IllustrationI CONTACTED BMW OF NORTH AMERICA JUST RECENTLY REGARDING THE AIRBAG SENSOR PROBLEM SINCE WE KEEP SPENDING MONEY ON THIS CAR SINCE THE FIRST DAY WE GOT IT NOTHING BUT PROBLEMS. I WOULD LIKE THEM TO PURCHASED THIS CAR BACK FROM ME SINCE ALL I HAD IS MONEY LOSSES AND AGGRAVATION WITH THIS VEHICLE.
2002 BMW 745LI
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 BMW 745LI do not stand out strongly from the model-year median of 25.
About this comparison →How this year compares
Owner complaints by model year
Compare all 745LI years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
025–50K
150–75K
675–100K
11100–150K
1150K+
26 reports with mileage · 10 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports0 injury reports
Air Bags complaints
10 reportsWE HAVE BEING HAVING PROBLEMS WITH THE SAFETY ISSUES OF THIS CAR, SOMETIMES THE CAR WILL BE FINE AND ALL OF THE SUDDEN IT DIES COMPLETLY LEAVING YOU STRANDED, THE CAR WILL CRANK OVER AND WONT START. WE HAVE TAKING TO THE SHOP AND WE HAVE EMAILS FROM BMW OF NORTH AMERICA ADDRESSING THIS ISSUE AND THEY ADVICE THE REPAIR SHOP TO RE…
Read full complaint
WE HAVE BEING HAVING PROBLEMS WITH THE SAFETY ISSUES OF THIS CAR, SOMETIMES THE CAR WILL BE FINE AND ALL OF THE SUDDEN IT DIES COMPLETLY LEAVING YOU STRANDED, THE CAR WILL CRANK OVER AND WONT START. WE HAVE TAKING TO THE SHOP AND WE HAVE EMAILS FROM BMW OF NORTH AMERICA ADDRESSING THIS ISSUE AND THEY ADVICE THE REPAIR SHOP TO REPLACE BATTERY, FUEL PUMP, AND SOME MODULATORS AND THE PROBLEM STILL NOT FIX. THIS CAR IS BEING A MONEY PIT. THE CAR WAS TOWED AGAIN TO THE BMW SERVICE DEALERSHIP TO GET DIAGNOSED AGAIN FOR THE SAME PROBLEM. ALSO IN THIS BMW BRAKE LIGHTS COME ON AND THERE IS NOTHING WRONG WITH THE BRAKES, AIRBAG LIGHT WILL COME ON AS WELL. I USED TO OWN A MERCEDES BENZ E430 AND I NEVER HAD ANY PROBLEMS WITH IT. MY HUSBAND LIKES BMW'S, BUT THERE IS NOTHING BUT PROBLEMS ONE AFTER ANOTHER VERY FRUSTRATING. MAYBE WE GOT A LEMON CAR ALL ALONE AND WE HAVE BEING PAYING THE PRICE EVER SINCE.
THE SEAT BELTS IN THE CAR HAS NOT TIGHTENING TENSION. THE RED LIGHTS ARE ON INDICATING THAT, FAULT IN PASS. - RESTRAINT SYSTEM AFFECTING AIRBAG, BELT TENSIONER OR BELT-FORCE LIMITER. FASTEN AND CONTINUE TO WEAR BELTS.
I HAVE READ THAT THERE WAS A SAFETY RECALL ON SOME MODEL OF THE BMW. AND I WOULD LIKE TO KNOW WHY HAVEN'T THE NHTSA HAVEN'T PUT OUT A BULLETIN ON THE BMW 745LI ABOUT THE SEATS BLETS AND THE AIRBAGS. WHEN THERE ARE ALOT OF COMPLAINTS ABOUT THIS PROBLEM. I FEEL THAT WE ARE DRIVING A VERY UNSAFE CAR. NOW ON MY VEHICLE THE PASSENGER…
Read full complaint
I HAVE READ THAT THERE WAS A SAFETY RECALL ON SOME MODEL OF THE BMW. AND I WOULD LIKE TO KNOW WHY HAVEN'T THE NHTSA HAVEN'T PUT OUT A BULLETIN ON THE BMW 745LI ABOUT THE SEATS BLETS AND THE AIRBAGS. WHEN THERE ARE ALOT OF COMPLAINTS ABOUT THIS PROBLEM. I FEEL THAT WE ARE DRIVING A VERY UNSAFE CAR. NOW ON MY VEHICLE THE PASSENGER SEAT BELT WILL NOT RETRACK. AND I AM UN ABLE TO CARRY ANYONE IN THE FRONT SEAT. ON THE DRIVER SIDE I HAD THAT BROBLEM TO BUT THE SEAT BELT IS ABLE TO FASTEN. THIS HAPPEN WHEN I WAS DRIVING.
THE AIRBAG AND SEATBELT TENSIONER WAS RECALLED FOR SAME MANUFACTURER FOR CARS FROM 2004 AND UP. THE 2002 AND 2003 MODEL HAD THE SAME ISSUE BUT WAS NOT PART OF THE RECALL. I WAS DRIVING ON THE FREEWAY AND THE LIGHT FOR THE SEATBELT TENSIONER AND THE PASSENGER AIRBAG CAME ON. THIS IS A SERIOUS SAFETY CONCERN SINCE AIRBAGS MAY NO…
Read full complaint
THE AIRBAG AND SEATBELT TENSIONER WAS RECALLED FOR SAME MANUFACTURER FOR CARS FROM 2004 AND UP. THE 2002 AND 2003 MODEL HAD THE SAME ISSUE BUT WAS NOT PART OF THE RECALL. I WAS DRIVING ON THE FREEWAY AND THE LIGHT FOR THE SEATBELT TENSIONER AND THE PASSENGER AIRBAG CAME ON. THIS IS A SERIOUS SAFETY CONCERN SINCE AIRBAGS MAY NOT DEPLOY AND THE SEAT BELT MAY NOT TIGHTEN IN AN EVENT OF AN ACCIDENT.
AIRBAG AND SEATBELT RESTRAINT FAULT LIGHT IS ON. *TR
TL* THE CONTACT OWNS A 2002 BMW 745LI. THE CONTACT STATED THAT THE FRONT PASSENGER AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE AIR BAG SENSOR MAT WAS CRACKED, WHICH IN TURN DEACTIVATED THE AIR BAG AND MADE THE LIGHT ILLUMINATE. THE FAILURE…
Read full complaint
TL* THE CONTACT OWNS A 2002 BMW 745LI. THE CONTACT STATED THAT THE FRONT PASSENGER AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE AIR BAG SENSOR MAT WAS CRACKED, WHICH IN TURN DEACTIVATED THE AIR BAG AND MADE THE LIGHT ILLUMINATE. THE FAILURE AND CURRENT MILEAGES WERE 81,500.
2002 BMW 745LI. AIR BAG LIGHT ON DASH BOARD CAME ON, WHICH MEANS SOMETHING IS NOW WRONG WITH THE AIR BAG OR THE AIR BAG SENSORS. BECAUSE OF THIS ISSUE MY AIR BAGS WILL NOT ACTIVATE IF A CRASH OCCURS. THIS SAFETY ISSUE CONCERNS ME AND REQUIRES IMMEDIATE ATTENTION. ANOTHER PROBLEM IS THE OIL PRESSURE VALVE IS LEAKING OIL WHICH…
Read full complaint
2002 BMW 745LI. AIR BAG LIGHT ON DASH BOARD CAME ON, WHICH MEANS SOMETHING IS NOW WRONG WITH THE AIR BAG OR THE AIR BAG SENSORS. BECAUSE OF THIS ISSUE MY AIR BAGS WILL NOT ACTIVATE IF A CRASH OCCURS. THIS SAFETY ISSUE CONCERNS ME AND REQUIRES IMMEDIATE ATTENTION. ANOTHER PROBLEM IS THE OIL PRESSURE VALVE IS LEAKING OIL WHICH HAS CAUSED SLIPPERY CONDITIONS AND UNWANTED POLLUTANTS (DIRTY MOTOR OIL) TO SEEP INTO THE GROUND BECAUSE OF THE CONTINUOUS LEAKING. *TR
THE TELEMATICS AND OTHER ELECTRONICS SYSTEMS OF THE VEHICLE HAVE FAILED OR REPORTED APPARENTLY ERRONEOUS INFORMATION ON MANY OCCASIONS. IN MOST CASES, THESE FAILURES OCCUR WHILE THE VEHICLE IS IN THE MIDST OF TRAVEL, WHICH THEREBY CAUSES THE DRIVER TO BECOME DISTRACTED FROM DRIVING WHILE FOCUSING ON THE SYSTEM FAILURE. THIS PO…
Read full complaint
THE TELEMATICS AND OTHER ELECTRONICS SYSTEMS OF THE VEHICLE HAVE FAILED OR REPORTED APPARENTLY ERRONEOUS INFORMATION ON MANY OCCASIONS. IN MOST CASES, THESE FAILURES OCCUR WHILE THE VEHICLE IS IN THE MIDST OF TRAVEL, WHICH THEREBY CAUSES THE DRIVER TO BECOME DISTRACTED FROM DRIVING WHILE FOCUSING ON THE SYSTEM FAILURE. THIS POSES A POTENTIAL SAFETY ISSUE AS IT PREVENTS THE DRIVER FROM DEVOTING THE NEEDED ATTENTION TO OPERATION OF THE VEHICLE. PROBLEMS INCLUDE, BUT ARE NOT LIMITED TO:*AK AIRBAG AND SRS WARNING MESSAGES; SERVICE ENGINE MESSAGES INDICATING POTENTIAL EMISSIONS PROBLEMS; FAILURE OF DYNAMIC DRIVE SYSTEM; INOPERABILITY OF TIRE PRESSURE MONITORING; ERRONEOUS FLAT TIRE MESSAGES FROM TIRE PRESSURE MONITOR; GAS TANK GAUGE READING EMPTY ALTHOUGH FULE IS IN VEHICLE'S TANK; TELEPHONE SYSTEM FAILURES; FAILURES AND FREEZES OF NAVIGATION SYSTEM; FAILURE OF AUDIO SYSTEM WHICH RESULTS IN HAVING TO HOLD TELEPHONE OR VIEW NAVIGATION SCREEN AS AUDIO COMMANDS ARE MUTED; INOPERATIVE VOICE COMMANDS.
NAR 04/10/2003 THE CONSUMERS HAS EXPERIENCED NUMEROUS PROBLEMS WITH THERE VEHICLE. THE TRANSMISSION HAS CAUSED THE VEHICLE TO SKID TO A STOP WHEN ACCELERATING ON THE BRAKE, THE PASSENGER AIR BAGS LIGHT COMES ON FOR NO REASON, AND THE COMPUTER SYSTEM THAT CONTROL THE VEHICLE AND ALLOWS IT TO FUNCTION HAS BEEN REPAIRED AND REPROG…
Read full complaint
NAR 04/10/2003 THE CONSUMERS HAS EXPERIENCED NUMEROUS PROBLEMS WITH THERE VEHICLE. THE TRANSMISSION HAS CAUSED THE VEHICLE TO SKID TO A STOP WHEN ACCELERATING ON THE BRAKE, THE PASSENGER AIR BAGS LIGHT COMES ON FOR NO REASON, AND THE COMPUTER SYSTEM THAT CONTROL THE VEHICLE AND ALLOWS IT TO FUNCTION HAS BEEN REPAIRED AND REPROGRAMMED 3 SEPARATE OCCASIONS. THE CONSUMER IS REQUESTING IMMEDIATE ASSISTANCE IN RESOLVING THIS SITUATION. *CB
Official recalls
203V240000 · Engine And Engine Cooling
Jul 1, 2003
ON CERTAIN PASSENGER VEHICLES, DUE TO A SOFTWARE ERROR, A DESYNCHRONIZATION OF THE VALVETRONIC MOTORS FOR ENGINE BANKS I AND II MAY OCCUR. IF THIS OCCURS, THE ENGINE COULD STALL.
Consequence & remedy
Consequence: IN THOSE CASES, THE DRIVER MAY NOT BE ABLE TO RESTART THE ENGINE. DEPENDING ON THE LEVEL OF ENGINE ROUGHNESS, OR STALLING, AS WELL AS TRAFFIC CONDITIONS AND THE DRIVER'S REACTIONS, THIS COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPROGRAM THE DIGITAL ENGINE MANAGEMENT CONTROL UNIT. OWNER NOTIFICATION BEGAN JULY 8, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
02V150000 · Fuel System, Gasoline:delivery
Jun 3, 2002
ON CERTAIN PASSENGER VEHICLES, THE ELECTRIC FUEL PUMP RUNS AT A ROTATIONAL SPEED THAT COULD RESULT IN REDUCED LUBRICATION OF ITS INTERNAL COMPONENTS. OVER AN EXTENDED PERIOD OF TIME, WEAR-INDUCED INTERNAL DAMAGE TO THE FUEL PUMP COULD RESULT IN INSUFFICIENT FUEL SUPPLY TO THE ENGINE WHEN THE FUEL TANK CONTAINS ONE-THIRD OR LESS OF ITS MAXIMUM FUEL CAPACITY.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, THE ENGINE COULD STALL AND NOT BE RESTARTED UNTIL MORE FUEL WAS ADDED TO THE FUEL TANK. THIS COULD OCCUR EVEN THOUGH THE FUEL GAUGE INDICATED THAT FUEL STILL REMAINED IN THE TANK.
Remedy: DEALERS WILL REPROGRAM THE FUEL PUMP CONTROL SYSTEM. OWNER NOTIFICATION BEGAN JUNE 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-332-4269.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA12002 · Vehicle Rollaway
Opened Apr 10, 2012 · Closed Jan 24, 2013
Status: closed (inferred from source dates) · Electrical System; Electrical System:ignition; Electrical System:ignition:switch; Power Train:automatic Transmission
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
Additional source detail variants (4)
Electrical System
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
Electrical System:ignition
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
Electrical System:ignition:switch
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
Power Train:automatic Transmission
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
PE11025 · Vehicle Rollaway
Opened Aug 5, 2011 · Closed Apr 23, 2012
Status: closed (inferred from source dates) · Electrical System; Power Train:automatic Transmission
In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional mechanical connection (e.g., cable or linkage) between the gearshift and automatic transmission with an electronic connection controlled by a computer module. When parking the vehicle, the driver has the capability to manually shift the vehicle to park by pressing the Park button on the end of the electronic gearshift lever. However, the instructions for engine shutoff provided in the owner's manual state that pressing the Start/Stop button serves the dual function of switching off the engine and automatically shifting the transmission to Park.In response to ODI's information request for PE11-025, BMW described several circumstances where the subject vehicles may shift to neutral when the driver may expect it to automatically shift to park. First, for Comfort Access System (CAS) vehicles, if the transmission is in neutral when the key fob is in the ignition slot and the Start/Stop button is pressed to shut-off the engine, the transmission will remain in neutral. This is referred to as the Carwash mode and is a normal operating feature of the vehicles that is described in the owner's manual. BMW also described two circumstances that are not normal operating features and are not described in the owners' manual: (1) with the transmission in drive or reverse and the engine running, if the Start/Stop button is pushed 2 or 3 times within a 0.3 second to 0.5 second interval, the engine will stop and the transmission will shift to Neutral; and 2) if the Park button on the gearshift lever is pressed at the same time that the gearshift lever is actuated (i.e., toggled up or down) to select drive, reverse or neutral; the transmission will shift to neutral or remain in neutral.Beginning in model year (MY) 2005, BMW introduced CAS as an optional feature package for the subject vehicles.The key for CAS equipped vehicles is an electronic code that is sent to the engine control module by a remote transmitter (key fob). An optional docking port (key slot) is provided for driver convenience or to put the vehicle into Car Wash mode, which allows for engine shutoff in neutral. BMW sold approximately 45,000 subject vehicles with CAS and approximately 94 percent of the CAS equipped vehicles were produced from MY 2006 through 2008. Non-CAS subject vehicles were produced from MY 2002 through 2008 and require the remote control to be in the ignition slot located next to the Start/Stop button to start the engine.The 50 incidents identified by ODI's analysis of complaints and field reports include 18 involving CAS vehicles (39.6 incidents per 100,000 vehicles) and 32 involving non-CAS vehicles (42.0 incidents per 100,000 vehicles). Because the incidents are considered random events, the failure rates were also adjusted for vehicle exposure, resulting in rat
Additional source detail variants (2)
Electrical System
In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional mechanical connection (e.g., cable or linkage) between the gearshift and automatic transmission with an electronic connection controlled by a computer module. When parking the vehicle, the driver has the capability to manually shift the vehicle to park by pressing the Park button on the end of the electronic gearshift lever. However, the instructions for engine shutoff provided in the owner's manual state that pressing the Start/Stop button serves the dual function of switching off the engine and automatically shifting the transmission to Park.In response to ODI's information request for PE11-025, BMW described several circumstances where the subject vehicles may shift to neutral when the driver may expect it to automatically shift to park. First, for Comfort Access System (CAS) vehicles, if the transmission is in neutral when the key fob is in the ignition slot and the Start/Stop button is pressed to shut-off the engine, the transmission will remain in neutral. This is referred to as the Carwash mode and is a normal operating feature of the vehicles that is described in the owner's manual. BMW also described two circumstances that are not normal operating features and are not described in the owners' manual: (1) with the transmission in drive or reverse and the engine running, if the Start/Stop button is pushed 2 or 3 times within a 0.3 second to 0.5 second interval, the engine will stop and the transmission will shift to Neutral; and 2) if the Park button on the gearshift lever is pressed at the same time that the gearshift lever is actuated (i.e., toggled up or down) to select drive, reverse or neutral; the transmission will shift to neutral or remain in neutral.Beginning in model year (MY) 2005, BMW introduced CAS as an optional feature package for the subject vehicles.The key for CAS equipped vehicles is an electronic code that is sent to the engine control module by a remote transmitter (key fob). An optional docking port (key slot) is provided for driver convenience or to put the vehicle into Car Wash mode, which allows for engine shutoff in neutral. BMW sold approximately 45,000 subject vehicles with CAS and approximately 94 percent of the CAS equipped vehicles were produced from MY 2006 through 2008. Non-CAS subject vehicles were produced from MY 2002 through 2008 and require the remote control to be in the ignition slot located next to the Start/Stop button to start the engine.The 50 incidents identified by ODI's analysis of complaints and field reports include 18 involving CAS vehicles (39.6 incidents per 100,000 vehicles) and 32 involving non-CAS vehicles (42.0 incidents per 100,000 vehicles). Because the incidents are considered random events, the failure rates were also adjusted for vehicle exposure, resulting in rat
Power Train:automatic Transmission
In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional mechanical connection (e.g., cable or linkage) between the gearshift and automatic transmission with an electronic connection controlled by a computer module. When parking the vehicle, the driver has the capability to manually shift the vehicle to park by pressing the Park button on the end of the electronic gearshift lever. However, the instructions for engine shutoff provided in the owner's manual state that pressing the Start/Stop button serves the dual function of switching off the engine and automatically shifting the transmission to Park.In response to ODI's information request for PE11-025, BMW described several circumstances where the subject vehicles may shift to neutral when the driver may expect it to automatically shift to park. First, for Comfort Access System (CAS) vehicles, if the transmission is in neutral when the key fob is in the ignition slot and the Start/Stop button is pressed to shut-off the engine, the transmission will remain in neutral. This is referred to as the Carwash mode and is a normal operating feature of the vehicles that is described in the owner's manual. BMW also described two circumstances that are not normal operating features and are not described in the owners' manual: (1) with the transmission in drive or reverse and the engine running, if the Start/Stop button is pushed 2 or 3 times within a 0.3 second to 0.5 second interval, the engine will stop and the transmission will shift to Neutral; and 2) if the Park button on the gearshift lever is pressed at the same time that the gearshift lever is actuated (i.e., toggled up or down) to select drive, reverse or neutral; the transmission will shift to neutral or remain in neutral.Beginning in model year (MY) 2005, BMW introduced CAS as an optional feature package for the subject vehicles.The key for CAS equipped vehicles is an electronic code that is sent to the engine control module by a remote transmitter (key fob). An optional docking port (key slot) is provided for driver convenience or to put the vehicle into Car Wash mode, which allows for engine shutoff in neutral. BMW sold approximately 45,000 subject vehicles with CAS and approximately 94 percent of the CAS equipped vehicles were produced from MY 2006 through 2008. Non-CAS subject vehicles were produced from MY 2002 through 2008 and require the remote control to be in the ignition slot located next to the Start/Stop button to start the engine.The 50 incidents identified by ODI's analysis of complaints and field reports include 18 involving CAS vehicles (39.6 incidents per 100,000 vehicles) and 32 involving non-CAS vehicles (42.0 incidents per 100,000 vehicles). Because the incidents are considered random events, the failure rates were also adjusted for vehicle exposure, resulting in rat