Fuel/propulsion System. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports2 fire reports0 injury reports

Exterior Lighting complaints

4 reports

Clear category filter

Mileage unknown · Feb 13, 2023

Exterior Lighting

Read full complaint

The headlights on the BMW 535 collect excessive amounts of condensation. If the condensation builds up, then the light does not function properly. The main safety concern is the malfunction of the turn signal. It will function in the rear of the vehicle but does not light up on the front in the affected headlight housing. Review of this problem on-line shows that this has occurred in many BMW vehicles and BMW also has issued a service bulletin for this problem (SI B63 05 16). As widespread as this problem is, I would think there would be a required recall for this service.

NHTSA ODI #11506957

Mileage unknown · Jul 9, 2022

Exterior Lighting

The front lights - water gets in impact visibility. The only repair is to replace the entire unit which is $2k per light. There is not other options. The adaptive warning sign does not go away due to this water.

NHTSA ODI #11473074

Mileage unknown · Sep 11, 2021

EngineExterior LightingFuel/propulsion System

While driving car stalled, dropped speed and engine warning light came on. Fuel pump was needed. Had to have car towed obtained a rental for 11 days. Fuel pump out of stock. Immediately after fuel pump was replaced less than two weeks the thermostat had to be replaced. Another tow and another rental. I need to be compensated…

Read full complaint

NHTSA ODI #11432548

109,000 miles · Feb 23, 2021

Exterior LightingVisibility/wiper

Read full complaint

THE HEADLIGHT GET CONDENSATION INSIDE WHICH REDUCES INTENSITY OF HEAD LIGHT. THIS CONDENSATION HAS NOW CORRUPTED THE ADAPTIVE HEADLIGHT CONTROL MODULE WHICH MADE THE TURN SIGNAL NOT WORK. THE DESIGN OF THE HEAD LIGHT MOUNTING MAKES FOR A VERY EXPENSIVE REPAIR AND/OR REPLACEMENT BY HAVE TO REMOVE BUMPER JUST TO GET TO HEADLIGHT. 1. CONDENSATION REDUCES INTENSITY OF HEADLIGHTS 2. MOISTURE CORRODED ADAPTIVE HEADLIGHT CONTROLLER MODULE THAT ALSO MADE TURN SIGNAL NOT WORK. 3. VERY COMPLICATED ACCESS TO HEADLIGHT TO REPAIR (VERY EXPENSIVE)

NHTSA ODI #11397518

Official recalls

16V746000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 17, 2016

BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.

Consequence & remedy

Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.