2013 BMW 535I

My 2013 BMW 535i (VIN [XXX] ) caught fire spontaneously while parked, turned off, and unoccupied on 11/18/2025 in Westbury, NY. A passerby saw smoke and called 911. Nassau County Police and the Westbury Fire Department responded. Firefighters informed me at the scene that the fire was mechanical in origin. The vehicle was completely off and had been parked for about 20 minutes. I was not in or near the car. The fire originated under the hood. This matches known fire patterns in BMW 5-series models from this generation involving electrical/engine components, even though my VIN shows no open recalls. The previous owner did not register the car, so any recall notices may not have reached them. The vehicle is a total loss. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Heard a clicking noise behind the steering wheel for a few days then I’ll the sudden the horn stopped working and all the controls on the steering wheel stopped working. I’m a mechanic so I took apart the clock spring stealing wheel compartment to find all of the wire broken and very very brittle. Cause for concern due to airbag malfunction and is no longer connected properly!!!I’ve been hearing a clicking noise behind the steering wheel for a few days. Then, suddenly, the horn stopped working, and all the controls on the steering wheel stopped working as well. Since I’m a mechanic, I disassembled the clock spring and the steering wheel compartment to find that all the wires were broken and extremely brittle. This is concerning because it could cause an airbag malfunction, and the wires are no longer connected properly.

The contact owns a 2013 BMW 535I. The contact stated while driving at various speeds, the engine was overheating. Additionally, the contact noticed an abnormal burning odor while driving, with smoke coming from underneath the hood while at a complete stop. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 200,000.

Headlight Assembly has issues with the seal and condensation can/does enter the headlight assembly rendering the functionality of the headlight as suspect. Without proper lighting and condensation in front of the headlight which greatly impacts/effects the clarity and visibility of objects in the front of the car creating a safety issue. The cost to replace/repair these assemblies is excessive and is a widespread problem across multiple BMW models/years.

The contact owns a 2013 BMW 535I. The contact stated while driving approximately 40 MPH, an abnormal clicking sound was coming from the passenger’s side of the vehicle. Soon after hearing the noise, the vehicle stalled without warning. The vehicle was towed to the dealer where the passenger’s side CV joint was replaced out of pocket. Recently, the vehicle was taken back to the same dealer for routine maintenance and the contact was informed that the driver’s side CV joint was faulty and needed to be replaced. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 165,000.

The headlight housing on my model year is leaking water into it and causing electrical issues , Iv noticed majority of other models I see on the road have the same issue with one of the headlight housings having water in them, this has caused numerous codes to appear on the dash. “ Vertical headlight malfunction “ …”turn signal malfunction “ …”daytime running light malfunction “ ect… this is a safety issue because it stops my signal from working and my headlight works when it wants to. Normally I would think maybe I rock chipped the housing but since I see it on majority of 535’s I see I figure it must have been an issue from factory.