IllustrationINSULATION ON WIRING INSIDE THE HEADLIGHT ASSEMBLY IS CRACKING AND FALLING OFF WIRING HARNESS CAUSING A SHORT AND BLOWN FUSE WHILE DRIVING ON CITY STREET.
2004 BMW X3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 BMW X3 do not stand out strongly from the model-year median of 86.
About this comparison →How this year compares
Owner complaints by model year
Compare all X3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
290–25K
1325–50K
1850–75K
2075–100K
19100–150K
7150K+
106 reports with mileage · 32 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seats. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports13 fire reports17 injury reports
Exterior Lighting complaints
6 reportsTHE LAMPS IN THE REAR TAIL LIGHT ASSEMBLY DO NOT WORK. THE CONNECTION IS CORRODED. SIMILAR ITEM WAS UNDER A RECALL FOR 2002-05 3 SERIES SEDANS (BMW RECALL CAMPAIGN 11V-438) AND THIS X3 SHARES MANY COMPONENTS WITH THE SEDAN. THE LIGHTING ASSEMBLY/CONNECTOR IS SUSPECTED TO BE ONE OF THEM.
ON JANUARY 23, 2012 AFTER A WHOLE WEEKEND OF DOWNPOUR RAIN, I GET INTO MY X3 TO NOTICE WATER ON THE CENTER CONSOLE (NEAR MY CUP HOLDER) I LOOK UP AND NOTICE THE WATER IS DRIPPING FROM THE TOP MIDDLE CONSOLE (WHERE THE MOON ROOF CONTROL, AIR BAG BUTTON AND SOS CALL BUTTON ARE LOCATED). NOT ONLY WAS IT DRIPPING WATER BUT THE WHOLE…
Read full complaint
ON JANUARY 23, 2012 AFTER A WHOLE WEEKEND OF DOWNPOUR RAIN, I GET INTO MY X3 TO NOTICE WATER ON THE CENTER CONSOLE (NEAR MY CUP HOLDER) I LOOK UP AND NOTICE THE WATER IS DRIPPING FROM THE TOP MIDDLE CONSOLE (WHERE THE MOON ROOF CONTROL, AIR BAG BUTTON AND SOS CALL BUTTON ARE LOCATED). NOT ONLY WAS IT DRIPPING WATER BUT THE WHOLE AREA AROUND BUT IT WAS SOAKED AND WET. AFTER READING ABOUT THIS ON-LINE THAT OTHER PEOPLE HAVE AND ARE EXPERIENCING THIS WATER LEAK PROBLEM, I REALIZED I NEED TO CHECK THE OTHER AREAS PEOPLE MENTION THEY HAD WATER LEAKS. THAT'S WHEN I CHECKED THE FLOOR ON BOTH THE DRIVER AND PASSENGER SIDE AND TO MY SURPRISE THE DRIVER SIDE HAD MORE WATER THAN WHAT I COULD EVER IMAGINE, IT WAS DRENCHED. SO NOW THAT I HAVE ALL THIS WATER IN MY CAR IT LOOKS LIKE IT HAS CAUSED SOME PROBLEMS WITH MY SOS BUTTON. WITHOUT ME TOUCHING IT, IT TRIES TO CALLS AND DOESN'T GET A CONNECTION. IT READS BMW PHONE INACTIVE AND IT KEEPS MAKING A NOISE THAT COMES THROUGH THE SPEAKERS. I'VE ALSO NOTICED THAT LIGHT FROM THE MIDDLE TOP CONSOLE IS NOT WORKING CORRECTLY. I AM SURE I'M GOING TO END UP WITH A LOT MORE ELECTRICAL, LIGHTING PROBLEMS THAN JUST THESE FEW. THIS IS A PROBLEM THAT NEEDS TO BE LOOKED INTO AND FIX BY BMW. *TR
WHILE I AM DRIVING THE INSTRUMENT CLUSTER LIGHT TURN OFF, ALL DIGITAL DISPLAY ON CLUSTER DISAPPEARED ABOUT 10 SECONDS AND TURN BACK ON. IT SEEM LIKE ALL HEADLIGHT AND TAIL LIGHT ALSO TURN OFF. IT SEEM LIKE HAPPENED 1 OR 2 TIMES A YEAR. *TR
THE DRIVER SIDE LOW BEAM HEADLIGHT IS NOT ACCESSIBLE FOR CHANGING BY THE OWNER. THE DEALER HAS TOLD ME THAT THE ENTIRE HEADLIGHT ASSEMBLY MUST BE REMOVED TO CHANGE THE LOW BEAM LIGHT.
BLINDED BY HIGH INTENSITY HEADLAMPS. ALMOST LOST CONTROL OF VEHICLE. FIRST, LET ME THANK YOU FOR CLOSING DOWN THE DISTRIBUTION OF AFTER-MARKET HI DEVICES MADE BY AMTEX IN DAYTON, TX. THE AFTER-MARKET ONES ARE PARTICULARLY DANGEROUS BECAUSE THEY ARE PLACED IN HEADLIGHTS NOT DESIGNED FOR THE HI INTENSITY LAMPS. THESE HEADLAMPS…
Read full complaint
BLINDED BY HIGH INTENSITY HEADLAMPS. ALMOST LOST CONTROL OF VEHICLE. FIRST, LET ME THANK YOU FOR CLOSING DOWN THE DISTRIBUTION OF AFTER-MARKET HI DEVICES MADE BY AMTEX IN DAYTON, TX. THE AFTER-MARKET ONES ARE PARTICULARLY DANGEROUS BECAUSE THEY ARE PLACED IN HEADLIGHTS NOT DESIGNED FOR THE HI INTENSITY LAMPS. THESE HEADLAMPS ARE A CONTINUING PROBLEM, ESPECIALLY THE BLUE-WHITE LAMPS. SOME ARE SO INTENSE AS TO CAUSE PAIN - LIKE LOOKING INTO A WELDER'S ELECTRIC ARC. THESE LAMPS MAY BE OK ON THE AUTOBAHN, BUT THEY HAVE NO PLACE IN URBAN CROWDED FREEWAYS. NOT ONLY ARE THE DIRECT BEAMS DISTRACTING AND DANGEROUS, BUT EVEN REFLECTED (FROM OTHER VEHICLES AND WET ROADWAYS) LIGHT CAUSES PROBLEMS. THIS IS A VERY SERIOUS PROBLEM, AND ONE THAT IS ADMITEDLY HARD TO QUANTIFY - WHO CAN SAY HOW MANY ACCIDENTS HAVE BEEN CAUSED BY DRIVERS BLINDED BY THESE LIGHTS. NOTABLE OFFENDERS ARE BMW-LATE MODELS, HONDA - ESPECIALLY ACCORD & ACURA, LEXUS, AND AUDI. MANY OF THE HIGH-END, EXPENSIVE FOREIGN-MADE VEHICLES TEND TO HAVE THESE OBNOXIOUS LAMPS AS STANDARD EQUIPMENT. ENOUGH IS ENOUGH! IT'S TIME TO GET THESE DANGEROUS IRRITANTS OFF THE ROAD!*AK
Official recalls
108V384000 · Air Bags:frontal
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.