2001 BMW K1200LT

TL* THE CONTACT OWNS A 2001 BMW K1200 LT MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, HE FELT A SLIGHT VIBRATION. AFTER PULLING OVER HER NOTICED THAT THERE WAS AN OIL LEAK ON THE REAR TIRE. THE MOTORCYCLE WAS TAKEN TO A DEALER WHERE THEY ADVISED HIM THAT THE BEARINGS HAD FAILED AND CAUSED THE SEAL TO FRACTURE, CAUSING THE LEAK. THE MOTORCYCLE WAS REPAIRED FOR THE BEARINGS AND THE SEAL. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 45,151. UPDATED 04/10/12*LJ THE DIFFERENTIAL BEARING AND SEAL HAD TO BE REPLACED. UPDATED 04/16/12

2001 BMW K1200LT. REQUEST FOR INVESTIGATION INTO BMW MOTORCYCLE FINAL DRIVE FAILURES *TGW THE CONSUMER STATED WHEN HE ATTEMPTED TO BRING THE MOTORCYCLE TO A SAFE STOP, HE DISCOVERED THE REAR BRAKES DID NOT WORK, WHICH FORCED HIM TO USE THE FRONT BRAKES ONLY, WHICH EXTENDED HIS STOPPING DISTANCE. HE WAS ABLE TO BRING THE BIKE TO A SAFE STOP WITHOUT INCIDENT. UPON INSPECTION, HE REALIZED THE REAR BRAKES FAILED BECAUSE THEY WERE SATURATED IN GEAR OIL, THAT LEAKED FROM THE FINAL DRIVE UNIT AFTER THE FINAL DRIVE BEARING SEAL FAILED. THE FINAL GEAR CROWN GEAR BEARING FAILED, CAUSING METAL PARTS TO BE CRUSHED BETWEEN THE SPINNING GEARS, TEARING THE SEAL AND ALLOWING THE OIL TO LEAK. THE CONSUMER STATED IT WAS THE SECOND TIME THE FINAL DRIVE BEARING FAILED ON HIS BIKE. *JB UPDATED 12/13/11*JB UPDATED 01/05/12.*JB ...UPDATED 01/31/12 *BF UPDATED 02/03/12

I OWN A 2001 BMW K1200LT MOTORCYCLE. I MAINTAIN IT VERY WELL AND CHANGE LUBRICANTS AHEAD OF SCHEDULE. MY WIFE AND I WERE RIDING THE MOTORCYCLE NOT FAR FROM OUR HOME WHEN WE FELT A ROUGHNESS AND VIBRATION THAT WORSENED AND WORSENED. HEARING THAT THESE BIKES ARE NOTORIOUS FOR A FAILED BEARING IN THE REAR DRIVE, I STOPPED TO CHECK IT AND THERE WAS GEAR OIL ALL OVER THE REAR WHEEL. EVEN MORE DANGEROUS THAN THE GEAR OIL SPILLING ONTO THE TIRE WAS THE FACT THAT IT RAN DOWN ONTO THE REAR BRAKE CALIPER! THANKFULLY, WE WERE CLOSE TO HOME, SO WE "LIMPED" HOME VERY CAREFULLY BEFORE THE TOTAL FAILURE HAPPENED. NUMBERS OF OWNERS ARE REPORTING THIS SAME FAILURE WHERE THE GEAR OIL IS SPILLING FROM THE REAR DRIVE ONTO THE TIRE AND BRAKES. THIS IS VERY DANGEROUS. *TR

BMW MOTORCYCLE, MODEL K1200LT. RIDING NORMALLY AT 65 MPH ON FREEWAY, OIL LEAKED OUT OF REAR DRIVE UNIT ONTO BRAKES, WHEEL AND TIRE. LOST ALL REAR BRAKING EFFECTIVENESS, TIRE SLIPPED SLIGHTLY ON ROAD. PULLED ONTO SHOULDER, STOPPED BY USING FRONT BRAKE ONLY. VEHICLE TOWED TO DEALER WHERE REAR DRIVE UNIT WAS REPLACED AT MY EXPENSE. OLD PART IS BEING SHIPPED TO MY OFFICE. *NM

WIFE AND I GOING HOME FROM WEEKEND TRIP WHEN OUR MOTORCYCLE STARTED MAKING A GRINDING SOUND FROM THE REAR WHEEL. AFTER GETTING BIKE TO SIDE OF THE ROAD I NOTICED OIL COVERING WHEEL, BRAKE AND TIRE. HAD BIKE TOWED TO DEALER, THEY SAID IT WAS THE REAR DRIVE BEARING. THEY SAID THAT THEY HAD A FEW OF THEM GO BAD. WITH 37,000 MILES OUT OF WARRANTY. STILL AT DEALER WAITING REPAIR.