2008 BMW 535XI

I RECENTLY PURCHASED A 2008 BMW 535XI AND HAVE HAD IT FOR ABOUT A WEEK OR SO. IT HAS SPENT MORE TIME IN THE SHOP THAN ON THE ROAD DUE TO FUEL INJECTORS CAUSING MISFIRES AND NOW THE HIGH PRESSURE FUEL PUMP HAS GONE OUT. I RECENTLY FOUND OUT ALSO THAT THIS IS A COMMON ISSUE WITH BMW AND THEY ARE PRETENDING THAT THE FUEL PUMP MALFUNCTION IN 3 & 5 SERIES ISN'T THEIR FAULT. I CHECKED THE CARFAX ON THE VEHICLE BEFORE BUYING IT AND IT WAS SERVICED REGULARLY AT A BMW DEALERSHIP. AFTER FURTHER RESEARCH I ALSO HAVE FOUND OUT THAT THE DEALERSHIP TOTALLY IGNORED THE RECALLS AND SCREWED OVER THE FIRST OWNER. BMW NEEDS TO TAKE FULL RESPONSIBILITY FOR SELLING CARS WITH KNOWN DEFECTIVE PARTS. I HAVE TO DROP $3800 TO FIX THE PROBLEMS THAT THE FUEL PUMP HAS CAUSED. THE CAR WON'T EVEN START NOW.

I PURCHASED A 2008 BMW 5 SERIES WAGON 9/1/2015 ON CALIFORNIA HAD ITS FIRST RAIN STORM CAUSING CATASTROPHIC FAILURE OF THE ENTIRE ELECTRICAL SYSTEM OF THE BMW RESULTING IN A COMPLETE LOSS 12/16/115. THE DRAIN LINES ARE A WELL DOCUMENTED AND A BMW SERVICE BULLETIN WAS ISSUED TO DEALERSHIPS. WHILE DRIVING ON THE HIGHWAY, I EXPERIENCED WIDESPREAD SYSTEM FAILURE, TIRE WARNINGS, TRANSMISSION FAILURE WARNINGS AND THE SUSPENSION FAILED AND THE CAR DROPPED ABOUT 6 INCHES. THE BMW DEALERSHIP GAVE US $24,188.17 REPAIR ESTIMATE FOR ALL THE ELECTRICAL COMPONENTS AND WIRING WHICH IS MORE THAN THE VALUE OF THE CAR

TL* THE CONTACT OWNS A 2008 BMW 535XI. THE CONTACT STATED THAT AFTER EXITING THE VEHICLE AND TOUCHING THE HANDLE TO LOCK THE DOORS VIA THE KEYLESS ENTRY FEATURE, THE CONTACT FAILED TO REALIZE THAT THE PASSENGER HAD NOT EXITED THE VEHICLE. THE PASSENGER WAS UNABLE TO UNLOCK THE DOORS AND REMAINED TRAPPED IN THE VEHICLE WITH THE WINDOWS UP FOR APPROXIMATELY 15 MINUTES UNTIL THE DRIVER CAME BACK TO UNLOCK THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS EXPLAINED THAT WHAT THE CONTACT PERCEIVED AS A FAILURE WAS A SECURITY FEATURE OF THE VEHICLE AND WAS NOT CONSIDERED A DEFECT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

APRIL 2013, BMW DEALER #1 (SELLER) WAS TOLD BY SELLING DEALER THAT RESTRAINT SYSTEM MALFUNCTION LIGHT JUST CAME ON HOURS BEFORE DELIVERY.. WAS TOLD TO BRING CAR TO A DEALER IN MY STATE AND THEY WILL FIX IT, NO CHARGE SINCE CAR IS STILL UNDER MANUFACTURER EXTENDED WARRANTY; MAY 23, 2013 BMW DEALER #2 (SERVICE) RESTRAINT SYSTEM MALFUNCTION LIGH IS ON.. DEALER #2 ADVISED THAT BST CABLE WAS SLICED, HENCE WARRANTY DOES NOT COVER THE REPAIR, WHICH WAS $1,000.00. JUNE 12, 2013 BMW DEALER #3 (SERVICE) WENT TO DEALER #3 FOR SECOND OPINION, SURPRISED WITH TOTALLY DIFFERENT DIAGNOSIS AND FIXED FOR $117.00.. BELOW IS THE ACTUAL DEALER FINDINGS AND FIXED; , , , , 93398 SPORADIC FAULT RAN, SHORT TEST, CONNECTED CHARGER 12.31V , , , , FAULTS ACTIVE HEAD RESTRAIN FIRING CIRCUIT, FAULT OCCURENCE 1, FAULT , , , , CURRENTLY NOT PRESENT INSPECTED CONNECTIONS AND LINES, CHECKED , , , , MEASURED RESISTANCE AS SEEN BY MODUAL, WITHIN SPEC. CLEARED , , , , FAULT MEMORY SEPTEMBER 2014 BMW DEALER #3 (SERVICE) RESTRAINT SYSTEM MALFUNCTION LIGH IS ON IS BACK.!! TOOK IT BACK TO DEALER #3.. THIS TIME DIAGNOSIS WAS THAT THE BST CABLE IS CORRODED DUE TO WATER IN THE REAR VENT IN THE BATTERY AREA.. BST CABLE NEEDS TO BE REPLACED AND COST $919.98. SUMMARY: APRIL 2013 DEALER #1 STATES, RESTRAINT SYSTEM DEALER FIX, NO CHARGE. MAY 2015, DEALER #2 STATES BST CABLE GOT SLICED, $1,000.00 REPAIR JUNE 2013 DEALER #3 STATES HEAD RESTRAINT FIRING CIRCUIT, FIXED IT FOR $117.00 SEPT 2014 DEALER #3 NOW STATES BST CABLE GOT CORRODED, $919.98 TO REPAIR WHY ARE THEIR FINDINGS OF THE PROBLEM ARE SO INCONSISTENT??

I HAD THE PASSENGER RESTRAINT MALFUNCTION ERROR SHOW UP ON MY VEHICLE'S DASH IN 2013. AT THAT TIME, THE DEALERSHIP REPLACED SOME MODULE IN THE DRIVER'S SIDE HEADREST. NOT SURE WHY WOULD THEY HAVE A REPLACE A MODULE IN "DRIVER SIDE" WHEN THE ERROR IS IN "PASSENGER SIDE." BUT I DIDN'T ARGUE AND LET THEM REPLACE IT AND PAID $400 FOR THE PRIVILEGE. NOW AGAIN IN APRIL 2015, SAME ERROR IS HAPPENING. FIRST THE DEALER (BMW OF CLEVELAND, SOLON, OH) COULDN'T FIND THE PROBLEM FOR 2 DAYS. BUT WHEN I TOLD THEM ABOUT THE HISTORY OF THE VEHICLE, THEY SAY THAT NOW THE WHOLE DRIVER'S SIDE HEADREST NEEDS TO BE REPLACED AND THE COST IS A WHOPPING $700. THE CAR SHOWS PROBLEM IN PASSENGER SIDE, AND DEALER SAYS DRIVER SIDE HEADREST NEEDS TO BE REPLACED. THIS IS PREPOSTEROUS! LOOKS LIKE THE DEALER IS TRYING TO SCAM ME ON THIS. IS THERE ANY RECALL ON THIS?

I WAS EXITING THE THE FREEWAY AND WHEN I WAS ON A BANKED ONRAMP THE ENGINE STOPPED RUNNING WHILE VEHICLE WAS IN MOTION. I LOST POWER STEERING AND THE ABILITY TO RELEASE THE BRAKE. I NEARLY LOST CONTROL OF THE VEHICLE AS THE UNEXPECTED LOSS IN POWER STEERING CAUSED ME TO LOOSE GRIP ON THE WHEEL. THE ENGINE WAS IN NEUTRAL WHEN THE ENGINE STALLED. UPON RESTARTING THE ENGINE (WHICH STRUGGLED TO START) THE "SERVICE ENGINE SOON TELLTALE" ILLUMINATED AND THE VEHICLE ENTERED "REDUCE ENGINE POWER MODE". AFTER SCANNING THE DTC (P3090) I LEARNED THE VEHICLE'S HIGH PRESSURE FUEL PUMP FAILED. I NOTICED BMW HAS A RECALL ON THE ISSUE. UNFORTUNATELY THEIR RECALL ONLY COVERS THE FUEL PUMP TO 120,000 MILES AND MY VEHICLE HAS ROUGHLY 9,500 MILES ABOVE THE COVERED THRESHOLD. BASED ON MY EXPERIENCE AND READING ONLINE I FEEL THE PUMP HAS SOME SORT OF DESIGN FLAW THAT BMW HAS FAILED TO PROPERLY ADDRESS. I WISH BMW WOULD HOLD UP TO THEIR INTEGRITY AND CONTINUE TO REPLACE THE FUEL PUMP FOR THE LIFE OF THE VEHICLE.

I DISCOVERED FAILURES OF MULTIPLE WIRES IN THE TAILGATE/REAR WINDOW WIRING HARNESSES. THROUGH RESEARCH ONLINE I HAVE FOUND THIS IS A COMMON PROBLEM WITH THIS VEHICLE OVER SEVERAL MODEL YEARS - SEARCH FOR BMW E61 TAILGATE WIRING PROBLEMS. THE FAILURES ARE CAUSED BY A POOR DESIGN WHERE THE WIRES ENTERING THE HINGE GUIDES (4) FOR THE GLASS AND TAILGATE ARE REPEATEDLY FLEXED AT A SHARP ANGLE UNTIL THE INSULATION, THEN THE COPPER WIRE BREAKS. SAFETY ISSUES - POSSIBLE ELECTRICAL SHORT CIRCUIT LEADING TO FIRES (HIGHEST LOAD IS FOR REAR DEFROSTER); LIGHTING FAILURES (REAR HIGH BRAKE LIGHT, LICENSE PLATE LAMPS AND OTHERS); REDUCED VISIBILITY DUE TO LOSS OF WIPER/WASHER/DEFROSTER; REAR GLASS LATCH OPENING WHILE UNDERWAY, POSSIBLY RESULTING IN LOSS OF CARGO OR INGRESS OF EXHAUST FUMES. THIS IS NOT AN EASILY REPAIRED PROBLEM. IT WOULD BE BEYOND THE CAPABILITIES OF ALL BUT A SKILLED MECHANIC WITH PROPER TOOLS. I DISCOVERED IT WHEN THE REMOTE LOCK/UNLOCK USING THE KEY FOBS FAILED. AS I INVESTIGATED I FOUND THE BROKEN WIRE, ALONG WITH SEVERAL OTHERS WITH BROKEN INSULATION, SOME WITH BROKEN COPPER STRANDS. *TR

WHILE DRIVING AT 55MPH NOT CLOSE TO THE VEHICLE IN FRONT OF ME AND WITH NO ONCOMING TRAFFIC, AND WITH THE SUNROOF CLOSED, THERE WAS A SUDDEN "EXPLOSION" ABOVE MY HEAD. IT WAS A VERY LOUD NOISE AND MY FIRST THOUGHT WAS THAT THE SUNROOF HAD BEEN SHOT. BEFORE I HAD TIME TO PULL OVER, THE SHATTERED GLASS OF THE SUNROOF BLEW OFF THE ROOF ONTO THE ROAD BEHIND ME. I DID NOT SEE ANYTHING COME OFF THE VEHICLE IN FRONT OF ME, THERE WAS NO ONCOMING TRAFFIC, AND I WAS NOT GOING UNDER A BRIDGE OF ANY KIND. IT WAS AS IF THE SUNROOF SPONTANEOUSLY EXPLODED. HAD THE SUNROOF CURTAIN NOT BEEN CLOSED, ALL THAT GLASS WOULD HAVE COME INTO THE CAR AND CAUSED SIGNIFICANT INJURY. *TR