NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
78 reportsMileage unknown · May 14, 2014
Air Bags
TL*THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN RECALL NUMBER: 13V564000 (AIR BAGS) BUT WAS ADVISED BY THE DEALER THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT RECEIVED THE NOTICE SEVERAL MONTHS AGO. THE MANUFACTURER WAS ALSO CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE…
Read full complaint
TL*THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN RECALL NUMBER: 13V564000 (AIR BAGS) BUT WAS ADVISED BY THE DEALER THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT RECEIVED THE NOTICE SEVERAL MONTHS AGO. THE MANUFACTURER WAS ALSO CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE RECALL REPAIR WOULD BE PERFORMED. THERE WERE NO FAILURES AT THIS TIME.
NHTSA ODI #10588289
Mileage unknown · Jan 13, 2014
Air Bags
PASSENGER SIDE AIRBAG FAULT LIGHT STAYS ON. DEALER SAID PROBLEM WASN'T UNDER WARRANTY. INFORMATION I FOUND ON THE INTERNET AND BMW SITES SAY IT IS UNDER WARRANTY. I AM AFRAID IF I'M IN AN ACCIDENT, MY PASSENGER COULD BE SERIOUSLY INJURED, OR KILLED. *TR
NHTSA ODI #10559738
75,000 miles · Jan 13, 2014
Air Bags
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE PULLING INTO HIS DRIVEWAY AT UNKNOWN SPEEDS, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.
NHTSA ODI #10559698
94,000 miles · Sep 4, 2013
Electrical SystemExterior Lighting
I TURNED MY CAR ON AND IT IMMEDIATELY WARNED ME THAT MY LEFT READ BRAKE LAMP WAS NOT FUNCTIONING. TO BE SPECIFIC, THERE WERE FOUR WARNING LIGHTS ON: ONE FOR THE REVERSE LIGHTS, ONE FOR THE BRAKE LAMP, AND TWO OTHER ONES. ALL FOR THE LEFT LIGHT. I OPENED IT UP AND IMMEDIATELY OBSERVED THAT THE WIRING HARNESS PLUG WHERE THE WI…
Read full complaint
I TURNED MY CAR ON AND IT IMMEDIATELY WARNED ME THAT MY LEFT READ BRAKE LAMP WAS NOT FUNCTIONING. TO BE SPECIFIC, THERE WERE FOUR WARNING LIGHTS ON: ONE FOR THE REVERSE LIGHTS, ONE FOR THE BRAKE LAMP, AND TWO OTHER ONES. ALL FOR THE LEFT LIGHT. I OPENED IT UP AND IMMEDIATELY OBSERVED THAT THE WIRING HARNESS PLUG WHERE THE WIRING MEETS THE BULB HOLDER HAD SHORTED AT THE GROUND WIRE. THE TWO PIECES WERE MELTED TOGETHER, SUGGESTING THERE MAY HAVE BEEN A SMALL FIRE. BITS OF MELTED PLASTIC FELL ALL OVER THE PLACE WHEN I MANAGED TO FINALLY PULL OUT THE PLUG. *JB
NHTSA ODI #10541958
54,000 miles · Aug 23, 2013
EquipmentStructure
I WAS JACKING UP MY BMW IN MY GARAGE USING A PROPER FLOOR JACK ON THE RIGHT SIDE REAR JACKPOINT STAND BUILT TO JACK THE CAR UP FROM THE RIGHT REAR. THE JACKPOINT FAILED AFTER IT WAS APPROXIMATELY 6 INCHES OFF GROUND, AND THE VEHICLE DROPPED BACK TO THE FLOOR WHERE THE ENTIRE JACKPOINT WAS NOW COLLAPSED INSIDE OF THE FRAME. I…
Read full complaint
I WAS JACKING UP MY BMW IN MY GARAGE USING A PROPER FLOOR JACK ON THE RIGHT SIDE REAR JACKPOINT STAND BUILT TO JACK THE CAR UP FROM THE RIGHT REAR. THE JACKPOINT FAILED AFTER IT WAS APPROXIMATELY 6 INCHES OFF GROUND, AND THE VEHICLE DROPPED BACK TO THE FLOOR WHERE THE ENTIRE JACKPOINT WAS NOW COLLAPSED INSIDE OF THE FRAME. I CONTACTED BMW DEALER IN CHAPEL HILL,NC, AND ALSO BMWNA WHO OPENED A CASE UNDER MY VIN NUMBER, AND HAD ME BRING THE VEHICLE INTO THE DEALER FOR AN INSPECTION, AND THAT THEY WOULD LOOK THINGS OVER, AND CORRECT THE SITUATION. THE DEALER TOOK 4 WEEKS TO GET BACK, AND TOLD ME THEY NEEDED TO SEE THE CAR AGAIN TO TAKE PHOTOS, AND LOOK IT OVER AGAIN SO I TOOK IT BACK TO THE SAME DEALER IN CHAPEL HILL, NC (PERFORMANCEBMW). THEY TOOK ANOTHER 4 WEEKS, AND ASKED IF I COULD BRING IT BACK AGAIN AS THEY NEEDED A SPECIALIST WHO TRAVELS TO THE DEALERSHIP TO LOOK OVER THE VEHICLE, AND SO I TOOK IT IN AGAIN A 3RD TIME. I THOUGHT FINALLY THEY WOULD RESOLVE THIS ISSUE, BUT AFTER THE 3RD VISIT THEY HAVE NEGLECTED TO CONTACT ME BACK, AND UPON MYSELF CONTACTING THEM 2 -3 WEEKS AFTER THE VISIT I WAS TOLD IT WOULD NOT BE COVERED ,AND THAT BMWNA WOULD TAKE NO FURTHER ACTION INTO REPAIRING MY VEHICLE. THIS IS A HUGE SAFETY ISSUE WHICH I HAVE READ HAS HAPPENED TO OTHERS, AND THEIR IS ABSOLUTELY NO RUST ON THE UNDERSIDE OF MY CAR, AND IT WAS NOT IN AN ACCIDENT. THE FRAME DID NOT HAVE ANY DAMAGE WHATSOEVER UNTIL THIS JACKPOINT FAILURE, AND NOW THEY JUST WANT TO NOT RETURN MY CALLS, AND NOT HELP AT ALL. ANYONE LOOKING CAN CLEARLY SEE THE JACKPOINT BROKE ON THE INSIDE, AND YOU CAN SEE THE WELD POINTS THAT HAVE FAILED ON THE FRAME. IS THERE ANYTHING YOU COULD POSSIBLY DO TO HELP WITH THIS SINCE IT IS A SERIOUS SAFETY CONCERN. THE FIX WOULD MEAN PULLING THE JACKPOINT BACK DOWN FROM THE INSIDE OF THE FRAME, AND RE-WELDING THE SIDE OF THE JACKPOINT. *TR
NHTSA ODI #10537024
111,000 miles · Jul 30, 2013
Service Brakes
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND. AFTER REPEATED ATTEMPTS AND FULL BODILY FORCE, THE VEHICLE THEN CAME TO A STOP.THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT …
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND. AFTER REPEATED ATTEMPTS AND FULL BODILY FORCE, THE VEHICLE THEN CAME TO A STOP.THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT THAT THE BRAKE VACUUM PUMP WOULD NEED TO BE REPLACED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 10V446000 (SERVICE BRAKES, HYDRAULIC) BUT WAS ADVISED THAT THE VIN WAS INELIGIBLE UNDER THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.
NHTSA ODI #10532712
120,000 miles · Jun 5, 2013
Air BagsElectrical System
MY CAR HAVE AN OVERHEATED CABLE CONNECTION AND IS CAUSING INCREASED ELECTRIC RESISTANCE, WHICH IS A RECALL AND ALSO THE PASSENGER AIRBAG LIGHT IS ON AND BMW REFUSE TO FIX THE ISSUES.. THEY SAY MY VIN WASN'T ONE OF THE CAR THAT'S IN THEIR DATABASE FOR THE RECALLS........ *TR
NHTSA ODI #10515172
120,000 miles · May 1, 2013
Electrical SystemSteering
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE STEERING WHEEL BECAME VERY STIFF AND THE POWER STEERING DEACTIVATED WARNING LAMP ILLUMINATED. THE CONTACT MENTIONED THAT AFTER RESTARTING THE VEHICLE, ALL OF THE WARNING LAMPS ILLUMINATED AND AN ELECTRONIC MALFUNCTION WARNING MESSAGE SHOWED U…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE STEERING WHEEL BECAME VERY STIFF AND THE POWER STEERING DEACTIVATED WARNING LAMP ILLUMINATED. THE CONTACT MENTIONED THAT AFTER RESTARTING THE VEHICLE, ALL OF THE WARNING LAMPS ILLUMINATED AND AN ELECTRONIC MALFUNCTION WARNING MESSAGE SHOWED UP BEFORE THE VEHICLE STALLED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE 120,000. *TR
NHTSA ODI #10510213
99,500 miles · Mar 18, 2013
Air Bags
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE FRONT PASSENGER SEAT AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 08V384000 (AIR BAGS:FRONTAL). THE VEHICLE WAS NOT R…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE FRONT PASSENGER SEAT AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 08V384000 (AIR BAGS:FRONTAL). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE WAS 99,500 AND THE CURRENT MILEAGE WAS 100,000.
NHTSA ODI #10503402
104,000 miles · Jan 15, 2013
Air Bags
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THAT THE FRONT PASSENGER SEAT ENTRY MAT WOULD NEED TO BE REPLACED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 0…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THAT THE FRONT PASSENGER SEAT ENTRY MAT WOULD NEED TO BE REPLACED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 08V384000 (AIR BAGS:FRONTAL) THAT HOWEVER, THE MANUFACTURER ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.
NHTSA ODI #10493073
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Illustration