IllustrationThe drivers headlight has developed significant condensation on its interior caused by a failed seal which in turn damaged or short-circuited the modules disabling my daytime running light, low beam, high beam, and turn signal
2011 BMW 535I
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all 535I years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
325–50K
1950–75K
1575–100K
19100–150K
2150K+
65 reports with mileage · 47 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports6 fire reports5 injury reports
Exterior Lighting complaints
5 reportsDrivers side headlight has severe condensation and signal light headlights have malfunction.
Driver side headlight has an extreme condensation issue. Especially after it rains or using a car wash. The condensation leaks into the control light module , which makes the turn signal, parking lamp and the adaptive light to all fail.
LIGHTING SYSTEM MALFUNCTION APPEARED ON THE DASHBOARD DURING 1ST WEEK OF APRIL 2020. IT AFFECTED BATTERY CONSUMPTION, TURN INDICATORS, WINDOW CONTROLS, HEADLIGHT CONTROLS, LOCK/UNLOCK CONFIRMATION... THE DEALERSHIP SUGGESTED FAULTY FOOTWELL MODULE NEEDS REPLACEMENT, COST APPROX. $1323+TAX. A WARRANTY EXTENSION DOCUMENT FOUND ON …
Read full complaint
LIGHTING SYSTEM MALFUNCTION APPEARED ON THE DASHBOARD DURING 1ST WEEK OF APRIL 2020. IT AFFECTED BATTERY CONSUMPTION, TURN INDICATORS, WINDOW CONTROLS, HEADLIGHT CONTROLS, LOCK/UNLOCK CONFIRMATION... THE DEALERSHIP SUGGESTED FAULTY FOOTWELL MODULE NEEDS REPLACEMENT, COST APPROX. $1323+TAX. A WARRANTY EXTENSION DOCUMENT FOUND ON THE INTERNET FOR FOOTWELL MODULE LISTS ALL MODELS EXCEPT MINE. HTTPS://BIMMERSCAN.COM/WP-CONTENT/UPLOADS/2018/09/B012016-1.PDF
TL* THE CONTACT OWNS A 2011 BMW 535I. THE CONTACT STATED THAT THERE WAS AN EXTREME AMOUNT OF CONDENSATION IN THE DRIVER'S SIDE HEADLAMP. GRAYSON BMW (10671 PARKSIDE DR., KNOXVILLE, TN 37922, (865) 693-4555) DIAGNOSED THAT THE HEADLAMPS NEEDED TO BE REPLACED AT A COST OF $8,000. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS …
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW 535I. THE CONTACT STATED THAT THERE WAS AN EXTREME AMOUNT OF CONDENSATION IN THE DRIVER'S SIDE HEADLAMP. GRAYSON BMW (10671 PARKSIDE DR., KNOXVILLE, TN 37922, (865) 693-4555) DIAGNOSED THAT THE HEADLAMPS NEEDED TO BE REPLACED AT A COST OF $8,000. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
Official recalls
417V067000 · Power Train:driveline:constant Velocity Joint
Feb 2, 2017
BMW of North America, LLC (BMW) is recalling certain 2011-2012 135i Coupe, 1 Series M Coupe and 135i Convertible vehicles, 2011 Z4 sDrive 35i, 335i, 335d, 335i Coupe, 335is Coupe, 335i Convertible, 335is Convertible, 535i, 535i xDrive, 535i Gran Turismo and 550i xDrive Gran Turismo vehicles and 2012 740i and 740Li vehicles. The rear driveshaft constant velocity (CV) joint on the affected vehicles may fatigue and break.
Consequence & remedy
Consequence: If the CV joint breaks, the vehicle may have a loss of propulsion, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the rear driveshaft CV joint and, based on its production date, will replace it, free of charge. The recall began April 21, 2017. Owners may contact BMW customer service at 1-800-525-7417.
16V832000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Nov 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2011 BMW 528i, 528xi, 535i, 535xi, 550i and 550xi vehicles manufactured March 1, 2010, through August 31, 2011. The affected vehicles may have received a replacement Sensor Cluster Unit (SCU) during a service visit. These SCUs have an acceleration sensor that may have been incorrectly programmed and, as a result, the SCU may not accurately determine if activation and deployment of the air bags, safety belt pre-tensioners and head restraints is necessary in the event of a crash.
Consequence & remedy
Consequence: Depending on the severity of the crash, inadequate activation of the driver and/or passenger air bags, safety belt pre-tensioners and active head restraints may increase the risk of injury.
Remedy: BMW will notify owners, and dealers will replace the SCU, free of charge. The recall began on December 16, 2016. Owners may contact BMW customer service at 1-800-525-7417.
16V746000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Consequence & remedy
Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
14V176000 · Engine And Engine Cooling:engine
Apr 10, 2014
BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.
Consequence & remedy
Consequence: If the bolts loosen or break the engine may have reduced power or stall. An engine stall increases the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty to address this condition. The recall began on September 24, 2014. Owners may contact BMW at 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.