2007 BMW 530I

The contact owns a 2007 BMW 530I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The contact stated that while driving at approximately 65 MPH, there was smoke coming from the hood. The "transmission overheating" message was displayed. The vehicle was inoperable. The vehicle was towed to an independent mechanic, where it was diagnosed that the PCV valve and transmission needed to be replaced. The vehicle remained with the independent mechanic awaiting the repair. The manufacturer was made aware of the failure. The approximate failure mileage was 170,000. The VIN was not available.

The contact owns a 2007 BMW 530I. The contact stated while driving at various speeds, there was an abnormal burning odor coming from the A/C vents. The contact also noticed the burning odor whenever opening the hood. The message "Service Engine Soon" was displayed. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). However, the parts to do the recall repair were not yet available. The local dealer was not contacted. The contact stated while driving 65-70 MPH, he noticed smoke coming out from underneath the hood of the vehicle. The contact veered to the side of the road for a moment and then opened the hood. The contact was able to continue driving. The contact stated that the failure had reoccurred on two different occasions. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 175,000. VIN tool confirms parts not available.

CAR OVERHEATING. TOOK VEHICLE TO SHOP AND RADIATOR WAS REPLACED IMMEDIATELY. SAME THING HAPPENED AGAIN THE DAY AFTER, CAR OVERHEATING AND GETTING MESSAGE THAT ENGINE MUST BE TURNED OFF IMMEDIATELY. CAR AT SHOP AGAIN AND ISSUE IS BEING INVESTIGATED. ASSUMPTION THAT IT HAS A DEFECTIVE WATER PUMP. CONTACTED BMW AND THEY STATE THAT THEY ARE AWARE OF SOME WATER PUMP ISSUES FOR MODELS 2008-2011 BUT THEY HAVE NOT IDENTIFIED ALL MODELS OR VINS AFFECTED. MY VEHICLE IS A 2007. BMW REFERRED ME TO NHTSA TO FILE COMPLAINT AND REQUEST INVESTIGATION. BMW STATES THAT IT IS A POSSIBILITY. REPAIR IS EXTREMELY EXPENSIVE, MY CAR IS NOT DRIVABLE AND I DO NOT HAVE ANOTHER VEHICLE TO DRIVE. I AM REQUESTING YOUR ASSISTANCE. THANK YOU. ## VIN PASSED ## BMW, 2007 530I ## *KB

I WAS WARNED BY THE COMPUTER SYSTEM OF ENGINE OVER HEATING, AND WHILE DRIVING ON FREEWAY, THE ENGINE AUTOMATICALLY SLOWED DOWN THE SPEED, WHICH CAUSED ME PULL OF THE FREEWAY IN A HURRY, SO I WOULDN'T CAUSE ANY ACCIDENT FOR SLOW TRAFFIC. AT THE MECHANIC'S SHOP, I WAS FIRST INFORMED THAT THERMOSTAT WAS DEFECTIVE, BUT LATER THEY DISCOVERED THE WATER PUMP HAS FAILED. THE REASON FOR THE WATER PUMP FAILURE WAS BECAUSE THE ELECTRONIC CONTROL WITHIN THE WATER PUMP HOUSING APPEARED TO BE BURNED OUT. I WAS ABLE TO SEE THE BURNED CHARRED MARK ON THE INTERIOR WALL OF THE HOUSING, WHICH IS LAMINATED WITH PLASTIC. THE WATER PUMP IS IN CLOSE PROXIMITY OF THE ENGINE. THIS FAILURE HAPPENS AT ABOUT 10,000 MILES AFTER THE EXPIRATION OF 50,000 MILES WARRANTY. I BELIEVE THE DESIGN OF THE WATER PUMP AND THE LOCATION OF THE WATER PUMP HAS INHERENT PROBLEM FOR EVENTUAL BREAKAGE. BMW SHOULD REDESIGN THIS PART. *TR

2007 BMW 530 EVAPORATIVE COOLER LEAK IN DASHBOARD, CAUSING FREON IN PASSENGER CABINET. IN ADDITION TO LEAKY FREON IN THE AIR. VERY COMMON PROBLEM ACCORDING TO DEALER IN TUCSON, AZ FOR BMW THEY REPLACE THEM ALL THE TIME EVEN ON COUPLE YEAR OLD CARS, USUALLY THEY CHARGE CUSTOMER FOR IT. ALL THE FREON LEAKING IN COMPARTMENT CAN'T BE GOOD FOR US. *TR