2018 BMW I3

After reviewing BMW’s warranty documentation, I believe that the part replaced — specifically the evaporative emissions (EVAP) valve or purge valve AND vapor canister (active charcoal canister) — should be covered under the California Extended Emissions Warranty (TZEV) for my 2018 BMW i3 with Range Extender. According to BMW’s California Emissions Warranty documentation (pages 14), the Evaporative Canister / Active Charcoal Filter is explicitly listed as a covered component under the Extended Emissions Warranty applicable to BMW i3 Range Extender vehicles in California. Furthermore, page 18 of the same document outlines the California Emission Control System Limited Warranty (TZEV), which provides coverage for emissions-related components for up to 15 years or 150,000 miles, whichever occurs first. Additionally, since we purchased this vehicle in 2021, we have meticulously maintained it and kept detailed fuel and service records. The vehicle has only been refueled NINE times total of 17 GALLONS of fuel with each refueling carefully logged by date and milage. The most recent refueling occurred on March 28, 2025, prior to our service visit at your dealership. These records demonstrate that the fuel and emissions systems have been minimally used, making premature failure of the vapor canister highly unusual. WE have never over filled the tank and dealer is claiming / assuming that is the cause. We believe this is a design flaw on BMW and we do pay the price. Many frustrated BMW i3 owners with similar issue and no help from BMW. THERE ARE MANY REPORTS OF THIS SAME ISSUE ALSO A BMW RECALL BULLETIN ( SIB 01 05 24 ) I3 REX EVAP SYSTEM PURGE VENT VALVE EXT LTD WTY PLEASE MAKE BMW TO RECALL / REPAY ALL I3 OWNERS WITH THIS ISSUE. WHAT IS THE POINT OF AN EXTENDED WARRANTY IF NO ONE IS ENFORCING IT !

This isn't a safety issue, rather it's a known problem with the factory AC compressor inside of BMW i3s and i8s that seem to constantly fail. I had a replacement under the car's factory warranty and the part already failed again right outside the part's warranty period. The replacement itself was quoted as a little over $9,000 but the dealership has since gone down to just under $4,000 to replace something that's just 2 months outside of warranty (but is probably something that would have failed an inspection had I just "taken it in" earlier). NUMEROUS people in online forums have confirmed this to be a known issue, but the company is holding their ground. Car companies should be held to a higher standard, and I'd like to ask the NHTSA to intervene and assist in this matter.

On May 2, 2022, the car began to power down involuntarily every time I applied the brakes. This happened 2-3 times, and I was able to restart. The final time was in the middle of an intersection, the car would not restart, could not be placed in neutral to be moved out of the intersection, and I had to have a police tow. The tow service took it to Sport Motoring, where they performed a diagnosis on May 3, 2022. The diagnosis shows 8 faults in the EME module, among other things. I located a recall (Recall #19V310000) for the 2018 i3 which details the exact issue of the car powering down on its own due to a faulty EME module. Sport Motoring called BMW Customer Service on May 3, 2022, and asked if the car might need to have this recall applied. They agreed that the symptoms did seem similar and said they would need to have a diagnosis from a dealer. Based on the call with BMW customer service, I had the car towed to Nalley BMW of Decatur. They charged me for an initial diagnosis which did not include any information from the EME module and stated that the 12v battery needed to be replaced, and then if needed they would perform further diagnosis for an additional charge. I paid for the diagnosis and the battery in advance. After replacing the 12v battery, the dealer test drove my vehicle and said it was performing normally, so I picked it up on May 6, 2022. On my way home, the car began involuntarily powering down again. I documented the error messages on the two screens with photos. I drove back to the dealership with one more loss of power on the way. At this point, the dealer states that the faults clear every time they power the vehicle on and that the vehicle is not repeating the problem when they test drive it, so there is nothing more they can do. I cannot drive this car as it is a serious safety hazard. I also learned that this dealer had possession of the car in 2021 and sold it at auction in July that year because it had issues they could not cure.