TL* THE CONTACT OWNS A 2003 BMW F650 CS MOTORCYCLE. THE CONTACT STATED THAT THE BATTERY WAS REPLACED AND THE RPM READING BECAME ERRATIC AND INCONSISTENT WITH THE THROTTLE POSITION. THERE WAS A RECALL UNDER NHTSA CAMPAIGN NUMBER: 04V236000 (FUEL SYSTEM, GASOLINE) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE MANUFACTURER WAS M…
Read full complaint
TL* THE CONTACT OWNS A 2003 BMW F650 CS MOTORCYCLE. THE CONTACT STATED THAT THE BATTERY WAS REPLACED AND THE RPM READING BECAME ERRATIC AND INCONSISTENT WITH THE THROTTLE POSITION. THERE WAS A RECALL UNDER NHTSA CAMPAIGN NUMBER: 04V236000 (FUEL SYSTEM, GASOLINE) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 4,500. *TR
NHTSA ODI #10536447
17,100 miles · Jun 7, 2006
Fuel System, Gasoline
A HAIRLINE CRACK IN THE FUEL PUMP/FILTER ASSEMBLY "CAP" ON TOP OF THE TANK WHICH ALLOWS FUEL TO LEAK OUT OF THE TANK AND POOL UNDER THE SEAT CREATING A FIRE/EXPLOSION HAZARD. THIS IS THE SAME PROBLEM REFERRED TO IN NHTSA CAMPAIGN ID NUMBER : 04V236000 REGARDING THE CS MODEL. PARTS ARE AVAILABLE, BUT DEALER WILL ONLY PERFORM AT…
Read full complaint
A HAIRLINE CRACK IN THE FUEL PUMP/FILTER ASSEMBLY "CAP" ON TOP OF THE TANK WHICH ALLOWS FUEL TO LEAK OUT OF THE TANK AND POOL UNDER THE SEAT CREATING A FIRE/EXPLOSION HAZARD. THIS IS THE SAME PROBLEM REFERRED TO IN NHTSA CAMPAIGN ID NUMBER : 04V236000 REGARDING THE CS MODEL. PARTS ARE AVAILABLE, BUT DEALER WILL ONLY PERFORM AT OWNERS COST BECAUSE THERE WAS NO RECALL ISSUED SPECIFICALLY FOR THE GS MODEL. *JB
NHTSA ODI #10159252
Mileage unknown · May 27, 2004
Fuel System, Gasoline
WHILE DRIVING OR PARKED, THE CONSUMER NOTICED GAS FUMES. THE CONSUMER INSPECTED THE VEHICLE AND NOTICED A PUDDLE OF FUEL UNDERNEATH THE VEHICLE. A TECHNICIAN INSPECTED THE VEHICLE AND NOTICED THAT THE GAS TANK HAD CRACKS. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
ON CERTAIN MOTORCYCLES, THE PLASTIC FUEL PUMP FLANGE COULD COME INTO CONTACT WITH A SUFFICIENT AMOUNT OF ACID OR CHEMICAL COMPOUNDS CONTAINING ACIDIC ELEMENTS, SUCH AS BATTERY ACID OR CERTAIN CLEANING PRODUCTS.
Consequence & remedy
Consequence: THE FLANGE COULD BECOME BRITTLE, CRACK, AND ALLOW FUEL TO ESCAPE FROM THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ACID-RESISTANT CAP OVER THE FUEL PUMP FLANGE. THE RECALL BEGAN JUNE 10, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN MOTORCYCLES, DUE TO A MANUFACTURING DEFECT, IT IS POSSIBLE THAT THE WHEEL COULD DEVELOP A CRACK. OVER TIME, THE CRACK COULD WORSEN TO THE POINT THAT THE WHEEL FAILED AND THE DRIVE BELT DERAILED.
Consequence & remedy
Consequence: THIS WOULD RESULT IN A LOSS OF DRIVE CAPABILITY AT THE REAR WHEEL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR DRIVE BELT WHEEL. OWNER NOTIFICATION BEGAN SEPTEMBER 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117, OPTION #4.
ON CERTAIN MOTORCYCLES, IT IS POSSIBLE THAT THE HEX NUT THAT SECURES THE WHEEL TO THE GEARBOX OUTPUT SHAFT WAS TIGHTENED INCORRECTLY DURING THE VEHICLE ASSEMBLY. AS A RESULT, THE NUT COULD LOOSEN DURING VEHICLE OPERATION. IF THIS HAPPENS, THE BELT WHEEL WOULD ITSELF LOOSEN ON THE OUTPUT SHAFT, RESULTING IN DAMAGE TO THE INTERNAL SPLINES OF THE WHEEL AND TO THE EXTERNAL SPLINES OF THE OUTPUT SHAFT AS THE VEHICLE IS OPERATED.
Consequence & remedy
Consequence: OVER TIME, THE SPLINES COULD BE DAMAGED TO THE EXTENT THAT THE OUTPUT SHAFT WOULD NOT LONGER OPERATE THE DRIVE BELT, RESULTING IN A LOSS OF DRIVE CAPABILITY AT THE REAR WHEEL.
Remedy: DEALERS WILL INSPECT THE HEX NUT TORQUE AND ADJUST THE TIGHTNESS IF NECESSARY, AND SECURE THE NUT WITH LOCTITE. OWNER NOTIFICATION BEGAN SEPTEMBER 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117, OPTION #4.
ON CERTAIN MOTORCYCLES, THE SCREWS THAT ATTACH THE REAR BRAKE CALIPER TO THE REAR SWING ARM WERE NOT TIGHTENED CORRECTLY DURING ASSEMBLY. THE SCREWS COULD LOOSEN DURING VEHICLE OPERATION AND EVENTUALLY FALL-OUT, ALLOWING THE REAR CALIPER TO SEPARATE FROM ITS MOUNT.
Consequence & remedy
Consequence: IF THE CALIPER BECOMES TRAPPED BETWEEN THE REAR WHEEL AND THE SWING ARM, IT COULD DISCONNECT FROM THE BRAKE LINE, RESULTING IN A LOSS OF REAR BRAKING CAPABILITY AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL CHECK THE TORQUE OF THE REAR BRAKE CALIPER ATTACHMENT SCREWS AND RETIGHTEN THEM TO THE PROPER VALUE IF NECESSARY. OWNER NOTIFICATION BEGAN JULY 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 BMW F650 Cs Problems, Complaints & Recalls | Skip That Year
Illustration