2006 BMW 530I

WHEN I STARTED MY CAR THE IDRIVE DISPLAYED THE "INCREASED BATTERY DISCHARGE" MESSAGE. I THEN SMELLED A STRONG ODOR OF SMOKE AND MELTED PLASTIC, AND THE IDRIVE STOPPED WORKING ALTOGETHER. I COULDN'T FIGURE OUT THE PROBLEM UNTIL I SEARCHED THIS WEBSITE AND SEVERAL BMW DEVOTED MESSAGE BOARDS TO DISCOVER THAT THE PROBLEM COULD BE TRACED TO A DEFECTIVE DESIGN RELATED TO THE MICRO PROCESSOR MODULE THAT CONTROLS THE IDRIVE. APPARENTLY, BMW THOUGHT IT WAS A GOOD IDEA TO INSTALL THE MPM, AN IMPORTANT AND SENSITIVE ELECTRICAL COMPONENT, IN THE SPARE TIRE WHEEL-WELL WHERE LIQUID CAN GATHER EASILY. A SMALL AMOUNT OF WATER SPILLED IN MY TRUNK, AND THE MPM BURNED AND MELTED ALONG WITH THE ATTACHED WIRING HARNESS. OBVIOUSLY, THIS IS A SERIOUS AND DANGEROUS DESIGN DEFECT. AND MINE IS NOT THE FIRST INSTANCE OF THIS HAPPENING - WHY HASN'T A RECALL BEEN REQUIRED? IT ALSO SEEMS THAT BMW ISSUED AT LEAST ONE SERVICE BULLETIN REGARDING THIS ISSUE, AND DIRECTED ITS DEALERS TO RELOCATE THE MPM TO A SAFER LOCATION. MY VEHICLE HAS BEEN TO THE DEALER SEVERAL TIMES SINCE THE BULLETIN WAS ISSUED - AT LEAST TWICE FOR PROBLEMS WITH THE ELECTRICAL SYSTEM - BUT THE DEALER NEVER MENTIONED THE BULLETIN OR SUGGESTED THAT THEY SHOULD RELOCATE IT. *TR

AS I WAS DRIVING A WARNING CAME ON MY IDRIVE DISPLAY THAT THERE WAS A PARKING LIGHT MALFUNCTION. I LATER REMOVED THE HEADLIGHT TO REPLACE A BULB AND UPON DOING SO I NOTICED BARE COPPER WIRES. I THEN REMOVED THE MAIN COVER AND SAW THAT LITERALLY EVERY WIRE HAD PORTIONS OF THE OUTER WIRE JACKET DETERIORATING. WHEN I REMOVED THE PARKING LAMP ASSY. TO REPLACE THE BULB, THE WIRE JACKET JUST FLAKED OFF. DUE TO THE SEVERITY OF THE DAMAGE I IMMEDIATELY TOOK THE HEADLIGHT TO LAUDERDALE BMW. LAUDERDALE BMW HAD A SPECIALIST LOOK AT THE HEADLIGHT. THE SPECIALIST SAID THAT THOUGH IT DID LOOK VERY BAD UNFORTUNATELY IT WAS JUST DUE TO THE FLORIDA SUN! THERE IS NO SUPPORT FOR THE HEADLIGHT EITHER FROM HELLA NORTH AMERICA (THE ACTUAL MANUFACTURER OF THE HEADLIGHT) OR FROM BMW. NO PARTS CAN BE ORDERED FOR IT. THE ONLY OPTION AVAILABLE IS TO PURCHASE A COMPLETE NEW HEADLIGHT ASSY. AT $1500.00 I WROTE TO HELLA NORTH AMERICA AND THEY REFERRED ME TO BMW GERMANY. I WROTE TO BMWNA AND THEY RESPONDED THAT IT WAS JUST NORMAL WEAR AND TEAR. IMAGINE THAT, AN 8 YEAR OLD HEADLIGHT DETERIORATE TO BARE WIRES IS BY BMW'S CONCERN, NORMAL WEAR AND TEAR! THAT'S SHAMEFUL! AT THIS POINT I CANNOT INSTALL THE HEADLIGHT ASSEMBLY BACK INTO THE CAR FOR FEAR OF A DEAD SHORT AND POSSIBLE FIRE! I HAVE A 1995 CHEVROLET S-10 THAT AT 19 YEARS HAS NO WIRING ISSUES AND DEFINITELY NO BARE WIRES! FOR BMW THOUGH IT IS CONSIDERED COMPLETELY ACCEPTABLE AFTER 8 YEARS! YET BOTH VEHICLES SIT SIDE BY SIDE IN THE FLORIDA SUN EVERYDAY! IS IT RIGHT THAT BMW VEHICLE PRICING ON THE AVERAGE IS SO MUCH HIGHER THAN CHEVROLET AND YET BMW'S BUILD QUALITY AND WHAT IS ACCEPTABLE IS SO MUCH LOWER! WHEN THIS HAPPENS, SOMETHING IS TERRIBLY WRONG! *TR

WE HAVE A 2006 BMW 530I IN JANUARY OF 2013 WE HAD A IGNITION COIL GO OUT WITH AROUND 75000 MILES WHICH WAS ABOUT A 275.00$ TO GET FIXED. THEN ON 6/26/13 WE HAD 2 MORE IGNITION COILS GO OUT AT 78000 MILES, THAT TIME IT WAS 507.00 $ TO FIX, THIS MUST BE A FAULTY PART BECAUSE NOW 12/16/13 WITH 82000 MILES IT HAS HAPPENED AGAIN! I AM GOING TO PAY FOR THE REMAINING 3 TO BE CHANGED. WHEN I CALLED BMW THERE WAS A RECALL APPARENTLY FROM 2002-2004 FOR THIS. BY WAY OF MY VIN.# I FOUND OUT MY CAR WAS MADE 9/2005 I FEEL THIS PROBLEM NEVER GOT FIXED OR SIMPLY JUST CHANGING THE BRAND OF THE COIL WAS NOT THE ANSWER TO THE PROBLEM! BECAUSE ITS NOT FIXED. I HAVE NEVER OWNED A CAR WITH ISSUES LIKE THIS. WHEN I SPOKE TO A INDEPENDENT CERTIFIED BMW MECHANIC I WAS TOLD IT HAS BEEN A PROBLEM! *TR

REF NHTSA CAMPAIGN NUMBER: 08V384000 WHILE MY VEHICLE IS THE SAME MODEL YEAR, MODEL AND SPECIFICATION LISTED IN THE RECALL, MY VEHICLE'S VIN IS NOT "INCLUDED" IN THE LIST OF RECALLED VEHICLES. I HAVE AND AM CURRENTLY EXPERIENCING THIS EXACT SEAT SENSOR MAT PROBLEM. BMW IS UNWILLING TO COVER ANY WARRANTY WORK AS THE SPECIFIC VIN IS APPARENTLY NOT AFFECTED DESPITE THE FACT THAT CLEARLY IT IS. I AM CONCERNED ABOUT THE SAFETY OF THE OCCUPANTS OF MY VEHICLE BASED ON THE UNRELIABILITY OF THIS COMPONENT AND FEEL THE RECALL SHOULD BE EXPANDED TO INCLUDE ALL VEHICLES THAT EXPERIENCE THE SAME PROBLEM. *TR

HAVE A PROBLEM WITH THE RIGHT HEADLIGHT IN MY 530I 2006 BMW. THE ANGEL LIGHT BULB BURNED OUT AND WHEN I WENT TO REPLACE IT, THE WIRE COVERS STARTED TO COME OFF EXPOSING THE WIRES COMPLETELY. AFTER REPLACING THE BULB (WHICH WAS A BIT DIFFICULT TO DO), MOST OF THE WIRES IN THE HEADLIGHT HAD NO PROTECTION AND WERE COMPLETELY EXPOSED. I HAD TO COVER THEM WITH ELECTRIC TAPE TO PREVENT SOME SHORTS, BUT MISSED A SECTION I GUESS, SINCE NOW THE COMPUTER IS GIVING ME A ADAPTIVE HEADLIGHT WARNING MESSAGE AND THE LIGHT IS NOT POINTING TO THE PROPER DIRECTION. I HAVE DONE SOME RESEARCH ON LINE AND FOUND THAT IT IS HAPPENING TO A LOT OF PEOPLE. CONTACTED BMW OF NORTH AMERICA, AND THEY SAID SINCE MY CAR IS OUT OF WARRANTY, THEY CANNOT DO ANYTHING ABOUT IT. THE MATERIAL USED TO COVER THESE WIRES IS NOT CORRECT, AS IT WILL BREAK OFF JUST BY LIGHTLY TOUCHING THEM. I FEEL THIS IS A SAFETY CONCERN WHERE THERE MAY BE SHORT CIRCUITS WHILE THE CAR IS RUNNING AND IT WOULD AFFECTS THE CAR'S COMPUTERS. IN MY CASE, THE LIGHT CONTROL MODULE IS ALSO SHORTED AND MUST BE REPLACED. I WOULD LIKE TO KNOW IF THERE IS ANYTHING YOU CAN DO TO FIND OUT IF THIS IS A SAFETY CONCERN OR NOT. I BELIEVE IT IS SPECIALLY ON A CAR STILL NEW. LET ME KNOW IF YOU WOULD NEED ANY FURTHER INFORMATION. THANK YOU. *JB