAT AND SWEATSHIRT. IMMEDIATELY TURNED THE SEAT HEATER OFF. EXTREMELY CONSIDERED THE CAR WOULD CATCH FIRE. CAR HAS 102,000 MILES. NO VISIBLE WEAR OR BURN MARKS ON THIS SEAT.
I OWN A 2005 BMW X3, PURCHASED NEW 5-5-05. ON 12-19-11, WHILE AT THE DEALER FOR SERVICE, TECH ADVISED THAT DURING SHORT TEST, HE NOTED FAULTED PASS SEAT MAT SENSOR. DEALER REPLACED PASS SEAT MAT SENSOR AND ENABLED. AT NO TIME WERE PRIOR RECALLS ON THIS ISSUE MENTIONED NOR WAS I PROVIDED DOCUMENTATION CONCERNING ANY EXTENDED WARR…
Read full complaint
I OWN A 2005 BMW X3, PURCHASED NEW 5-5-05. ON 12-19-11, WHILE AT THE DEALER FOR SERVICE, TECH ADVISED THAT DURING SHORT TEST, HE NOTED FAULTED PASS SEAT MAT SENSOR. DEALER REPLACED PASS SEAT MAT SENSOR AND ENABLED. AT NO TIME WERE PRIOR RECALLS ON THIS ISSUE MENTIONED NOR WAS I PROVIDED DOCUMENTATION CONCERNING ANY EXTENDED WARRANTY. ON 5-14-15 (NOTE THE DATE) THE SRS WARNING LIGHT ON THE DASH CAME ON AND REMAINED LIT WHILE THE PASS SEAT AIR BAG LIGHT WOULD NOT GO OFF. TOOK CAR TO DEALER 5-19-15. THEY CONFIRMED THE SAME SEAT MAT SENSOR THEY REPLACED ON 12-19-11 WAS AGAIN FAULTY. HOWEVER, THIS TIME THEY WOULD NOT REPLACE AS IT WAS BEYOND THE HERETOFORE "EXTENDED WARRANTY" BY 14 DAYS. TOOK VEHICLE TO LOCAL SHOP WHO REPLACED SEAT MAT SENSOR. FAULTY SEAT MAT SENSOR RETAINED FOR POSSIBLE TESTING. THIS IS A SIGNIFICANT SAFETY ISSUE THAT BMW IS IGNORING. HOW MANY MORE COMPLAINTS NEED TO BE MADE BEFORE THIS ISSUE IS RESOLVED? DO PEOPLE NEED TO BE INJURED (OR WORSE) BEFORE BMW IS HELD ACCOUNTABLE? WITH SEAT BAG RECALLS BEING IN THE NEWS DAILY, HOW MUCH BAD PUBLICITY DOES BMW WANT BEFORE THEY ACTUALLY DO WHAT IS RIGHT?
Official recalls
108V384000 · Air Bags:frontal
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).