Power Train. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

What owners actually said

51 reports

Mileage unknown · Jun 12, 2002

Power Train

Read full complaint

HELLO. I PURCHASED MY BMW MOTORCYCLE NEW ON 5/3/00 FROM BMW-DUCATIC OF CHARLOTTE, NC . THE REAR END DIFFERENTIAL COMPLETELY FAILED WHILE ENROUTE TO THE DEALERSHIP TO HAVE THIS PROBLEM DIAGNOISED. THE DEALERSHIP REPAIRED THE DIFFERENTIAL WITH A COMPLETELY NEW UNIT FROM BMW AS THE MOTORCYCLE WAS UNDER WARRANTY AT THE TIME. SINCE THIS FAILURE I HAVE HAD ZERO PROBLEMS SINCE. HOWEVER, AND THIS IS VERY IMPORTANT, HAD I NOT STOPPED AT A REST AREA ON INTERSTATE 85 WHILE ENROUTE TO CHARLOTTE, NC I MAY NOT BE ALIVE TODAY. WHILE COMING INTO THE REST AREA AT APPROXIMATELY 70 MPH THE REAR END 'LET GO'. THERE HAVE BEEN NUMEROUS FAILURES OF THIS DIFFERENTIAL ON THIS MODEL OF BMW AS WELL AS OTHER MODELS OF BMW MOTORCYCLES. THANK YOU FOR YOUR TIME AND EFFORT. SINCERELY, [XXX].*AK PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI #762992

Official recalls

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP12001 · M/c Final Drive Ball Bearing Failure

Opened Jan 20, 2012 · Closed Jun 20, 2013

Status: closed (inferred from source dates) · Power Train:driveline:differential Unit

The Office of Defects Investigation (ODI) received a defect petition requesting that it open an investigation into model year (MY) 1998-2009 BMW KLT series motorcycles for final drive bearing failures.The petitioner asked NHTSA to issue an order that [BMW] be required to recall the affected models for inspection ofcomponent wear and proper assembly of the [final drive] bearing.ODI has reviewed the petition, assessed relevant consumer complaints, and gathered other data in the course of investigating this issue.Based on its review, ODI does not believe that a safety-related defect trend currently exists for final drive bearing failures in the subject motorcycles.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to accomplish the agency's safety mission, the petition is denied.However, the agency will continue to monitor information related to this issue and will take further action if warranted.For detailed information, see the Federal Register notice: https://federalregister.gov/a/2013-13779.

PE03054 · Fuel Line Leakage

Opened Dec 1, 2003 · Closed Jan 23, 2004

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

BMW IS CONDUCTING A RECALL (04V-028).AN INFORMATION REQUEST(IR)RESPONSE WAS NOT RECEIVED. UPON BMW'S RECEIPT OF THE IR, AND AFTER DISCUSSIONS WITH ODI, BMWDETERMINED THAT A RECALL WAS NECESSARY. ON CERTAIN MOTORCYCLES, THE O-RING CONTAINED WITHIN THE FUEL LINE QUICK-DISCONNECT COUPLING COULD BECOME DAMAGED.FURTHER, THERE IS ALSO A PROBLEM INVOLVING CRIMP-TYPE HOSE CLAMPS, WHICH CAN ALSO RESULT IN A SMALL FUEL LEAK.DEALERS WILL INSPECT, AND IF NECESSARY, ADJUST ALL CRIMP-TYPE HOSE CLAMPS.ALSO ALL FUEL LINE QUICK-DISCONNECT COUPLINGS WILL BE INSPECTED.IF A LEAK IS DETECTED, THE QUICK-DISCONNECT O-RING WILL BE REPLACED.IF DAMAGED, THE COUPLING WILL BE REPLACED.OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 2004.