NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
37 reportsClear category filter75,000 miles · Apr 1, 2015
Air BagsSeat Belts
WHILE BMW HAS RECALLED MANY 2005 BMW 530I SEDANS FOR THE AIRBAG CONCERNS, MY VIN IS APPARENTLY NOT INCLUDED IN THIS LIST. I HAVE CONTACTED BMW DIRECTLY, AS WELL AS MANY LOCAL SERVICE DEPARTMENTS, WITH NO AVAIL. BOTH LIGHTS INDICATING SEAT BELT AND AIRBAG MALFUNCTIONS HAVE BEEN ILLUMINATED FOR OVER A YEAR AND I AM VERY CONCERNED …
Read full complaint
WHILE BMW HAS RECALLED MANY 2005 BMW 530I SEDANS FOR THE AIRBAG CONCERNS, MY VIN IS APPARENTLY NOT INCLUDED IN THIS LIST. I HAVE CONTACTED BMW DIRECTLY, AS WELL AS MANY LOCAL SERVICE DEPARTMENTS, WITH NO AVAIL. BOTH LIGHTS INDICATING SEAT BELT AND AIRBAG MALFUNCTIONS HAVE BEEN ILLUMINATED FOR OVER A YEAR AND I AM VERY CONCERNED THAT IF A CRASH WERE TO OCCUR, THE PASSENGERS IN THE VEHICLE WOULD NOT BE ADEQUATELY PROTECTED. IF THERE ARE AIR BAG ISSUES IN SOME BMW 530I SEDANS, ISN'T IT POSSIBLE THAT OTHERS MAY HAVE THE SAME ISSUE? *TR
NHTSA ODI #10703156
102,000 miles · Feb 24, 2015
Air BagsSeat BeltsService BrakesCrashInjury
I PURCHASED MY VEHICLE FROM A DEALER ON APRIL 2014. APPROXIMATELY A MONTH LATER, THE PASSENGER FRONTAL AIRBAG AUTOMATICALLY DISABLED AND THE LIGHT ILLUMINATED ON THE DASHBOARD. THE FRONTAL PASSENGER SEATBELT ALSO DISABLED AND THE LIGHT ILLUMINATED ON THE DASHBOARD. THE BRAKE LIGHT IS ALSO ILLUMINATED. IN JUNE 2014, MY CAR WAS HI…
Read full complaint
I PURCHASED MY VEHICLE FROM A DEALER ON APRIL 2014. APPROXIMATELY A MONTH LATER, THE PASSENGER FRONTAL AIRBAG AUTOMATICALLY DISABLED AND THE LIGHT ILLUMINATED ON THE DASHBOARD. THE FRONTAL PASSENGER SEATBELT ALSO DISABLED AND THE LIGHT ILLUMINATED ON THE DASHBOARD. THE BRAKE LIGHT IS ALSO ILLUMINATED. IN JUNE 2014, MY CAR WAS HIT BY A F150 TRUCK. THE IMPACT WAS SO FORCEFUL, MY CAR WAS KNOCKED ON THE OTHER SIDE OF THE STREET. NON OF THE AIRBAGS DEPLOYED AND THERE WERE INJURIES TO THE DRIVER. MY VEHICLE WAS REPAIRED AND I WAS INFORMED BY THE MECHANIC THAT THE LIGHTS ILLUMINATED ON MY DASHBOARD WERE RECALLS AND A KNOWN SAFETY ISSUE WITH MY VEHICLE'S MAKE AND MODEL. I RESEARCHED THE INFORMATION AND DID FIND RECALLS FOR THE FRONTAL AIRBAG AND FRONTAL SEATBELT. I CONTACTED A BMW DEALERSHIP A COUPLE OF TIMES AND I AM TOLD MY VIN DOES NOT SHOW ANY OPEN RECALLS AND THE REPAIRS WILL BE OUT OF POCKET. THESE PROBLEMS APPEARS TO BE DEFECTS WITH THE VEHICLE AND A DEFINITE SAFETY ISSUE. *JS
NHTSA ODI #10690322
Mileage unknown · Oct 11, 2014
Air Bags
PASSENGER SIDE AIR BAG FAILURE MESSAGE. *TR
NHTSA ODI #10644100
50,000 miles · Jun 12, 2014
Air Bags
TL* THE CONTACT OWNS A 2005 BMW 530I. THE CONTACT STATED THAT THE FRONT PASSENGER SEAT AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE PASSENGER SEAT AIR BAG SENSOR MAT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFE…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 530I. THE CONTACT STATED THAT THE FRONT PASSENGER SEAT AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE PASSENGER SEAT AIR BAG SENSOR MAT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 08V384000 (FRONT PASSENGER SEAT OCCUPANT DETECTION MAT). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 71,000. UPDATED 8/27/14*CN UPDATED 09/8/2014 *JS
NHTSA ODI #10597875
51,051 miles · Jun 12, 2014
Air BagsElectrical System
FRONT PASSENGER SEAT OCCUPANT MAT IS MALFUNCTIONING IN MY 2005 BMW 530I. THERE WAS A RECALL IN ACTION NUMBER EA08001 IN WHICH BMW AGREED TO EXTEND THE WARRANTY OR COMPLETE THE REPAIR OF THE PROBLEM. WHEN I WENT TO THE BMW SERVICE FACILITY, THEY WOULD ONLY FIX THE ISSUE IF I PAID. I CALLED BMW USA AND THEY TOLD ME THAT MY SPECIFI…
Read full complaint
FRONT PASSENGER SEAT OCCUPANT MAT IS MALFUNCTIONING IN MY 2005 BMW 530I. THERE WAS A RECALL IN ACTION NUMBER EA08001 IN WHICH BMW AGREED TO EXTEND THE WARRANTY OR COMPLETE THE REPAIR OF THE PROBLEM. WHEN I WENT TO THE BMW SERVICE FACILITY, THEY WOULD ONLY FIX THE ISSUE IF I PAID. I CALLED BMW USA AND THEY TOLD ME THAT MY SPECIFIC VIN NUMBER IS NOT INCLUDED IN THE REPAIR/EXTENDED WARRANTY. EVEN THOUGH MY VEHICLE IS EXPERIENCING THE PROBLEM, THEY TELL ME MY VIN IS NOT INCLUDED. THEREFORE, MY PASSENGER SEAT AIRBAGS DO NOT WORK. I REPORTED THIS PROBLEM ORIGINALLY IN 2012 TO BMW. *TR
NHTSA ODI #10597872
145,000 miles · Jun 9, 2014
Air BagsService Brakes, HydraulicCrashInjury
TL* THE CONTACT OWNS A 2005 BMW 530I. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT HEARD A LOUD NOISE NEAR THE FRONT DRIVER'S SIDE WHEEL. THE DEALER COULD NOT DUPLICATE THE FAILURE AND DID NOT STATE IF THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 10V446000 (SERVICE BRAKES, HYDRAULIC). THE CONTACT WAS UNABLE TO STOP…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 530I. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT HEARD A LOUD NOISE NEAR THE FRONT DRIVER'S SIDE WHEEL. THE DEALER COULD NOT DUPLICATE THE FAILURE AND DID NOT STATE IF THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 10V446000 (SERVICE BRAKES, HYDRAULIC). THE CONTACT WAS UNABLE TO STOP THE VEHICLE IN TIME WHEN ANOTHER VEHICLE SUDDENLY MANEUVERED IN HER LANE, WHICH LED TO THE CONTACT CRASHING INTO THE REAR OF THE SECOND VEHICLE. AS A RESULT, THE CONTACT SUSTAINED BURNS TO THE SKIN DUE TO THE CONTENTS THAT WERE RELEASED UPON AIR BAG DEPLOYMENT. TWO PASSENGERS WERE ALSO INJURED. A POLICE REPORT WAS FILED AND MEDICAL ATTENTION WAS RECEIVED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.
NHTSA ODI #10597054
106,240 miles · Mar 8, 2014
Air Bags
I'VE GOT AN ALERT ON THE DASHBOARD (PASSENGER RESTRAIN SYSTEM MALFUNCTION). I'VE HEARD THAT IS A RECALL FOR THIS MALFUNCTIONS. I WANT TO CHECK WITH YOU IF MY CAR IS ABLE FOR THAT. THANKS *TR
NHTSA ODI #10567962
89,000 miles · Jul 15, 2013
Air BagsSeat Belts
NOTHING CRAZY HAPPENED, WAS JUST DRIVING DOWN THE STREET, AND ALL OF A SUDDEN MESSAGE POPPED ON MY SCREEN "PASSENGER RESTRAINT SYSTEMS MALFUNCTION". IT SHOULD BE FIXED BY BMW DEALERSHIP AT NO COST SINCE THERE IS A RECALL ON THIS PROBLEM, BUT DEALERSHIP REFUSED TO DO IT. *TR
NHTSA ODI #10524944
85,000 miles · Jun 30, 2013
Air BagsSeat Belts
AIR BAG LIGHT ILLUMINATED , PASSENGER RESTRAINT SYSTEM ERROR . CURRENT RECALL ON OVER 200,000 CARS DOESN'T INCLUDE THE 05 530I AS STATED BY DEALER . AIRBAG ON PASSAGES SIDE RENDERED IN OPERABLE WITH FAULT CODES. AS PER RECALL THIS IS DUE TO DEFECTIVE PASSENGER SIDE MAT. I BELIEVE THIS TO BE AN EXTREMELY HAZARDOUS SAFETY ISSUE. A…
Read full complaint
AIR BAG LIGHT ILLUMINATED , PASSENGER RESTRAINT SYSTEM ERROR . CURRENT RECALL ON OVER 200,000 CARS DOESN'T INCLUDE THE 05 530I AS STATED BY DEALER . AIRBAG ON PASSAGES SIDE RENDERED IN OPERABLE WITH FAULT CODES. AS PER RECALL THIS IS DUE TO DEFECTIVE PASSENGER SIDE MAT. I BELIEVE THIS TO BE AN EXTREMELY HAZARDOUS SAFETY ISSUE. AIRBAGS WILL NOT DEPLOY UPON IMPACT ! RECALL ID # 05V504000 . AS I HAVE SEEN IN THE COMPLAINTS FILED I'M NOT THE ONLY 2005 530I WITH THIS ISSUE . I HAVE SEEN NUMEROUS COMPLAINTS , I GUESS BMW IS WAITING FOR A FATALITY TO OCCUR . *TR
NHTSA ODI #10522470
95,000 miles · Jun 25, 2013
Air Bags
TL* THE CONTACT OWNS A 2005 BMW 530I. THE CONTACT STATED THAT THE AIR BAG LIGHT DID NOT ILLUMINATE ON THE INSTRUMENT PANEL TO INDICATED THAT THE AIR BAG WAS ACTIVATED. THE CONTACT STATED THE FAILURE WAS IDENTICAL TO NHTSA RECALL CAMPAIGN ID NUMBER: 08V384 (AIR BAGS), BUT THE MANUFACTURER CONFIRMED THAT THE VEHICLE WAS NOT INCLUD…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 530I. THE CONTACT STATED THAT THE AIR BAG LIGHT DID NOT ILLUMINATE ON THE INSTRUMENT PANEL TO INDICATED THAT THE AIR BAG WAS ACTIVATED. THE CONTACT STATED THE FAILURE WAS IDENTICAL TO NHTSA RECALL CAMPAIGN ID NUMBER: 08V384 (AIR BAGS), BUT THE MANUFACTURER CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED. THE VEHICLE WAS NOT BEEN INSPECTED. THE FAILURE MILEAGE WAS 95,000. THE CURRENT MILEAGE WAS 97,600. *TR
NHTSA ODI #10521623
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Illustration