NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
78 reports65,350 miles · Jan 23, 2012
Air BagsSeat Belts
MY VEHICLE WAS PARKED FOR A WEEK FROM THE DATE THAT I LAST DRIVEN IT AND TO THE TIME I WENT AND START UP THE CAR. AFTER A WEEK OF NO USAGE AS SOON AS I STARTED THE CAR, THE PASSENGER SEAT BELT RESTRAINT AND AIRBAG LIGHT SHOWED UP AS A MALFUNCTION. AFTER DOING SOME RESEARCH I NOTICE THAT BMW HAD A RECALL ON A SEAT MAT SENSOR ON 2…
Read full complaint
MY VEHICLE WAS PARKED FOR A WEEK FROM THE DATE THAT I LAST DRIVEN IT AND TO THE TIME I WENT AND START UP THE CAR. AFTER A WEEK OF NO USAGE AS SOON AS I STARTED THE CAR, THE PASSENGER SEAT BELT RESTRAINT AND AIRBAG LIGHT SHOWED UP AS A MALFUNCTION. AFTER DOING SOME RESEARCH I NOTICE THAT BMW HAD A RECALL ON A SEAT MAT SENSOR ON 200,000 5 SERIES BUT AFTER TALKING TO BMW MY VEHICLE IS NOT COVERED UNDER THIS RECALL. I ALSO DID SOME RESEARCH AND NOTICE THAT THERE IS A GREAT AMOUNT OF PEOPLE WITH THIS SAME PROBLEM. THIS IS A MAJOR CONCERN BECAUSE THE SEAT MAT SENSOR IS BAD THE PASSENGER AIRBAG WILL NOT DEPLOY IF I GET INTO A CAR ACCIDENT. *TR
NHTSA ODI #10444862
Mileage unknown · Jan 6, 2012
Air BagsSeats
A PASSENGER RESTRAINT MALFUNCTION LIGHT HAS CAME ON MY 2005 545 BMW. AFTER DOING A LITTLE RESEARCH IT SEEMS THAT THIS PROBLEM IS QUITE COMMON ON BMWS AND I FEEL AS ITS AN ISSUE WITH THE PRODUCTION OF THE CAR AND SHOULD NOT BE AT THE OWNERS EXPENSE FOR A FAULTY PRODUCTION. MY EXTENDED WARRANTY DOES NOT COVER THIS REPAIR AND I'VE …
Read full complaint
A PASSENGER RESTRAINT MALFUNCTION LIGHT HAS CAME ON MY 2005 545 BMW. AFTER DOING A LITTLE RESEARCH IT SEEMS THAT THIS PROBLEM IS QUITE COMMON ON BMWS AND I FEEL AS ITS AN ISSUE WITH THE PRODUCTION OF THE CAR AND SHOULD NOT BE AT THE OWNERS EXPENSE FOR A FAULTY PRODUCTION. MY EXTENDED WARRANTY DOES NOT COVER THIS REPAIR AND I'VE CONTACTED THE BMWNA AND WAS TOLD THAT THERE IS A RECALL BUT NOT ON MY CAR. THE COST TO REPAIR IS OVER $2000 AND I FEEL THAT IT IS A SAFETY ISSUE BMW NEEDS TO ADDRESS SINCE THERE ARE SO MANY ISSUES WITH THE PASSENGER SEAT AIRBAG SENSORS. *TR
NHTSA ODI #10442679
112,200 miles · Dec 22, 2011
Power TrainCrashInjury
MY BMW 545I 2005 HAS EXPERIENCED PROBLEMS WITH MECHATRONICS FOR SOME TIME. ONE DAY I WAS DRIVING HOME AND MY CAR HAS DOWN SHIFTED FROM HIGH 4TH GEAR TO 2ND AND CAUSED ME TO DRIVE INTO A DITCH. LUCKILY I WAS WEARING A SEAT BELT BUT STILL EXPERIENCED NECK INJURIES FROM HITTING THE DITCH. THIS PROBLEM NEEDS A RECALL BEFORE SOME ON…
Read full complaint
MY BMW 545I 2005 HAS EXPERIENCED PROBLEMS WITH MECHATRONICS FOR SOME TIME. ONE DAY I WAS DRIVING HOME AND MY CAR HAS DOWN SHIFTED FROM HIGH 4TH GEAR TO 2ND AND CAUSED ME TO DRIVE INTO A DITCH. LUCKILY I WAS WEARING A SEAT BELT BUT STILL EXPERIENCED NECK INJURIES FROM HITTING THE DITCH. THIS PROBLEM NEEDS A RECALL BEFORE SOME ONE GETS KILLED. BMW CAN NO LONGER COVER THIS UP AND THIS ISSUE NEEDS TO BE INVESTIGATED. MANY FORMS ON THE INTERNET HAVE ADDRESSED THE SAME PROBLEM. THIS IS NO LONGER A ISSUE, ITS A LIFE SAFETY PROBLEM. *TR
NHTSA ODI #10440933
40,656 miles · Dec 16, 2011
Air Bags
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE FRONT PASSENGER AIR BAG WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THE CONTACT THAT THE FRONT PASSENGER SEAT CUSHION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 08V38…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE FRONT PASSENGER AIR BAG WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THE CONTACT THAT THE FRONT PASSENGER SEAT CUSHION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 08V384000 (AIR BAGS:FRONTAL) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 40,656 UPDATED 03/16/12 *BF
NHTSA ODI #10440203
Mileage unknown · Dec 1, 2011
Air BagsEngine And Engine CoolingPower Train
2005 BMW 545I. CONSUMER WRITES IN REGARDS TO SEVERAL ISSUES WITH VEHICLE TO INCLUDE PASSENGER SIDE AIRBAG, TRANSMISSION ISSUES AND LEAKS *TGW THE CONSUMER STATED THE ISSUE WITH THE PASSENGER SIDE AIR BAG WAS RECALLED. EVEN THOUGH THE PART WAS REPLACED TWICE UNDER WARRANTY AND EXHIBITED THE SAME SYMPTOMS AS STATED IN THE RECALL,…
Read full complaint
2005 BMW 545I. CONSUMER WRITES IN REGARDS TO SEVERAL ISSUES WITH VEHICLE TO INCLUDE PASSENGER SIDE AIRBAG, TRANSMISSION ISSUES AND LEAKS *TGW THE CONSUMER STATED THE ISSUE WITH THE PASSENGER SIDE AIR BAG WAS RECALLED. EVEN THOUGH THE PART WAS REPLACED TWICE UNDER WARRANTY AND EXHIBITED THE SAME SYMPTOMS AS STATED IN THE RECALL, THE CONSUMER'S VIN WAS NOT INCLUDED. THE CONSUMER ALSO STATED THERE WAS A JOLT/DELAY WHEN PULLING AWAY. WITHIN THE LAST THREE MONTHS, THE TRANSMISSION WOULD SHIFT BETWEEN 30-40 MPH AS IF IT WERE NOT GETTING ENOUGH FUEL. THERE WAS ALSO A COOLANT LEAK COMING FROM THE VALLEY PAN, A HOSE AND THE COOLANT TANK WERE REPLACED. THE ENGINE WAS REPLACED IN 2008, AND SINCE THEN, THE VEHICLE USED EXCESSIVE AMOUNTS OF COOLANT. *JB
NHTSA ODI #10437142
104,000 miles · Nov 23, 2011
Air BagsPower Train
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THE AIR BAG AND POWER TRANSMISSION WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE ALSO OCCASIONALLY STALLED WHILE DRIVING ON THE HIGHWAY. THE DEALER AND MANUFACTURER WERE NOTIFIED AND MADE THE CONTACT AWARE OF THE NHTSA CAMPAIGN ID NUMBER: 05V504000 (POWER…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THE AIR BAG AND POWER TRANSMISSION WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE ALSO OCCASIONALLY STALLED WHILE DRIVING ON THE HIGHWAY. THE DEALER AND MANUFACTURER WERE NOTIFIED AND MADE THE CONTACT AWARE OF THE NHTSA CAMPAIGN ID NUMBER: 05V504000 (POWER TRAIN:AUTOMATIC TRANSMISSION) AND THE NHTSA CAMPAIGN ID NUMBER: 08V384000 (AIR BAGS:FRONTAL) RECALL, BUT THE VIN WAS NOT ASSOCIATED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 104,000 AND THE CURRENT MILEAGE WAS 112,000.
NHTSA ODI #10436891
70,000 miles · Nov 17, 2011
Service Brakes, Hydraulic
OCCURRENCE IS VERY SIMILAR TO OID 10399328, 10328989 AND 10407868. FIRST OCCURRENCE WAS IN CONGESTED TRAFFIC CONDITIONS AT SLOW SPEED. THE VEHICLE SLOWED WHEN BRAKES WERE APPLIED NORMALLY BUT DID NOT COME TO A FULL STOP. HAD TO STOMP ON THE BRAKES WILL EXTREME FORCE TO AVOID COLLIDING WITH THE CAR IN FRONT. PROBLEM RECURRED INT…
Read full complaint
OCCURRENCE IS VERY SIMILAR TO OID 10399328, 10328989 AND 10407868. FIRST OCCURRENCE WAS IN CONGESTED TRAFFIC CONDITIONS AT SLOW SPEED. THE VEHICLE SLOWED WHEN BRAKES WERE APPLIED NORMALLY BUT DID NOT COME TO A FULL STOP. HAD TO STOMP ON THE BRAKES WILL EXTREME FORCE TO AVOID COLLIDING WITH THE CAR IN FRONT. PROBLEM RECURRED INTERMITTENTLY 3 TIME BEFORE REPAIRS. ADDITIONALLY, FREQUENTLY WHEN FOOT WAS ON BRAKE WHEN THE CAR WAS TURNED OFF THE PEDAL WOULD FORCEFULLY PUSH BACK AGAINST FOOT. SERVICE ON RECALL FOR HYDRAULIC POWER VACUUM PUMP ON THE BOOSTER WAS PERFORMED IN JANUARY. DEALER SAID THE CURRENT PROBLEM IS NOT COVERED UNDER THE RECALL AS IT IS A COMPLETE BOOSTER FAILURE NOT THE VACUUM PUMP. MY PERCEPTION IS THAT THE FIRST RECALL WAS NOT COMPREHENSIVE ENOUGH TO ADDRESS A LARGER GENERAL PROBLEM VEHICLE'S BOOSTER BRAKING SYSTEM. *TR
NHTSA ODI #10436284
64,000 miles · Oct 4, 2011
Engine And Engine Cooling
THE COOLANT TRANSFER PIPE WHICH RUNS THROUGH THE ENGINE LEAKED ALL OF THE COOLANT AND REQUIRED AN IMMEDIATE SHUT DOWN. IT REQUIRED A REPAIR COSTING APPROXIMATELY $6,700 WHICH INCLUDED 38 HOURS OF LABOR. THIS IS CLEARLY A DESIGN FLAW. IT IS WIDELY CITED ON THE INTERNET. *TR
NHTSA ODI #10428680
87,500 miles · Jun 21, 2011
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2005 BMW 545I. WHILE DRIVING APPROXIMATELY 45 MPH AND DEPRESSING THE BRAKES, THE BRAKE PEDAL DROPPED TO THE FLOOR BOARD. THE CONTACT APPLIED EXCESSIVE PRESSURE TO THE BRAKE PEDAL IN ORDER FOR THE VEHICLE TO COME TO A STOP. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE APPROXIMATE …
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 545I. WHILE DRIVING APPROXIMATELY 45 MPH AND DEPRESSING THE BRAKES, THE BRAKE PEDAL DROPPED TO THE FLOOR BOARD. THE CONTACT APPLIED EXCESSIVE PRESSURE TO THE BRAKE PEDAL IN ORDER FOR THE VEHICLE TO COME TO A STOP. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 87,500.
NHTSA ODI #10407674
83,000 miles · Jun 16, 2011
Wheels
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE REAR PASSENGER WHEEL DEFLATED WHILE IN MOTION. THE CONTACT DISCOVERED THAT THE WHEEL WAS FRACTURED IN HALF. THE WHEEL WAS REPLACED AND BOTH THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000 AND THE CURRENT MILEAGE WAS 90,0…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE REAR PASSENGER WHEEL DEFLATED WHILE IN MOTION. THE CONTACT DISCOVERED THAT THE WHEEL WAS FRACTURED IN HALF. THE WHEEL WAS REPLACED AND BOTH THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000 AND THE CURRENT MILEAGE WAS 90,000.
NHTSA ODI #10407103
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Illustration