NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
58 reports95,000 miles · Jun 25, 2013
Air Bags
TL* THE CONTACT OWNS A 2005 BMW 530I. THE CONTACT STATED THAT THE AIR BAG LIGHT DID NOT ILLUMINATE ON THE INSTRUMENT PANEL TO INDICATED THAT THE AIR BAG WAS ACTIVATED. THE CONTACT STATED THE FAILURE WAS IDENTICAL TO NHTSA RECALL CAMPAIGN ID NUMBER: 08V384 (AIR BAGS), BUT THE MANUFACTURER CONFIRMED THAT THE VEHICLE WAS NOT INCLUD…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 530I. THE CONTACT STATED THAT THE AIR BAG LIGHT DID NOT ILLUMINATE ON THE INSTRUMENT PANEL TO INDICATED THAT THE AIR BAG WAS ACTIVATED. THE CONTACT STATED THE FAILURE WAS IDENTICAL TO NHTSA RECALL CAMPAIGN ID NUMBER: 08V384 (AIR BAGS), BUT THE MANUFACTURER CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED. THE VEHICLE WAS NOT BEEN INSPECTED. THE FAILURE MILEAGE WAS 95,000. THE CURRENT MILEAGE WAS 97,600. *TR
NHTSA ODI #10521623
97,000 miles · Apr 2, 2013
Power Train
I WAS DRIVING ALONG THE HIGHWAY AT APPROXIMATELY 55 MPH IN MYCERTIFIED PRE OWNED 2005 BMW 530I THAT I HAVE OWNED FOR 3 AND A HALF YEARS WHEN ALL OF A SUDDEN I GOT A MESSAGE IN THE IDRIVE THAT READ :TRANSMISSION FAILSAFE, DRIVE MODERATELY". I THEN PROCEEDED TO DRIVE HOME APPROXIMATELY 15 MILES. AFTER A COUPLE OF DAY I HAD MY VEHI…
Read full complaint
I WAS DRIVING ALONG THE HIGHWAY AT APPROXIMATELY 55 MPH IN MYCERTIFIED PRE OWNED 2005 BMW 530I THAT I HAVE OWNED FOR 3 AND A HALF YEARS WHEN ALL OF A SUDDEN I GOT A MESSAGE IN THE IDRIVE THAT READ :TRANSMISSION FAILSAFE, DRIVE MODERATELY". I THEN PROCEEDED TO DRIVE HOME APPROXIMATELY 15 MILES. AFTER A COUPLE OF DAY I HAD MY VEHICLE TOWED TO THE NEAREST BWM SERVICE CENTER WHERE I WAS INFORMED THAT THE TRASMISSION WOULD NEED TO BE REPLACED. THE VEHICLE HAD 46K MILES ON IT WHEN I PURCHASED IT SO THAT MEANS THAT I HAVE ONLY DRIVEN 50K WHEN THE TRANSMISSION FAILED. I JUST FIND IT DISCERNING THAT A VEHICLE WITH SUCH LOW MILEAGE IS IN NEED OF A TRANSMISSION. I HAVE KEPT UP THE MAINTENANCE ON MY VEHICLE AND AS I MENTION ABOVED I PURCHASE A PRE- CERTIFIED VEHICLE AND I HAVE NEVER HAS A VEHICLE TO NEED A TRANSMISSION THIS SOON. AFTER CHECKING THE INTERNET IT CONCERNS ME THAT ALOT OF OTHER PEOPLE HAVE HAD THE SAME ISSUE AND THAT BMW HAS NO ADDRESS IT. *TR
NHTSA ODI #10505434
74,500 miles · Mar 25, 2013
Power Train
COMING ONTO HIGHWAY PUSHED GAS PEDAL TO ACCELERATE, THE CAR ATTEMPTED TO DOWNSHIFT BUT LOST POWER WITH A LARGE WARNING DIAGNOSTIC ON CONTROL PANEL -- TRANSMISSION ERROR INDICATING THAT CAR WOULD NOW OPERATE IN A DIMINISHED STATE. LUCKILY MANAGED TO PULL OFF TO THE SIDE WITHOUT CAUSING ACCIDENT. THIS IS A HAZARDOUS SITUATION THE …
Read full complaint
COMING ONTO HIGHWAY PUSHED GAS PEDAL TO ACCELERATE, THE CAR ATTEMPTED TO DOWNSHIFT BUT LOST POWER WITH A LARGE WARNING DIAGNOSTIC ON CONTROL PANEL -- TRANSMISSION ERROR INDICATING THAT CAR WOULD NOW OPERATE IN A DIMINISHED STATE. LUCKILY MANAGED TO PULL OFF TO THE SIDE WITHOUT CAUSING ACCIDENT. THIS IS A HAZARDOUS SITUATION THE LOSS OF POWER COULD EASILY HAVE HAD MORE DISASTROUS CONSEQUENCES. *TR
NHTSA ODI #10504450
90,000 miles · Mar 11, 2013
Air BagsEquipment Adaptive/mobility
THERE IS A RECALL FOR THIS YEAR BMW. FOR THE SEAT MAT THAT ACTIVATES THE AIRBAG, BUT MY DEALERSHIP TELLS ME THAT OUR CAR DOES NOT QUALIFY . I AM ALSO HAVING THE SAME PROBLEM WITH AIRBAG AND THE SEAT MAT NOT FUNCTIONING. WHY DOES THIS RECALL NOT COVER MY CAR. *TR
NHTSA ODI #10502403
82,000 miles · Dec 3, 2012
Structure
I WAS DRIVING ABOUT 35 MILES AN HOUR ON A BUMPY ROAD(NORTH RT 18, NJ), THEN SUDDENLY A FRONT PASSENGER DOOR POPPED OPEN DURING DRIVING. WHEN I MEAN BY POPPED OPEN, IT GOES FROM DOOR FULLY CLOSED & LOCKED TO PARTIALLY OPEN, AS IF THE DOOR WASN'T COMPLETELY SHUT. WHEN IT HAPPENED, THE "DOOR OPEN" SIGNAL CAME UP IMMEDIATELY A…
Read full complaint
I WAS DRIVING ABOUT 35 MILES AN HOUR ON A BUMPY ROAD(NORTH RT 18, NJ), THEN SUDDENLY A FRONT PASSENGER DOOR POPPED OPEN DURING DRIVING. WHEN I MEAN BY POPPED OPEN, IT GOES FROM DOOR FULLY CLOSED & LOCKED TO PARTIALLY OPEN, AS IF THE DOOR WASN'T COMPLETELY SHUT. WHEN IT HAPPENED, THE "DOOR OPEN" SIGNAL CAME UP IMMEDIATELY AND THE INTERIOR LIGHTS CAME UP. I TOLD A LOCAL BMW DEALERSHIP, WAS TOLD THE DOOR ACTUATOR IS BAD, AND I SHOULD PAY FOR THE COST OF $500.00, WHICH SEEMED UNFAIR WHEN IT LOOKS LIKE A SYSTEM MALFUNCTION. I HAD NOT HAD A PROBLEM UNTIL NOW. *TR
NHTSA ODI #10487243
110,000 miles · Nov 1, 2012
Air BagsElectrical SystemSeat Belts
MUCH LIKE THE OTHER COMPLAINTS, I JUST COPIED AND PASTED THIS FROM ANOTHER COMPLAINANT. THE PASSENGER RESTRAINT SYSTEM MALFUNCTION ALARM CAME ON THE IDRIVE. THE DEALER SAYS THAT THE VEHICLE IS NOT COVERED UNDER RECALL. HOWEVER, THE RECALL ID #73368 EXACTLY MATCHES THE DESCRIPTION OF MY PROBLEM. THEREFORE, WE BELIEVE THAT OUR VE…
Read full complaint
MUCH LIKE THE OTHER COMPLAINTS, I JUST COPIED AND PASTED THIS FROM ANOTHER COMPLAINANT. THE PASSENGER RESTRAINT SYSTEM MALFUNCTION ALARM CAME ON THE IDRIVE. THE DEALER SAYS THAT THE VEHICLE IS NOT COVERED UNDER RECALL. HOWEVER, THE RECALL ID #73368 EXACTLY MATCHES THE DESCRIPTION OF MY PROBLEM. THEREFORE, WE BELIEVE THAT OUR VEHICLE SHOULD BE COVERED. PLEASE ADVISE HOW TO GET THIS RESOLVED AS SOON AS POSSIBLE SO THAT I CAN GET THE CAR FIXED. WE ARE CONCERNED BECAUSE IT'S A SERIOUS SAFETY ISSUE WHEN THE FRONT AIR BAGS WILL NOT COME ON IN CASE OF AN ACCIDENT. I WENT AS FAR AS TO SPEAK WITH BMW DIRECTLY AND THEY SAID IT ONLY GOES TO THE 2004 MODELS, AND THEN TO THE 2006 MODELS....YEA, WHATEVER. IT'S A SAFETY RECALL, THEY SHOULD HONOR IT, AND BMW IS COMPLETELY INFLEXIBLE WHEN IT COMES TO THEIR CUSTOMERS. IT'S A SHAME NOT ONLY WILL THEY NOT HELP, THEY WANT TO CHARGE OVER $1000 TO THE CUSTOMER FOR A RECALL PART. I'M TRADING MY OTHER BMW IN ON ANYTHING BUT ANOTHER BMW AND WILL DRIVE MY AFFECTED 530I UNTIL IT REACHES THE SCRAP YARD. *TR
NHTSA ODI #10482908
57,900 miles · Sep 11, 2012
Air Bags
THE PASSENGER RESTRAINT SYSTEM MALFUNCTION ALARM CAME ON THE IDRIVE. THE DEALER SAYS THAT THE VEHICLE IS NOT COVERED UNDER RECALL. HOWEVER, THE RECALL ID #73368 EXACTLY MATCHES THE DESCRIPTION OF MY PROBLEM. THEREFORE, WE BELIEVE THAT OUR VEHICLE SHOULD BE COVERED. PLEASE ADVISE HOW TO GET THIS RESOLVED AS SOON AS POSSIBLE SO…
Read full complaint
THE PASSENGER RESTRAINT SYSTEM MALFUNCTION ALARM CAME ON THE IDRIVE. THE DEALER SAYS THAT THE VEHICLE IS NOT COVERED UNDER RECALL. HOWEVER, THE RECALL ID #73368 EXACTLY MATCHES THE DESCRIPTION OF MY PROBLEM. THEREFORE, WE BELIEVE THAT OUR VEHICLE SHOULD BE COVERED. PLEASE ADVISE HOW TO GET THIS RESOLVED AS SOON AS POSSIBLE SO THAT I CAN GET THE CAR FIXED. WE ARE CONCERNED BECAUSE IT'S A SERIOUS SAFETY ISSUE WHEN THE FRONT AIR BAGS WILL NOT COME ON IN CASE OF AN ACCIDENT. *TR
NHTSA ODI #10475106
40,000 miles · Sep 5, 2012
Air Bags
THANKS TO YOUR ORGANIZATION, BMW USA AGREED TO EXTEND THE WARRANTY FOR THE BMW PASSENGER SEAT OCCUPANCY SENSOR MAT AIRBAG TO 10 YEARS. HOWEVER, BMW USA IS NOT HONORING THIS COMMITMENT FOR MY VEHICLE, A 2005 BMW 530I. IS THERE ANY WAY TO ASK BMW USA TO HONOR THIS COMMITMENT? THIS PART OF MY VEHICLE IS AFFECTED BY THIS PROBLEM, IN…
Read full complaint
THANKS TO YOUR ORGANIZATION, BMW USA AGREED TO EXTEND THE WARRANTY FOR THE BMW PASSENGER SEAT OCCUPANCY SENSOR MAT AIRBAG TO 10 YEARS. HOWEVER, BMW USA IS NOT HONORING THIS COMMITMENT FOR MY VEHICLE, A 2005 BMW 530I. IS THERE ANY WAY TO ASK BMW USA TO HONOR THIS COMMITMENT? THIS PART OF MY VEHICLE IS AFFECTED BY THIS PROBLEM, IN THE MANNER DESCRIBED BY THE RECALL, FOR THE REASONS DESCRIBED IN THE RECALL, AND IT IS ONE OF THE VEHICLES COVERED BY THIS RECALL--BASED ON MODEL AND YEAR INFORMATION PUBLISHED. *TR
NHTSA ODI #10473882
40,000 miles · Jun 14, 2012
Air Bags
TL* THE CONTACT OWNS A 2005 BMW 530I. THE CONTACT NOTICED THE AIR BAG WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 08V384000 (AIR BAGS:FRONTAL) BUT THE CONTACT WAS ADVISED BY THE DEALER THAT THE VIN WAS NOT INCLUD…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 530I. THE CONTACT NOTICED THE AIR BAG WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 08V384000 (AIR BAGS:FRONTAL) BUT THE CONTACT WAS ADVISED BY THE DEALER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
NHTSA ODI #10461743
100,400 miles · Apr 10, 2012
Air Bags
MY CAR IS SAYING THAT THE PASSENGER RESTRAINT SYSTEM HAS A FAULT AND THE SEAT BELT OR AIR BAGS MAY BE DAMAGED FOR NO ABSOLUTE REASON. *TR
NHTSA ODI #10454763
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Illustration