2008 BMW 535XI

ON JANUARY 5, 2014 DRIVING ON THE HIGHWAY APPROX. 55 MPH THE VEHICLE'S DISPLAYED ENGINE AND TRANSMISSION MALFUNCTION DROPPED MY RATE OF SPEED TO APPROXIMATELY 20 MPH (SAFETY MODE) ALMOST SUSTAINED A REAR END COLLISION I THEN PULLED OVER ONTO THE SHOULDER I TURNED THE CAR OFF WAITED 10 MINUTES AND TURNED IT ON WITHOUT ANY ISSUES. I TOOK THE CAR TO BMW OF TENAFLY, NJ THEY INSPECTED THE VEHICLE MADE SOME ADJUSTMENTS AND SAID THE CAR WAS GOOD TO DRIVE ON THE WAY HOME TRAVELING APPROX. 45 MPH THE CAR AGAIN DISPLAYED ENGINE AND TRANSMISSION MALFUNCTION DROPPED MY RATE OF SPEED TO APPROXIMATELY 20 MPH (SAFETY MODE) I PULLED OVER I TURNED THE CAR OFF WAITED 10 MINUTES AND TURNED IT ON THE MALFUNCTION CONTINUED THE NEXT DAY I BROUGHT THE VEHICLE BACK TO BMW OF TENAFLY, NJ THEY CHANGED THE CONTROL MODULE AND SOME OTHER COMPONENT IN THE ENGINE. ON JUNE 10, 2014 DRIVING ON I95 TRAVELING APPROXIMATELY 65 MPH THE CAR ONBOARD DISPLAY SHOWED A TRANSMISSION MALFUNCTION AND DROPPED MY RATE OF SPEED TO APPROXIMATELY 20 MPH (SAFETY MODE), I PULLED OVER ONTO THE SHOULDER I TURNED THE CAR OFF WAITED 10 MINUTES AND TURNED IT ON WITHOUT ANY ISSUES. TRAFFIC CONDITIONS WERE LIGHT, BUT COULD POTENTIALLY BE A SERIOUS ISSUE (ACCIDENT OR FATALITY) DURING NORMAL TRAFFIC CONDITIONS. ON JUNE 9, 2014 I FILED A REPORT WITH BMW USA AND I HAVE SCHEDULED AN APPOINTMENT WITH THE SERVICE DEPARTMENT BMW OF TENAFLY, NJ. *TR

E61 WAGON, REAR HATCH: I DISCOVERED FAILURES OF MULTIPLE WIRES IN THE TAILGATE/REAR WINDOW WIRING HARNESSES. THROUGH RESEARCH ONLINE I HAVE FOUND THIS IS A COMMON PROBLEM WITH THIS VEHICLE OVER SEVERAL MODEL YEARS - SEARCH FOR BMW E61 TAILGATE WIRING PROBLEMS. THE FAILURES ARE CAUSED BY A POOR DESIGN WHERE THE WIRES ENTERING THE HINGE GUIDES (4) FOR THE GLASS AND TAILGATE ARE REPEATEDLY FLEXED AT A SHARP ANGLE UNTIL THE INSULATION, THEN THE COPPER WIRE BREAKS. SAFETY ISSUES - POSSIBLE ELECTRICAL SHORT CIRCUIT LEADING TO FIRES (HIGHEST LOAD IS FOR REAR DEFROSTER); LIGHTING FAILURES (REAR HIGH BRAKE LIGHT, LICENSE PLATE LAMPS AND OTHERS); REDUCED VISIBILITY DUE TO LOSS OF WIPER/WASHER/DEFROSTER; REAR GLASS LATCH OPENING WHILE UNDERWAY, POSSIBLY RESULTING IN LOSS OF CARGO OR INGRESS OF EXHAUST FUMES. THIS IS NOT AN EASILY REPAIRED PROBLEM. IT WOULD BE BEYOND THE CAPABILITIES OF ALL BUT A SKILLED MECHANIC WITH PROPER TOOLS. I DISCOVERED IT WHEN THE REMOTE LOCK/UNLOCK USING THE KEY FOBS FAILED. AS I INVESTIGATED I FOUND THE BROKEN WIRE, ALONG WITH SEVERAL OTHERS WITH BROKEN INSULATION, SOME WITH BROKEN COPPER STRANDS. *TR

FUEL INJECTORS WERE REPLACED ON THIS VEHICLE IN 05/2011 DUE TO A FAULTY DESIGN UNDER A RECALL THROUGH BMW. THE SAME INJECTORS HAVE SUBSEQUENTLY FAILED AGAIN LESS THAN 3 YEARS SINCE THEY WERE REPLACED. THIS RESULTED IN A LOSS OF POWER WHILE OPERATING THE VEHICLE PUTTING ME AT RISK. BMW FAILS TO TAKE RESPONSIBILITY SAYING WARRANTY ON PARTS HAS EXPIRED ON PARTS THAT HAVE BEEN PREVIOUSLY RECALLED WITH KNOWN ISSUES. *TR

WHILE DRIVING THE 2008 BMW 535XI, THERE WAS A LOUD SOUND FROM THE ENGINE. A MESSAGE APPEARED "CAR OVERHEATED" AND THE CAR STOPPED IN THE MIDDLE OF THE ROAD. THE WATER PUMP FAILED WITH ABSOLUTELY NO WARNING. THE ACCELERATION WOULD NOT WORK AT ALL AND THE CAR WAS ESSENTIALLY INOPERABLE. IT WAS A VERY DIFFICULT SITUATION WITH VEHICLES APPROACHING ME FROM BEHIND ESPECIALLY WITH NO SHOULDER SPACE AVAILABLE TO PULL THE CAR OVER. I MANAGED TO TURN ONT HE HAZARD LIGHTS AND BARELY MANAGED TO ESCAPE THIS SITUATION WITHOUT AN INCIDENT. THE VEHICLE WAS TOWED TO A DEALER AND I WAS INFORMED THAT THE AUXILIARY WATER PUMP HAD FAILED AND WILL HAVE TO REPLACE IT, THE COST OF WHICH WOULD BE AT LEAST $1,200. WHEN I LOOKED UP ON THE INTERNET REGARDING THIS ISSUE, I HAVE SEEN MANY INDIVIDUALS COMPLAINING ABOUT THE WATER PUMP IN LESS THAN AS LITTLE AS 30,000 MILES. I ALSO STUMBLED ONTO A NHTSA RECALL CAMPAIGN (NO. 11V-521: "ELECTRIC AUXILIARY WATER PUMP") ON CERTAIN 2008 BMW 5-SERIES. I WAS SHOCKED TO KNOW THAT MY VEHICLE WAS NOT INCLUDED IN THIS CAMPAIGN NUMBER. WHAT TYPE OF QUALITY CHECKS ARE THESE PUMPS SUBJECTED TO? I HAVE HEARD OF MANY SUCH INSTANCES WITH THIS YEAR, MAKE AND MODEL. MOST OTHER VEHICLES HAVE WATER PUMPS LASTING OVER 100,000 MILES AND WELL BEYOND. WHY HASN'T BMW ISSUED A RECALL? *TR

THE CAR HAS BEEN REPLACED A PUMP SENSORS 40 DAYS AGO BECAUSE OF THE ENGINE MALFUNCTION ,AND TWO WEEKS AGO WHILE STARTED IN COLD WEATHER, IT WAS SHAKING AND THE ENGINE LIGHT ON. THE DEALER CHECKED AND SAID THAT IT IS THE INJECTOR PROBLEM AND RECOMMEND TO CHANG ALL 6 INJECTORS. BUT THE INJECTORS HAVE BEEN CHANGED AT THE MILEAGE OF 27,000 IN 2010. *TR

I DISCOVERED MULTIPLE SEVERED WIRES IN THE TAILGATE/REAR WINDOW WIRING HARNESSES. THROUGH RESEARCH ONLINE I HAVE FOUND THIS IS A COMMON PROBLEM WITH THIS VEHICLE OVER SEVERAL MODEL YEARS - SEARCH FOR BMW E61 TAILGATE WIRING PROBLEMS. THE FAILURES ARE CAUSED BY A POOR DESIGN WHERE THE WIRES ENTERING THE HINGE GUIDES (4) FOR THE GLASS AND TAILGATE ARE REPEATEDLY FLEXED AT A SHARP ANGLE UNTIL THE INSULATION, THEN THE COPPER WIRE BREAKS. SAFETY ISSUES - POSSIBLE ELECTRICAL SHORT CIRCUIT LEADING TO FIRES (HIGHEST LOAD IS FOR REAR DEFROSTER); LIGHTING FAILURES (REAR HIGH BRAKE LIGHT, LICENSE PLATE LAMPS AND OTHERS); REDUCED VISIBILITY DUE TO LOSS OF WIPER/WASHER/DEFROSTER; REAR GLASS LATCH OPENING WHILE UNDERWAY, POSSIBLY RESULTING IN LOSS OF CARGO OR INGRESS OF EXHAUST FUMES. THIS IS NOT AN EASILY REPAIRED PROBLEM. IT WOULD BE BEYOND THE CAPABILITIES OF ALL BUT A SKILLED MECHANIC WITH PROPER TOOLS. I DISCOVERED IT WHEN THE REAR WIPER AND REAR WINDOW DEFROSTER STOPPED WORKING. AS I INVESTIGATED I FOUND THE BROKEN WIRES, ALONG WITH SEVERAL OTHERS WITH BROKEN INSULATION, SOME WITH BROKEN COPPER STRANDS." *TR

THE REAR RIGHT TAIL LIGHT STOPPED FUNCTIONING CORRECTLY, AND THE BRAKE LIGHT, THE RUNNING LIGHT, THE REVERSE LIGHT, AND THE BLINKER STOPPED WORKING. THIS CREATED MANY POTENTIAL ACCIDENTS AS ONCOMING DRIVERS COULD NOT PROPERLY SEE ME REVERSING OR TURNING RIGHT. THERE IS AN ACTIVE RECALL FOR THE ISSUE AND BMW IS REPLACING THE REAR TAIL LIGHTS FOR VIN'S THAT THE GOVERNMENT HAS IDENTIFIED AS HAVING THE ISSUE. MY VEHICLE HAS THE ISSUE. BMW REFUSED TO REPLACED THE TAIL LIGHT THAT HAS PERMANENT LOSS OF FUNCTIONALITY. I WAS FORCED TO PAY OUT OF POCKET FUNDS FOR THE ITEM THAT HAS A RECALL AND BMW NORTH AMERICA HAS REFUSED TO ASSIST IN THIS MATTER. I SPOKE TO [XXX] AT BMW NORTH AMERICA, HE IS A CUSTOMER RELATIONS SUPERVISOR, AND HIS CONTACT INFORMATION IS IN THE BMW CASE FILE WITH ID LAST 7 DIGITS OF MY VIN. HE INDICATED THAT BMW WILL NOT DO ANYTHING UNLESS THE GOVERNMENT FORCES THEM TO BY PROVIDING THE VIN NUMBER TO THEM AS AN EFFECTED VEHICLE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WARNING LIGHTS CAME ON WHILE DRIVING THE CAR. WINDSHIELD WIPERS STARTED GOING ON (WITHOUT BEING TURNED ON). BRAKE AND TAIL LIGHTS FAILED INTERMITTENTLY. GAUGES ALL WENT TO ZERO INTERMITTENTLY WHILE DRIVING. SUNROOF WOULDN'T CLOSE. DROVE TO DEALER. DIAGNOSED AS ELECTRICAL SYSTEM COMPONENTS SUBMERGED IN REAR OF CAR DUE TO BLOCKED SUNROOF DRAIN. THE SAME ISSUE WAS REPAIRED A YEAR PRIOR. THIS TIME TO LIABILITY ASSUMED BY MANUFACTURER OR DEALER BECAUSE OF "OUTSIDE FORCE" (RAIN). $9,500 REPAIR ESTIMATE. APPEARS TO BE A COMMON PROBLEM/ FLAW WITH THE MODEL. DEALER DID NOT APPEAR TO DO A CHECK OF THE DRAINAGE SYSTEM WHILE CAR WAS IN FOR ROUTINE SERVICE A MONTH BEFORE THE INCIDENT. NO LOSS OF STEERING OR ENGINE WHILE DRIVING. *TR