NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
2 reportsClear category filterMileage unknown · Oct 28, 2021
Unknown Or OtherInjury
Fine, white particles are blowing out of the cabin air ducts whenever the air conditioner or fan is turned on. My local BMW service center, Herb Chambers BMW of Boston, determined that the debris is flakes of aluminum from the deteriorated aluminum alloy fins of the AC evaporator coil and heater exchanger. The cabin air ducts we…
Read full complaint
Fine, white particles are blowing out of the cabin air ducts whenever the air conditioner or fan is turned on. My local BMW service center, Herb Chambers BMW of Boston, determined that the debris is flakes of aluminum from the deteriorated aluminum alloy fins of the AC evaporator coil and heater exchanger. The cabin air ducts were scoped and found to be intact with no intrusion of outside contaminants. The dealer determined that if not replaced, “the A/C Evaporator will fail…” and quoted the cost of repairs at $5,286.18. As I am sure you are aware, aluminum is a neurotoxin when absorbed by the body. The science is well established and can be easily sourced using Google Scholar: https://scholar.google.com/scholar?hl=en&as_sdt=0%2C22&q=neurotoxicity+of+aluminum&oq=neuroto. The fine aluminum particles blowing from the heating and cooling system of my BMW have been absorbed into my eyes, mouth and airways, putting me at risk from internal exposure to aluminum. They have also rendered my BMW 335d unusable due to this health safety hazard. I filed a request for recourse with BMW of North America and was denied.
NHTSA ODI #11438480
70,000 miles · Aug 27, 2018
EngineUnknown Or Other
THE CAR IS IN THE SHOP EVERY WEEK I HAVE HAD IT TOWED 12 TIMES SINCE MAY. I TOOK IT IN FOR THE RECALL (ELECTRICAL ISSUED RECENTLY) THE VEHICLE RAN GREAT, NOW THE DEALERSHIP SAYS I NEED 3 NEW INJECTORS. THE INJECTORS ARE BAD. I AM READING REVIEWS AND OTHERS STATED THEIR BMW'S NEED NEW INJECTORS. SO IS THEIR A RECALL FOR INJE…
Read full complaint
THE CAR IS IN THE SHOP EVERY WEEK I HAVE HAD IT TOWED 12 TIMES SINCE MAY. I TOOK IT IN FOR THE RECALL (ELECTRICAL ISSUED RECENTLY) THE VEHICLE RAN GREAT, NOW THE DEALERSHIP SAYS I NEED 3 NEW INJECTORS. THE INJECTORS ARE BAD. I AM READING REVIEWS AND OTHERS STATED THEIR BMW'S NEED NEW INJECTORS. SO IS THEIR A RECALL FOR INJECTORS I DID NOT SEE? THE CAR STAHLED WHILE I WAS DRIVING IT STOPPED IN THE MIDDLE OF THE ROAD.
NHTSA ODI #11122690
Official recalls
6Jul 3, 2024
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Air Bags:frontal
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jun 19, 2019
BMW of North America, LLC (BMW) is recalling certain 2009 328i and 328xi, 2009-2011 335d, 2008-2012 M3 Coupe and M3 Convertible, and 2008-2011 M3 Sedan vehicles. The connection of the positive battery cable at the fuse box terminal may degrade, resulting in an intermittent loss of electrical power.
Consequence & remedy
Consequence: A loss of electrical power can cause the vehicle to stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace and secure the positive battery cable connector, free of charge. The recall began August 14, 2019. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall is an expansion of a previous recall, number 18V-314.
Additional source detail variants (3)
Electrical System:wiring:fuses And Circuit Breakers
BMW of North America, LLC (BMW) is recalling certain 2009 328i and 328xi, 2009-2011 335d, 2008-2012 M3 Coupe and M3 Convertible, and 2008-2011 M3 Sedan vehicles. The connection of the positive battery cable at the fuse box terminal may degrade, resulting in an intermittent loss of electrical power.
Consequence: A loss of electrical power can cause the vehicle to stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace and secure the positive battery cable connector, free of charge. The recall began August 14, 2019. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall is an expansion of a previous recall, number 18V-314.
Electrical SYSTEM:12V/24V/48V Battery:cables
BMW of North America, LLC (BMW) is recalling certain 2009 328i and 328xi, 2009-2011 335d, 2008-2012 M3 Coupe and M3 Convertible, and 2008-2011 M3 Sedan vehicles. The connection of the positive battery cable at the fuse box terminal may degrade, resulting in an intermittent loss of electrical power.
Consequence: A loss of electrical power can cause the vehicle to stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace and secure the positive battery cable connector, free of charge. The recall began August 14, 2019. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall is an expansion of a previous recall, number 18V-314.
Electrical System
BMW of North America, LLC (BMW) is recalling certain 2009 328i and 328xi, 2009-2011 335d, 2008-2012 M3 Coupe and M3 Convertible, and 2008-2011 M3 Sedan vehicles. The connection of the positive battery cable at the fuse box terminal may degrade, resulting in an intermittent loss of electrical power.
Consequence: A loss of electrical power can cause the vehicle to stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace and secure the positive battery cable connector, free of charge. The recall began August 14, 2019. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall is an expansion of a previous recall, number 18V-314.
May 14, 2018
BMW of North America, LLC (BMW) is recalling certain 2010-2011 BMW 335d vehicles with diesel engines. The connection of the positive battery cable at the fuse box terminal may degrade over time, possibly resulting in an intermittent loss of electrical power.
Consequence & remedy
Consequence: A loss of electrical power to the vehicle can cause the vehicle to unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on June 29, 2018. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Electrical System:wiring:fuses And Circuit Breakers
BMW of North America, LLC (BMW) is recalling certain 2010-2011 BMW 335d vehicles with diesel engines. The connection of the positive battery cable at the fuse box terminal may degrade over time, possibly resulting in an intermittent loss of electrical power.
Consequence: A loss of electrical power to the vehicle can cause the vehicle to unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on June 29, 2018. Owners may contact BMW customer service at 1-800-525-7417.
Electrical SYSTEM:12V/24V/48V Battery:cables
BMW of North America, LLC (BMW) is recalling certain 2010-2011 BMW 335d vehicles with diesel engines. The connection of the positive battery cable at the fuse box terminal may degrade over time, possibly resulting in an intermittent loss of electrical power.
Consequence: A loss of electrical power to the vehicle can cause the vehicle to unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on June 29, 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 25, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
Consequence & remedy
Consequence: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.
Remedy: BMW will notify owners, and dealers will replace the wiring and electrical connectors, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact BMW customer service at 1-800-525-7417.
Feb 2, 2017
BMW of North America, LLC (BMW) is recalling certain 2011-2012 135i Coupe, 1 Series M Coupe and 135i Convertible vehicles, 2011 Z4 sDrive 35i, 335i, 335d, 335i Coupe, 335is Coupe, 335i Convertible, 335is Convertible, 535i, 535i xDrive, 535i Gran Turismo and 550i xDrive Gran Turismo vehicles and 2012 740i and 740Li vehicles. The rear driveshaft constant velocity (CV) joint on the affected vehicles may fatigue and break.
Consequence & remedy
Consequence: If the CV joint breaks, the vehicle may have a loss of propulsion, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the rear driveshaft CV joint and, based on its production date, will replace it, free of charge. The recall began April 21, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration