Suspension. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports0 fire reports2 injury reports

Vehicle Speed Control complaints

1 reports

Clear category filter

Mileage unknown · Aug 19, 2002

Fuel System, GasolineVehicle Speed Control

Read full complaint

THE FUEL TANK PROBLEM IS A DEFECT OR SMALL CRACK IN THE PLASTIC. FUEL SEEPS OUT AND PUDDLES UNDER THE SEAT. I PLAN TO SAVE THE OLD PART WHEN THE DEALER FIXES TEH PROBLEM UNDER WARRANTY. ON AN INTERNET DISCUSSION SITE I SAW TWO OTHER INSTANCES OF THIS PROBLEM WITH THIS MOTORCYCLE AND YEAR. THE ENGINE/FUEL INJECTION PROBLEM IS STALLING. MOTORCYCLE WILL RUN FINE FOR MANY WEEKS AND THEN IT WILL STALL AT ANY SPEED INTERMITTENTLY. ONCE THE MOTORCYCLE IS SHUT OFF (KEY IN OFF POSITION) AND TURNED BACK ON IT WILL START AND RUN FINE. THERE IS SLIGHT SURGING PROBLEM TOO. THIS SURGING PROBLEM IS THE ENGINE NOT KEEPING A CONSTANT SPEED WHEN THE THROTTLE IS HELD IN A FIXED POSITION.

NHTSA ODI #765847

Official recalls

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE09026 · Motorcycle Front Wheel Separation

Opened May 18, 2009 · Closed Sep 18, 2009

Status: closed (inferred from source dates) · Suspension:front

THIS PE WAS OPENED AFTER NHTSA RECEIVED 3 VOQS CONCERNING ALLEGED FRONT AXLE SEPARATIONS ON CERTAIN BMW F650 GS MODEL MOTORCYCLES SOLD FOR USE IN THE UNITED STATES (THE SUBJECT VEHICLES).COMPLAINTS INVOLVING MOTORCYCLES IN NON-US MARKETS ARE NOT COUNTED IN THIS TOTAL.AFTER GATHERING ADDITIONAL INFORMATION ABOUT THIS SUBJECT, WE ARE NOW AWARE OF FOUR CONFIRMED INCIDENTS INVOLVING MODEL YEAR 2001-2003 SUBJECT VEHICLES.ALL FOUR BIKES WERE BUILT BEFORE SEPTEMBER, 2002.OF THESE, TWO INVOLVE MY 2001 BIKES AND THE OTHER TWO, MY'S 2002 AND 2003, RESPECTIVELY.THE INCIDENTS OCCURRED IN 2002, 2003, AND TWO IN 2008.IN EACH INSTANCE, THE LUG FRACTURES ARE FORCED FRACTURES RATHER THAN FATIGUE-RELATED.BETWEEN OCTOBER 1999 AND SEPTEMBER, 2002, BMW BUILT APPROXIMATELY 4,300 SUBJECT VEHICLES.AFTER SEPTEMBER 12, 2002, ALL F650GS'S WERE BUILT WITH REINFORCED LOWER FORK TUBES TO REDUCE, ACCORDING TO BMW,THE POSSIBILITY OF ANY SIGNIFICANT FRACTURE THAT COULD OCCUR AT THE FORK LEG AXLE LUG AREADURING A CRASH.BMW TOOK THIS ACTION BECAUSE THE SUBJECT VEHICLES ARE DESIGNED FOR OFF-ROAD USE WHERE CRASHES (MANY MINOR) ARE COMMON AND DID NOT WANT RIDERS TO HAVE TO DEAL WITH A BROKEN FORK AS A RESULT.CURRENTLY, THERE IS NO DATA CONCLUSIVELY ESTABLISHING THAT THE SUBJECT FORK LUGS ARE SEPARATING BEFORE AN ALLEGED CRASH OCCURS.ADDITIONALLY, THE INFREQUENT, SPORADIC, AND RANDOM NATURE OF THE FAILURES FAILS TO ESTABLISH A DEFECT TREND CURRENTLY EXISTS.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.