2008 BMW 535XI

WHILE DRIVING ON THE HIGHWAY AND LOCAL STREETS THE CAR SUDDENLY LOSES POWER AND CUTS OFF GIVING A FUEL PUMP MALFUNCTION. I HAD THE HIGH PRESSURE FUEL PUMP REPLACED AND THE PROBLEM STILL EXISTS. THIS HAS PUT MY WHOLE FAMILY IN DANGER BECAUSE IT HAS HAPPENED ON THE HIGHWAY AT SPEEDS IN EXCESS OF 50 MPH. THE CAR JUST SUDDENLY SHUT DOWN.

WEDNESDAY JULY 25TH, 2018, AS I WAS GETTING READY TO LEAVE WORK, I STARTED MY CAR WHICH WAS PARKED IN MY COMPANY'S UNDERGROUND GARAGE AND THE INTERIOR BECAME ENGULFED WITH SMOKE. I TURNED THE CAR OFF AND GOT OUT TO CHECK THE ENGINE. THERE WAS NO SMOKE COMING FROM THE UNDER THE HOOD OF THE CAR. I GOT BACK INTO THE CAR AND STARTED IT AGAIN AND MORE SMOKE ENTERED INTO THE CAR. I TURNED THE CAR OFF AND WENT BACK TO MY OFFICE TO CALL AAA. APPROXIMATELY 20-30 MINUTES LATER I WENT BACK TO THE CAR AND IMMEDIATELY SMELLED SMOKE IN THE GARAGE. AS I APPROACHED THE CAR IT WAS COMPLETELY FILLED WITH SMOKE BUT I COULD TELL THAT THE BOTH THE BACK AND FRONT WINDOW SHIELDS AND THE SUNROOF WERE SCORCHED. MY KEY FOB DID NOT WORK SO I HAD TO OPEN THE CAR WITH THE KEY. WITH THE DOOR OPEN THE THICK SMOKE ESCAPED AND THEN I WAS ABLE TO SEE THE DAMAGE TO THE CAR AS A RESULT OF A FIRE. I HAVE ATTACHED SOME PICTURES SO YOU CAN SEE. I DID SOME RESEARCH AND FOUND THAT THERE HAVE BEEN SOME INSTANCES WHERE THIS HAS HAPPENED TO OTHER BMW OWNERS IN THE PAST AND THAT THIS WAS A COURSE OF ACTION TO TAKE IN LETTING YOU KNOW.

THE WIRING HARNESSES IN THE TAILGATE HAVE BEEN BOTH SEVERED AND OTHERWISE DAMAGED BY THE NORMAL OPERATION OF THE TAILGATE AND LIFTGLASS. THE HINGES AND WIRING TRAYS HAVE SHARP EDGES AND THE WIRE INSULATION MATERIAL SEEMS TO BE OF A PVC MATERIAL. IT APPEARS THAT THIS MATERIAL IS VULNERABLE TO FAILURE WITH ONLY REGULAR OPERATION OF THE VEHICLE, HOWEVER, THE SHARP EDGES OF THE HARNESS TRAY IN THE TAILGATE HINGES ACT AS SHEARS THAT HAVE SEVERED THE WIRES. THIS PRESENTS SEVERAL SAFETY ISSUES INCLUDING THE POTENTIAL OF FIRES FROM ELECTRICAL SHORTS, MALFUNCTIONING AND DAMAGE OF CONTROL MODULES DUE TO ELECTRICAL SHORTS, INOPERABLE REAR-DEFOGGER SYSTEM, INOPERABLE KEYFOB REMOTES FOR ENTRY AND LOCKING, LOSS OF RADIO SYSTEM INCLUDING WEATHER BAND FOR SAFETY UPDATES, ETC. THIS APPEARS TO BE NOT ONLY A COMMON PROBLEM, BUT EVERY VEHICLE IN THIS DESIGNATION HAS EITHER SUFFERED FROM THESE PROBLEMS OR IS SUSCEPTIBLE. AS NOTED IN SEVERAL BLOGSITES WHERE OWNERS AND REPAIR SPECIALISTS HAVE COMMENTED, THIS IS AN OBVIOUS DESIGN DEFECT THAT SHOULD BE ADDRESSED BY BOTH NHTSA AND THE MANUFACTURER. CLEARLY A RECALL AND MANUFACTURER-PAID REPAIR SHOULD BE IMPLEMENTED.

AT C. 89,000 MILES - WARNING: "DRIVER SIDE AIR BAGS MALFUNCTION". BMW DEALER, ROCKVILLE, MD, WANTS $660 TO TELL ME IF IT'S A REAL PROBLEM WITH THE BAG, AND/OR ITS HOUSING AND/OR ONLY A FAULTY SENSOR SENDING AN INCORRECT MESSAGE (!!) FOLLOWING THAT SUSPICIOUS DRILL THEY CAN THEN FIX IT - A COUPLE HUNDRED DOLLARS IF IT'S ONLY A SENSOR, MUCH MORE $ IF IT'S SOMETHING ELSE. CAR MOVING OR NOT, THE WARNING REMAINS ON.

THE DRIVE SHAFT FOR MY BMW 535XI BROKE WHILE DRIVING STRAIGHT ON THE HIGHWAY WITHOUT ANY WARMING. THIS CAUSED CONSIDERABLE DAMAGE TO THE UNDERNEATH COMPONENTS OF THE CAR. SUCH AS RIPPING THE DATA CABLE AND BURST THE TRANSMISSION AND ALL THE TRANSMISSION FLUID LICKED OUT INSTANTLY. MY VEHICLE STALLED IN THE MIDDLE OF TRAFFIC WITH ON COMING CARS. I HAVE UPLOADED A PICTURE OF THE BROKEN DRIVE SHAFT WHILE THE CAR WAS BEING TOWED . I HAVE THE DOCUMENTS BUT I AM UNABLE TO UPLOAD THEM AT THIS TIME. IN ADDITION THE PRESSURE HOSE FOR THE POWER PUMP BURST AND IT IS UNFAIR THAT I HAVE TO REPLACE ALL 3 POWER HOSTS BECAUSE IT IS A BMW RECOMMENDATION.