2008 BMW 5 Series

ELECTRICAL WIRING INSULATION/SHEATHING WITHIN THE HEADLIGHT UNIT/HOUSING IS SHOWING SIGNS OF AND OR OUTRIGHT DETERIORATION WHICH IN TURN EXPOSES BARE WIRES WITHIN THE HEADLIGHT HOUSING. AT THIS POINT, THE DAYTIME RUNNING LAMPS HAVE BEEN THE ONLY EFFECTED LIGHTS BUT THE WIRES FOR THE HEADLIGHTS ARE ALSO NOTICEABLY TROUBLED. THE ISSUE IS NOT SPEED, MOVEMENT OR AREA DEPENDENT. FOR FURTHER REFERENCE, I WILL PROVIDE A LINK TO AN OWNER'S FORUM DETAILING OTHER'S DILEMMAS DUE TO THIS EXACT ISSUE: HTTP://WWW.BIMMERFEST.COM/FORUMS/SHOWTHREAD.PHP?T=798640 I LOOK FORWARD TO A RESPONSE.

ON OR ABOUT MAY 2013 I WAS TRAVELING AT 60MPH ON THE FREEWAY WHEN SUDDENLY I HEARD A LOUD BANG SOUND AND MY VEHICLE CAME TO AN AUTOMATIC STOP. SCARED AS VEHICLE BEHIND ME SCREECHED AND TURN AWAY AVOIDING ME. I REMAINED IN THE MIDDLE OF THE ROAD FOR APPROXIMATELY 30 MINUTES BEFORE THE VEHICLE RESTARTED AND I TRAVELED FEARFULLY TO COMPLETE MY ASSIGNMENT. SAME DAY ON MY RETURN HOME VEHICLE STOPPED ABOUT 3 TIMES BUT I DROVE STRAIGHT TO DEALERSHIP. WITHOUT INSPECTING MY VEHICLE I WAS TOLD MY ALTERNATOR AND BATTERY WAS GONE. I WAS QUOTED VERY HIGH AMOUNT BUT SOMETHING TOLD ME A BAD ALTERNATOR AND BATTERY WOULD NOT START A VEHICLE SO I OFFERED TO TAKE MY VEHICLE HOME. MY VEHICLE STAYED HOME FOR ABOUT 4 MONTHS WITHOUT USE ONLY WARM UPS REVERSE AND PARK. I DID EXTENSIVE RESEARCH TO AVOID THE FRIVOLOUS AMOUNT THE DEALERS QUOTED AND FOUND THAT THE INTEGRATED MODULE (IVM) WAS BAD. I GOT IT FOR $144 AND REPLACED IT AND PROBLEM WAS FIXED AFTER 4 MONTHS. UNTIL APRIL 2014 I DROVE THE OUT TO WORK AND BARELY TWO MILES AWAY FROM HOME I STOPPED AT A TRAFFIC LIGHT AND WHEN RELEASED THE VEHICLE SOUNDED A HUGE BANGED SOUND THIS WITH TRANSMISSION MALFUNCTION LIGHT ACTIVE BRAKE LIGHTS AND SEVERAL OTHER LIGHTS ON DASH BOARD. ONCE AGAIN I SURVIVED BEING RAN OVER IN THE EARLY MORNING RUSH. TOOK VEHICLE TO BMW DEALERSHIP. TOLD GEAR SHIFTER WAS BAD AND REPLACED FOR $915 AND THEREAFTER I RECEIVED A CALL THE TRANSMISSION WAS OUT. I WAS ADVISED COST WILL BE $15000 THEN LATER THAT IT CANNOT BE FIXED AND ADVICE TO SALE IT AS IS TO SOME GUY. I OWE $17900 ON VEHICLE. CALLED BMW NORTH AMERICA TO COMPLAIN WAS TOLD NEW TRANSMISSION COST $9200 AND I'M ASKED TO PAY $7400 BEST DEAL. THERE'S NO REASON FOR TRANSMISSION ON 2008 TO GO OUT. SINCE DEALERS TOOK MY CAR THEY GAVE ME A RENTAL FOR 4 DAYS AND TOOK IT FROM ME BUT KEPT MY VEHICLE FOR ADDITIONAL 2 WEEKS AND ARE STILL HOLDING IT CALLING TO ACCEPT DEAL. *TR

MALFUNCTION OF LEFT HEADLIGHT. DEALER INSPECTION REVEALED"HEADLIGHT WIRES LEADING TO BULB SOCKET HAVE CORROSION ON THEM AND CASING AROUND THE WIRES IS COMING OFF". THERE WAS A RECENT VEHICLE SAFETY RECALL FOR THIS MODEL CAR FOR SIMILAR ISSUES WITH REAR LAMP BULB CARRIER: RECALL CAMPAIGN NO. 13V-407 POTENTIALLY SERIOUS SAFETY ISSUE WITH MALFUNCTION OF HEADLIGHTS LEADING TO DANGEROUS DRIVING CONDITIONS OR CRASH CAN OCCUR ESPECIALLY AT NIGHT OR IN BAD/INCLEMENT WEATHER. *TR

GROUND WIRE FOR PASSENGER SIDE TAIL LIGHT BURNED UP. GROUND WIRE, BOTH SIDES OF ELECTRICAL CONNECTOR, AND TAIL LIGHT BULB HOLDER ALL BURNED UP. PASSENGER SIDE BRAKE LIGHT, TAIL LIGHT, TURN SIGNAL AND BACK UP LIGHT DO NOT FUNCTION AT ALL. IMPROPERLY RATED FUSE DID NOT BLOW BEFORE CIRCUIT BURNED UP AND MELTED. THIS CIRCUIT IS NOT DESIGNED CORRECTLY. THIS IS A SAFETY HAZARD TO MYSELF AND ANYONE DRIVING BEHIND ME. CAR MODEL IS A 2008 528XI. *TR

VEHICLE IS 2008 528I SEDAN. THE TIRE MONITOR PRESSURE INDICATOR WAS DISPLAYED. I TOOK THE CAR TO A BMW DEALERSHIP TO CHECK THE TIRE PRESSURE. THEY SAID THE TIRE PRESSURE WAS OK ON ALL 4 TIRES. HOWEVER, IT CONTINUED TO DISPLAY THE TMP INDICATOR. THEN FOR THE NEXT COUPLE OF DAYS, WHEN THE VEHICLE WAS STARTED, VARIOUS ALERT INDICATORS WOULD DISPLAY BRIEFLY AND THE DATE AND TIME WERE NOT SET. I TOOK THE CAR BACK TO THE DEALERSHIP AND THEY DETERMINED FLUID (REFERRED TO BY BMW AS 'AN OUTSIDE INFLUENCE') LEAKED FROM INSIDE THE TRUNK OF VEHICLE INTO THE RDC (COMMUNICATION) MODULE, WHICH IS LOCATED UNDER THE TRUNK. THE SERVICE ADVISOR STATED THE SUBMERGED FLUID SHORTED OUT THE MODULE AND MELTED THE HARNESS. THE RDC MODULE AND THE HARNESS WERE REPLACED. THE TRUNK WAS NOT WET SO I DID NOT REALIZE ANYTHING HAD LEAKED NOR WAS I AWARE THERE WERE CRITICAL ELECTRICAL COMPONENTS LOCATED DIRECTLY UNDER THE TRUNK, WHICH WERE NOT PROPERLY PROTECTED. TO PLACE THE RDC MODULE IN AN AREA WHERE LIQUIDS CAN PENETRATE (I.E. OPEN DRUNK WHILE RAINING, GROCERIES SPILLING'), IS EXTREMELY POOR VEHICLE DESIGN. SINCE THE PROBLEM WAS A RESULT OF 'AN OUTSIDE INFLUENCE' IT WAS NOT COVERED UNDER WARRANTY AND IT COST ALMOST $1000 TO FIX. *TR

OUR 2008 BMW 528I HAS AN ELECTRICAL PROBLEM IN WHICH THE VEHICLE DOES NOT HAVE THE CAPABILITY OF CHARGING THE BATTERY IF THE VEHICLE IS DRIVEN SHORT DISTANCES OR MULTIPLE STOPS. THIS CAUSES THE BATTERY TO RUN DOWN AND THE VEHICLE TO BECOME INOPERATIVE. THE VEHICLE WILL STOP AND NOT START. AFTER FOUR (4) TRIPS TO THE DEALER (TRUCKED TWICE) THE DEALER HAS DETERMINED THAT IT IS AN OPERATOR PROBLEM AND THE VEHICLE SHOULD BE PLUGGED INTO AND ELECTRICAL BATTERY CHARGER WHEN NOT IN USE. ADDITIONALLY, THEY INDICATED THE VEHICLE SHOULD BE TAKEN DAILY FOR DRIVES OF MORE THAN 20 MILES TO HOPEFULLY CHARGE THE BATTERY. THE ISSUE HAS US IN FEAR OF THE VEHICLE STALLING IN TRAFFIC AND CREATING A SERIOUS SAFETY ISSUE. *TR

VEHICLE IS 2008 BMW 535XI WAGON. BLOCKED SUNROOF DRAINS MEANT THAT WATER DRAINED INTO THE VEHICLE, GATHERING IN THE TRUNK WHERE THE ELECTRONICS SIT. CAR HAD MULTIPLE ENGINE FAILURES AND WARNINGS OF TRANSMISSION FAILURE, ELECTRICAL FAILURE, SUNROOF ERROR AND TPM FAILURE. CAUSE PER BMW WAS BLOCKAGE OF REAR SUNROOF DRAIN. THIS IS A COMMON FAULT CAUSED BY POOR DESIGN OF THE SUNROOF DRAINS (TOO NARROW AND PRONE TO BLOCKING). A RECALL ON THE SEDAN 5 SERIES MOVES THE ELECTRONICS TO A HIGHER POSITION IN THE VEHICLE TO PREVENT THE ELECTRONICS DAMAGE BUT BMW STATE THERE IS NO SIMILAR MOVE POSSIBLE FOR THE WAGON., ALSO IT IMPOSSIBLE TO DIAGNOSE THE PROBLEM BEFORE IT OCCURS AND BMW HAS NO SUGGESTED SERVICE STEPS T P[REVENT OCCURRENCE. WHEN THIS HAPPENS ITS VERY DANGEROUS AND V EXPENSIVE TO REMEDIATE. BMW OCCASIONALLY COVERS A GOODWILL REPAIR BUT WON'T COVER UNDER WARRANTY. ADVICE FROM BMW IS NOT PARK THE VEHICLE UNDER TREES! DEALER INDICATES WHEN THIS RE-OCCURS BMW WILL NOT COVER THE COST AGAIN. *TR