I AM FILING THIS COMPLAINT ON BEHALF OF MYSELF AND THE COUNTLESS OTHERS EXPERIENCING THIS POTENTIALLY FATAL DEFECT IN BMW'S SMG PUMP UNIT. I WAS DRIVING ON THE FREEWAY FOR ABOUT 5 MINUTES WHEN I NOTICED MY CAR IMMEDIATELY SHIFTED INTO NEUTRAL WITHOUT ME MAKING THAT DECISION. I WAS IN THE MIDDLE OF CHANGING LANES WHEN THIS HAPPEN…
Read full complaint
I AM FILING THIS COMPLAINT ON BEHALF OF MYSELF AND THE COUNTLESS OTHERS EXPERIENCING THIS POTENTIALLY FATAL DEFECT IN BMW'S SMG PUMP UNIT. I WAS DRIVING ON THE FREEWAY FOR ABOUT 5 MINUTES WHEN I NOTICED MY CAR IMMEDIATELY SHIFTED INTO NEUTRAL WITHOUT ME MAKING THAT DECISION. I WAS IN THE MIDDLE OF CHANGING LANES WHEN THIS HAPPENED. THE SMG WARNING LIGHT CAME ON. I PUT MY HAZARDS ON. THE CAR ABRUPTLY SLOWED AS IT CHOSE TO SHIFT BACK TO 4TH GEAR AS I WAS GOING 65MPH. I TRIED SHIFTING BACK UP TO GEAR SAFELY GET TO THE SHOULDER BUT WITH NO LUCK AS THE VEHICLE WENT BACK INTO NEUTRAL. THE CARS BEHIND ME CAME VERY RAPIDLY AND TWO ALMOST HIT ME AS A RESULT OF THIS PUMP FAILURE. BY THIS TIME I WAS TRAVELING AROUND 40MPH IN A 65+ TRAFFIC ZONE. I FINALLY ROLLED MY CAR DOWN THE SHOULDER TO SAFETY. I REPLACED THE SMG RELAY WITH A SPARE NEW ONE I ALWAYS CARRIED IN THE CAR. I WAITED 10 MINUTES FOR THE VEHICLE TO COOL OFF AS I KNEW THIS WAS THE INFAMOUS SMG PUMP ISSUE. THE CAR STARTED BACK UP WITH NO LIGHT AND DROVE ME ALMOST THE ENTIRE ROUTE BACK HOME. JUST ABOUT A MILE FROM MY HOME, SAME THING HAPPENED. THIS TIME LEAVING ME COMPLETELY STUCK IN A BUSY INTERSECTION. LUCKILY, THE PEOPLE BEHIND ME WERE KIND ENOUGH TO HELP PUSH MY CAR OUT OF THE WAY. I CALLED A FRIEND AND WE PUSHED THE CAR ALL THE WAY BACK TO MY GARAGE. NOW THIS IS JUST THE FIRST TIME IT HAS HAPPENED. IT HAPPENS IN LESS THAN 3 MINUTES OF DRIVING THE CAR JUST WHEN I TRY TO MOVE IT NEVER BREAKING 15MPH. BMWNA IGNORES OUR COMPLAINTS AS THEIR DEALERSHIPS MAKE MONEY HAND OVER FIST WITH THIS $4000 REPAIR. MY COMPLAINT IS NOT WITH THE REPAIR AMOUNT. US M3 OWNERS ARE AWARE OF THE MAINTENANCE AND REPAIR COSTS FOR OUR HIGHLY SPECIALIZED VEHICLES. HOWEVER, THIS PUMP MALFUNCTION IS A VERY REAL DANGER TO ALL DRIVERS. WE'VE SEEN THIS HAPPEN TO VEHICLES WITH ANYWHERE FROM 15K TO 120K MILES ON THEM. BMW NEEDS TO ISSUE A RECALL. *TR
NHTSA ODI #10598930
77,500 miles · Aug 10, 2012
Power Train
MULTIPLE INCIDENTS SINCE THE DAY AFTER WE PURCHASED THE CAR: ?DRIVING IN 4TH GEAR (ANYWHERE FROM 10 TO 40 MINS OF DRIVING) WILL SUDDENLY FEEL AS IF CLUTCH IS ENGAGED SO I CANNOT ACCELERATE, YELLOW TRANSMISSION WARNING LIGHT COMES ON, THEN I HAVE TO COAST TO A COMPLETE STOP AND SHUT THE ENGINE OFF. IT CAN TAKE SEVERAL ATTEMPTS …
Read full complaint
MULTIPLE INCIDENTS SINCE THE DAY AFTER WE PURCHASED THE CAR: ?DRIVING IN 4TH GEAR (ANYWHERE FROM 10 TO 40 MINS OF DRIVING) WILL SUDDENLY FEEL AS IF CLUTCH IS ENGAGED SO I CANNOT ACCELERATE, YELLOW TRANSMISSION WARNING LIGHT COMES ON, THEN I HAVE TO COAST TO A COMPLETE STOP AND SHUT THE ENGINE OFF. IT CAN TAKE SEVERAL ATTEMPTS TO RESTART THE CAR TO RE-ENGAGE BACK INTO 1ST GEAR. NOTICED IF I WAIT LONG ENOUGH, ONCE THE TRANSMISSION WARNING LIGHT ALSO TURNS OFF THEN I CAN RESTART BACK IN FIRST GEAR. ALL THIS WHILE DRIVING IN AUTO MODE. ?SAME ISSUE AS ABOVE BUT HAS HAPPENED IN THE LOWER GEARS WHILE ACCELERATING OR WHEN CRUISING AT HIGHER GEARS, FOR EXAMPLE, 6TH GEAR AND MANUALLY SHIFTING INTO 5TH, WARNING LIGHT WILL COME ON, CAR WILL NOT BE IN GEAR, WILL HAVE TO COAST TO A STOP AND ATTEMPT TO RESTART WITH 1ST GEAR AGAIN. ?SAME ISSUE AS ABOVE, BUT HAS HAPPENED WHILE PARKED AT A RED LIGHT, INDICATOR SHOWS 1ST GEAR, BUT WHEN I TRY TO GO, THE WARNING LIGHT COMES ON AND I?M NOT IN GEAR, REQUIRES A STOP/RESTART OF ENGINE AGAIN ? SOMETIMES MULTIPLE TRIES. THIS HAPPENS ON BOTH EVEN, DECLINED AND INCLINED ROAD SURFACES. ?THIS IS EXTREMELY DANGEROUS AS WE HAVE BEEN LEFT DEAD IN THE ROAD ATTEMPTING TO RESTART THE CAR WHILE THERE'S ON-COMING TRAFFIC AROUND US! *TR
NHTSA ODI #10470150
66,000 miles · Dec 27, 2011
Power Train
TROUBLE WITH SMG TRANSMISSION. CAR WILL NOT STAY IN GEAR AND BUCKS HARD TRYING TO ENGAGE. *TR
NHTSA ODI #10441289
45,000 miles · Nov 3, 2005
Power Train
ON NOVEMBER 2ND, 2005, AT 6:30 P.M., MY FAMILY GOT INTO THE M3. THAT INCLUDED MY WIFE IN FRONT, AND THREE DAUGHTERS IN THE BACK. WE WERE ON THE WAY TO MEET MY FATHER FOR DINNER. WE HAD PLANNED TO TAKE THE 60 FREEWAY WESTBOUND, OF WHICH THE ON RAMP IS OFF A STREET CALLED CHINO HILLS PARKWAY. TO OUR SHOCK, THE FREEWAY WAS JAMMED L…
Read full complaint
ON NOVEMBER 2ND, 2005, AT 6:30 P.M., MY FAMILY GOT INTO THE M3. THAT INCLUDED MY WIFE IN FRONT, AND THREE DAUGHTERS IN THE BACK. WE WERE ON THE WAY TO MEET MY FATHER FOR DINNER. WE HAD PLANNED TO TAKE THE 60 FREEWAY WESTBOUND, OF WHICH THE ON RAMP IS OFF A STREET CALLED CHINO HILLS PARKWAY. TO OUR SHOCK, THE FREEWAY WAS JAMMED LIKE A PARKING LOT, SO WE PROCEED TO MAKE A U-TURN TO TAKE AN ALTERNATE SIDE ROAD. TRAVELLING SOUTHBOUND ON CHINO HILLS PARKWAY AT ABOUT 25 TO 30 MPH IN 2ND GEAR, THE SMG GEAR INDICATOR GOES TO "0". I DO NOT RECALL SHIFTING AT ALL, SO I JUST PROCEED TO MOVE THE GEAR LEVER TO PUT IT BACK IN GEAR. IT DOES NOT CHANGE, REAMINS AT "0", AND SINCE MY FOOT IS STILL ON THE GAS PEDAL, I JUST HEAR THE REVS OF THE ENGINE WHILE NOTICING I HAVE NO POWER TO MOVE FORWARD. THANKFULLY, WE WERE ON A SLIGHT DOWNWARD SLOPE, SO I WAS ABLE TO SAFELY COAST TO A STOP BY THE RIGHT SIDE OF THE ROAD. THE FIRST THING I NOTICE IS THE YELLOW GEAR-SHAPED TRANSMISSION LIGHT HAS COME ON. I PROCEED TO SHUT THE CAR OFF, THINKING A RESTART WOULD CORRECT THE SITUATION. I TRY SHIFTING INTO GEAR, BUT IT REMAINS AT "0". BEFORE I RESTART THE SECOND TIME, I POP THE HOOD OPEN, AND GO OUT TO CLOSE IT, HAVING HEARD THAT SOMETIMES THE SMG PUMP ACTS FUNNY IF THE HOOD IS NOT CLOSED. I'M STILL UNABLE TO SHIFT. I TURN OFF THE ENGINE, WAIT A FEW MINUTES. THIS TIME, THE ENGINE DOESN'T EVEN START! THIS HAPPENED TWO MORE TIME. FINALLY, ON THE SIXTH RESTART, THE ENGINE COMES ALIVE, AND I AM ABLE TO SHIFT INTO GEAR. THE YELLOW TRANSMISSION LIGHT IS STILL ON, BUT WE MADE IT HOME SINCE THIS ALL HAPPENED ABOUT 3 MILES FROM HOME. THE CAR HAS BEEN FLATBEDDED TO THE DEALERSHIP.
NHTSA ODI #10141672
7,800 miles · Jan 30, 2004
Power TrainCrash
2002 BMW M3, REPEATED SMG TRANSMISSION FAILURES RENDERING THE VEHICLE INOPERABLE. BMW HAS NO IDEA WHAT IS CAUSING THE PROBLEM. BMW ALSO DAMAGED THE VEHICLE TRYING TO RETRIVE IT FOR YET ANOTHER REPAIR ATTEMPT. IT MAY HAVE STARTED ITSELF WITHOUT THE KEY IN IT WHILE THE TOW TRUCK WAS PICKING IT UP. BMW IS IN A CONSTANT STATE OF …
Read full complaint
2002 BMW M3, REPEATED SMG TRANSMISSION FAILURES RENDERING THE VEHICLE INOPERABLE. BMW HAS NO IDEA WHAT IS CAUSING THE PROBLEM. BMW ALSO DAMAGED THE VEHICLE TRYING TO RETRIVE IT FOR YET ANOTHER REPAIR ATTEMPT. IT MAY HAVE STARTED ITSELF WITHOUT THE KEY IN IT WHILE THE TOW TRUCK WAS PICKING IT UP. BMW IS IN A CONSTANT STATE OF DENIAL. VEHICLE HAS BEEN IN THE DEALER 6 WEEKS NOW AND COUNTING AND IT HAS LESS THAN 8000 MILES ON IT.
NHTSA ODI #10056196
15,000 miles · Aug 9, 2003
Engine And Engine CoolingPower TrainVehicle Speed Control
MULTIPLE PROBLEMS WITH THE VEHICEL. THE ENGINE WAS REPLACED AT 16000, THE TRANSMISSION (SMG) WAS RE[;ACED AT 20000, NOW THE ENGINE REV HIGH AT IDEL AND SEND STRON VIBRATION TO THE CABIN AND STEERING COLUMN. BMW OF HOUSTON NORTH, A LOCAL DEALER IN HOUSTON, TX, WERE LESS THAN HELPFUL IN TRYING TO SOLVE THE CURRENT PROBLEM. IT APPE…
Read full complaint
MULTIPLE PROBLEMS WITH THE VEHICEL. THE ENGINE WAS REPLACED AT 16000, THE TRANSMISSION (SMG) WAS RE[;ACED AT 20000, NOW THE ENGINE REV HIGH AT IDEL AND SEND STRON VIBRATION TO THE CABIN AND STEERING COLUMN. BMW OF HOUSTON NORTH, A LOCAL DEALER IN HOUSTON, TX, WERE LESS THAN HELPFUL IN TRYING TO SOLVE THE CURRENT PROBLEM. IT APPEARS THAT THEY WANT TO KEEP THE PROBLEMS WITH M3 QUIET. *AK
NHTSA ODI #10031136
1,000 miles · Apr 29, 2003
Power Train
THE TRANSMISSION HAS FAILED 4 TIMES. IT HAS BEEN REPAIRED 4 TIMES WITH NO EFFECT. THE DEALER DROVE IT OVER 300 MILE TO "TEST DRIVE" THE CAR. BMW DOES NOT RESPOND WITH ANYTHING BUT RHETORIC AND POOR SERVICE. OTHER OWNERS HAVE HAD THEIR ENGINES LITERALLY BLOW UP! BMW IS A TERRIBLEL COMPANY WITH DEFECTIVE PRODUCTS AND POOR SER…
Read full complaint
THE TRANSMISSION HAS FAILED 4 TIMES. IT HAS BEEN REPAIRED 4 TIMES WITH NO EFFECT. THE DEALER DROVE IT OVER 300 MILE TO "TEST DRIVE" THE CAR. BMW DOES NOT RESPOND WITH ANYTHING BUT RHETORIC AND POOR SERVICE. OTHER OWNERS HAVE HAD THEIR ENGINES LITERALLY BLOW UP! BMW IS A TERRIBLEL COMPANY WITH DEFECTIVE PRODUCTS AND POOR SERVICE. *NLM
NHTSA ODI #10016725
Mileage unknown · Jan 16, 2002
Power TrainCrash
WHILE DRIVING AND CHANGING GEARS COULD HEAR A GRINDING NOISE. HAD VEHICLE AT DEALERSHIP FOR A THIRD TRANSMISSION. PROBLEM WITH TRANSMISSION HAS HAPPENED TWICE BEFORE, AND REPLACED TWICE.*AK
BMW of North America, LLC (BMW) is recalling certain 2000-2005 323iT, 325iT, 325xiT, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323Ci, 325Ci, 328Ci, 330Ci, M3 Coupe, 323Cic, 325Cic, 330Cic, and M3 Convertible vehicles equipped with non-desiccated frontal Takata PSAN inflators and PSPI passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the passenger's front air bag, free of charge. The recall began February 13, 2020. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2000 323i sedans, coupes, convertibles, and Sports Wagons; 2000 328i sedans and coupes; 2001-2005 325i sedans, coupes, convertibles, and Sport Wagons; 2001-2005 325xi sedans and Sports Wagons; 2006 325i coupes and convertibles; 2001-2006 330i sedans, coupes, and convertibles; 2001-2005 330xi sedans; and 2001-2006 M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure that could cause the air bag inflator to rupture upon deployment of the air bag.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, excessive internal pressure could cause rupturing of the inflator resulting in metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger side frontal air bag, free of charge. An interim notice was mailed to owners in September 2014. A second notice was mailed when an adequate supply of parts became available, on December 1, 2014. Owners may contact BMW customer service at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
BMW of North America, LLC (BMW) is recalling certain 2000-2002 BMW 320i, 323i, 325i, 325xi, 330i, 330xi, 323Ci, 325Ci, 330Ci, M3, 323iT, 325iT and 325xiT vehicles, 2001-2002 525i, 530i, 540i, M5, 525iT and 540iT vehicles, and 2001-2003 X5 3.0i, X5 4.4i, and X5 4.6is vehicles. These vehicles may have had a driver-side air bag module installed as replacement equipment such as after a vehicle crash necessitating replacement of the original air bag, or as a remedy part for a prior recall. These replacement modules contain an air bag inflator that may rupture due to propellant degradation occurring after long-term exposure to lower absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will inspect the driver side air bag module, replacing it as necessary, free of charge. The recall began March 15, 2017. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi Sedans, and 325xi and 325i Sportswagons, 2002-2006 330Ci, 325Ci, and M3 Convertibles and 325i, 330i, and M3 Coupes, 2002-2003 M5, 540i, 525i Sedan, and 530i Sedans, and 540i and 525i Sportswagons, and 2003 X5 3.0i and 4.4i Sports Activity Vehicles. Please note that the 5-series and X5 vehicles are only included if they are equipped with the optional sports steering wheel. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall began Aug 2016. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall supersedes recall 14V-348 in its entirety. Additionally, vehicles that have had their driver side frontal air bag replaced previously as part of a recall remedy need to have their air bag replaced under this recall as well. Note: On December 17, 2015 BMW removed the model year 2004 X5 3.0i and 4.4i Sports Activity vehicle from this recall. Those vehicles were mistakenly identified as including the air bags that are subject to this recall.
BMW is recalling certain model year 2002-2003 325i, 325xi, 330i, 330xi sedans; 325Ci and 330Ci coupes and convertibles; 325iT and 325xiT Sports Wagons; and M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW intends to issue initial notifications to owners informing them of the safety defect in June 2013. Once replacement parts are available, estimated for July, BMW will notify owners again to contact their dealers and schedule a replacement of the passenger air bag, free of charge. Owners may contact BMW customer service at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE09036 · Rear Lamp Illumination
Opened Aug 7, 2009 · Closed Dec 22, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Additional source detail variants (4)
Exterior Lighting
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:brake Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:tail Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
DP09002 · Rear Lamp Illumination
Opened Apr 8, 2009 · Closed Aug 6, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Additional source detail variants (5)
Exterior Lighting:back Up Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:brake Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:tail Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
2002 BMW M3 Problems, Complaints & Recalls | Skip That Year
Illustration