Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports1 fire reports0 injury reports

Electrical System complaints

2 reports

Clear category filter

7,100 miles · Aug 11, 2012

Electrical SystemFuel/propulsion SystemStructure

Read full complaint

THE PLASTIC MOUNTING PLATE HOLDING THE FUEL PUMP AND FUEL GAUGE SENDING UNIT DEVELOPED A HAIRLINE CRACK. THIS CRACK ALLOWED FUEL TO ESCAPE FROM THE TANK UNCONTROLLED, WHICH COULD CAUSE A FIRE. THE MOTORCYCLE WAS PARKED IN THE GARAGE, WHERE A GAS WATER HEATER NEARBY COULD HAVE IGNITED THE FUMES. THIS CRACK WAS NOT CAUSED BY ANY CONTACT OR PRESSURE FROM ANY OTHER COMPONENT OF THE MOTORCYCLE AS IT IS PROTECTED BENEATH THE SEAT AND A SUBSTANTIAL RECESS IN THE FUEL TANK. THE LOCAL DEALERSHIP ADMITTED THAT THEY REPLACE AS MANY AS TWO OF THESE CRACKED MOUNTING PLATES PER MONTH. THIS CONDITION WAS NOT FOUND ON ANY RECALL NOTIFICATION THAT WE ARE AWARE OF. UNFORTUNATELY, THIS MOUNTING PLATE IS NOT AVAILABLE SEPARATELY, AS IT IS A COMPONENT ASSEMBLY OF THE FUEL PUMP AND SENDING UNIT, COSTING NEARLY $1000 TO REPLACE. *TR

NHTSA ODI #10470251

9,500 miles · Jul 5, 2012

Electrical SystemFire

DURING COMMUTING ALL LIGHTS OFF, NO TURN, NO STOP LIGHTS, THE BMW CANBUS SWITCH OFF COMPUTER, SPEEDOMETR, TACHOMETR AND ABS STOP WORKING. BATTERY SUPPLY/FEED ONLY ENGINE, AFTER FEW MINUTES ENGINE STOPS. BURNT SMOKE AND ODOR COME FROM ALTERNATOR. *TR

NHTSA ODI #10464230

Official recalls

08V342000 · Steering

Jul 25, 2008

BMW IS RECALLING 428 MY 2007 F800 S, F800 ST, R1200 R, K1200 S, K1200 R, K1200 R SPORT, AND K1200 GT MOTORCYCLES. IT IS POSSIBLE FOR THE COATING TO SEPARATE FROM THE INSIDE FACE OF THE STEERING DAMPER HOUSING. IF THIS HAPPENED, THE COATING COULD PARTIALLY CLOG THE OIL BORES WITHIN THE DAMPER.

Consequence & remedy

Consequence: IF THIS OCCURRED, THE STEERING DAMPER COULD BECOME STIFF INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE STEERING DAMPER FREE OF CHARGE. THE RECALL BEGAN DURING SEPTEMBER 2008. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

08V241000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Jun 2, 2008

BMW IS RECALLING 1,980 MY 2007-2008 F800 S AND F800 ST MOTORCYCLES. DUE TO THE ROUTING OF THE FUEL TANK BREATHER HOSE, PRESSURE EQUALIZATION INSIDE THE FUEL TANK IS POSSIBLE ONLY TO A LIMITED EXTENT. CONSEQUENTLY, AT HIGH AMBIENT TEMPERATURES, THE FUEL TANK CAN DEFORM. IF THIS HAPPENED AT THE POINT WHERE THE FUEL TANK IS SHAPED TO PROVIDE CLEARANCE FOR THE REAR WHEEL, THEN, IN COMBINATION WITH A LARGE PAYLOAD, THE BOTTOM OF THE TANK COULD RUB AGAINST THE REAR WHEEL.

Consequence & remedy

Consequence: IF THIS OCCURRED, IT IS POSSIBLE THAT A LEAK COULD DEVELOP IN THE TANK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REROUTE THE FUEL TANK BREATHER HOSE. THE RECALL BEGAN DURING AUGUST 2008. OWNERS MAY CONTACT BMW AT 1-800-331-1117.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.