NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
77 reports154,000 miles · Jul 16, 2014
Air Bags
TL* THE CONTACT OWNS A 2003 BMW 330I. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE DRIVER'S SIDE AIR BAG DEPLOYED INADVERTENTLY. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STATED THAT THE AIR BAGS DEPLOYED DUE TO DRIVING OVER A POT HOLE. THE MANUFACT…
Read full complaint
TL* THE CONTACT OWNS A 2003 BMW 330I. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE DRIVER'S SIDE AIR BAG DEPLOYED INADVERTENTLY. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STATED THAT THE AIR BAGS DEPLOYED DUE TO DRIVING OVER A POT HOLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 154,000.
NHTSA ODI #10611031
83,000 miles · Jun 23, 2014
Fuel/propulsion SystemService Brakes
TL* THE CONTACT OWNS A 2003 BMW 330I. THE CONTACT STATED THAT THE BRAKES SEIZED AND THE STEERING WHEEL BECAME DIFFICULT TO TURN THEN THE EML WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE FUEL PUMP FRACTURED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 83,000.
NHTSA ODI #10605245
9,692 miles · Jun 2, 2014
Air Bags
TL* THE CONTACT OWNS A 2003 BMW 330I. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC, WHO DIAGNOSED THE FAILURE AS AN IGNITION CIRCUIT AIR BAG INDICATOR FAULT. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 9,692 AND THE CURRENT MILEAG…
Read full complaint
TL* THE CONTACT OWNS A 2003 BMW 330I. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC, WHO DIAGNOSED THE FAILURE AS AN IGNITION CIRCUIT AIR BAG INDICATOR FAULT. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 9,692 AND THE CURRENT MILEAGE WAS 79,692.
NHTSA ODI #10595606
90,000 miles · Nov 14, 2013
Exterior Lighting
I'M CONTACTING YOU TO EXPRESS MY FRUSTRATION WITH THE QUALITY OF THE BMW XENON HEADLIGHT. THE XENON LOW BEAMS STARTED TO DIM AND ARE NOW USELESS. THROUGH GOOGLE I FOUND OUT THAT THIS IS A VERY COMMON PROBLEM SINCE THE PLASTIC REFLECTOR/PROJECTOR BOWLS JUST BURN OUT. THE LIGHT OUTPUT IS NOW TOO LOW TO BE SAFE AT NIGHT. HTTP://…
Read full complaint
I'M CONTACTING YOU TO EXPRESS MY FRUSTRATION WITH THE QUALITY OF THE BMW XENON HEADLIGHT. THE XENON LOW BEAMS STARTED TO DIM AND ARE NOW USELESS. THROUGH GOOGLE I FOUND OUT THAT THIS IS A VERY COMMON PROBLEM SINCE THE PLASTIC REFLECTOR/PROJECTOR BOWLS JUST BURN OUT. THE LIGHT OUTPUT IS NOW TOO LOW TO BE SAFE AT NIGHT. HTTP://WWW.ZHPMAFIA.COM/FORUMS/SHOWTHREAD.PHP?3625-ZKW-REFLECTOR-RECALL-OPEN-NTHSA-INVESTIGATION&S=B19D0DF67F3AFE70AC7AD8205496E414. *TR
NHTSA ODI #10552280
Mileage unknown · Mar 1, 2013
Exterior Lighting
THE HEADLIGHTS ON THE CAR SEEMS TO BE VERY DIM. THE AMOUNT OF LIGHT THAT COMES OUT OF THE HEADLIGHTS LOOKS SLIGHTLY BROWN AND PRETTY DARK AS COMPARED TO MANY OTHER CARS ON THE ROAD. I BELIEVE THAT THE HEADLIGHTS WERE DESIGNED WITH PLASTIC AND WHICH CASE THE BULB WOULD CAUSE THINGS TO BURN OVER TIME. *TR
NHTSA ODI #10500888
65,000 miles · Feb 18, 2013
Electrical System
PLEASE NOTE THAT THIS INCIDENT HAPPENED PRIOR TO THE DATE AND MILEAGE NOTED ABOVE AS THE PREVIOUS OWNER HAD TO ALSO DEAL WITH THIS PROBLEM. I REPORT THE DATES AS WHEN I RECEIVED THE CAR WHEN IT CAME INTO MY OWNERSHIP ONLY. DRIVER'S DOOR LOCK FAILED TO ELECTRONICALLY AND MECHANICALLY UNLOCKED FROM THE INSIDE. THE DOOR CAN ONLY BE…
Read full complaint
PLEASE NOTE THAT THIS INCIDENT HAPPENED PRIOR TO THE DATE AND MILEAGE NOTED ABOVE AS THE PREVIOUS OWNER HAD TO ALSO DEAL WITH THIS PROBLEM. I REPORT THE DATES AS WHEN I RECEIVED THE CAR WHEN IT CAME INTO MY OWNERSHIP ONLY. DRIVER'S DOOR LOCK FAILED TO ELECTRONICALLY AND MECHANICALLY UNLOCKED FROM THE INSIDE. THE DOOR CAN ONLY BE OPENED FROM THE OUTSIDE WITH A KEY. THIS POSES A POTENTIALLY GRAVE SAFETY CONCERN AS NO ONE CAN OPEN THE DOOR FROM INSIDE - ESSENTIALLY PASSENGERS MAY BECOME LOCKED-IN. CULPRIT APPEARS TO BE BMW E46 GM V MODULE FACTORY CODING WHERE GLITCH PREVENTS DOOR LOCKS FROM BEHAVING APPROPRIATELY. AFTERMARKET REPROGRAMMING FIXES THE ISSUE. THIS IS A VERY COMMON ISSUE FOR BMW E46 VEHICLES - INTERNET SEARCH "BMW GM V CONTROL MODULE" FOR DETAILS AND TESTIMONIALS. BMW SHOULD BE HELD RESPONSIBLE AND FIX THE ISSUE. *TR
NHTSA ODI #10498546
120,000 miles · Oct 12, 2012
Electrical SystemExterior Lighting
ABOUT 2 OR SO YEARS AGO I STARTED TO NOTICE MY NIGHT DRIVING WAS BECOMING UNPLEASANT AND UNSAFE DUE TO THE FACT THAT MY HEADLIGHTS WERE LOSING OUTPUT. AFTER REPLACING THE PLASTIC LENSES NEW FROM BMW I THEN WENT ON TO BUYING NEW BULBS THINKING THAT WOULD MAKE A DIFF. IT DIDN'T. 10-12-12 TODAY MY LIGHTS ARE YELLOW/FOGGY ON THE IN…
Read full complaint
ABOUT 2 OR SO YEARS AGO I STARTED TO NOTICE MY NIGHT DRIVING WAS BECOMING UNPLEASANT AND UNSAFE DUE TO THE FACT THAT MY HEADLIGHTS WERE LOSING OUTPUT. AFTER REPLACING THE PLASTIC LENSES NEW FROM BMW I THEN WENT ON TO BUYING NEW BULBS THINKING THAT WOULD MAKE A DIFF. IT DIDN'T. 10-12-12 TODAY MY LIGHTS ARE YELLOW/FOGGY ON THE INSIDE LIKE SMOKE HAS MADE THE LENSES OPAQUE AND MY OUTPUT IS BARELY SEEN, I LOOKED ON THE BACK WHERE THE BULB IS INSERTED AND IT SURE LOOKS BROWN IN THERE, I GET MORE LIGHT REFLECTED ON THE GROUND WHEN I TURN MY TURN SIGNALS THAN I DO ON THE HEADLIGHTS. AFTER GOING ONLINE AND SEARCHING, MY CAR CAME FROM FACTORY WITH A DEFECT ZKW XENON HEADLIGHT SYSTEM, WHICH 99% OF THE ZKW HEADLIGHT OWNERS OF E46 SEDANS FOUND ONLINE HAVE THE SAME ISSUE, ALL YOU HAVE TO DO IS GOOGLE "E46 ZKW BURNT BOWLS" . I HAVE A 4 MONTH OLD LITTLE GIRL, I CANNOT IMAGINE DRIVING WITH HER IN THE CAR ON A RAINY NIGHT AND MY CONCERN IS NOW MY BABY. I CAN SEND YOU PICTURES IF NEEDED PLEASE, THANK YOU FOR READING AND I APPRECIATE YOUR HELP. *TR
NHTSA ODI #10479862
46,000 miles · Sep 21, 2012
Exterior Lighting
CAR IS EQUIPPED WITH OPTIONAL, FACTORY-INSTALLED, BI-XENON HEADLAMP ASSEMBLIES MADE BY ZKW. THE PROJECTOR BOWLS INSIDE, WHICH GREATLY MAGNIFY THE LIGHT OUTPUT OF THE BULB, ARE MADE OF A PLASTIC THAT CANNOT HANDLE THE HEAT OF THE XENON BULB. AS A RESULT, THE REFLECTIVE SURFACE BURNS AND TURNS BROWN. IN DOING SO, THE LIGHT OUTPUT …
Read full complaint
CAR IS EQUIPPED WITH OPTIONAL, FACTORY-INSTALLED, BI-XENON HEADLAMP ASSEMBLIES MADE BY ZKW. THE PROJECTOR BOWLS INSIDE, WHICH GREATLY MAGNIFY THE LIGHT OUTPUT OF THE BULB, ARE MADE OF A PLASTIC THAT CANNOT HANDLE THE HEAT OF THE XENON BULB. AS A RESULT, THE REFLECTIVE SURFACE BURNS AND TURNS BROWN. IN DOING SO, THE LIGHT OUTPUT IS GREATLY REDUCED TO A DANGEROUS LEVEL. THIS PROBLEM AFFECTS BOTH HIGH AND LOW BEAM OPERATION. SITUATION GETS PROGRESSIVELY WORSE OVER TIME. THE PLASTIC BOWLS ARE NOT SOLD SEPARATELY, THEREFORE THE ONLY SOLUTION IS TO PURCHASE NEW HEADLAMP ASSEMBLIES, AT AN APPROXIMATE COST OF $1,900 FOR THE PAIR. *TR
NHTSA ODI #10476660
40,000 miles · Aug 7, 2012
Air Bags
TL* THE CONTACT OWNS A 2003 BMW 330-I. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE FAILURE WAS CAUSED BY THE AIR BAGS SENSOR. THE VEHICLE WAS REPAIRED HOWEVER THE FAILURE RECURRED SEVERAL TIMES AFTER THE REPAIR. THE CONTACT CONTINUED TO TAKE TH…
Read full complaint
TL* THE CONTACT OWNS A 2003 BMW 330-I. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE FAILURE WAS CAUSED BY THE AIR BAGS SENSOR. THE VEHICLE WAS REPAIRED HOWEVER THE FAILURE RECURRED SEVERAL TIMES AFTER THE REPAIR. THE CONTACT CONTINUED TO TAKE THE VEHICLE TO THE DEALER UPON EACH RECURRENCE BUT THE CONTACT WAS CONCERNED BECAUSE AT EVERY VISIT TO THE DEALER, SHE WAS TOLD A DIFFERENT COMPONENT WAS CAUSING THE FAILURE. THE CONTACT WAS NOT AWARE OF EACH COMPONENT THAT SHE WAS ADVISED TO HAVE REPAIRED. THE DEALER LATER DENIED ANY FURTHER SERVICE TO THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 84,000.
NHTSA ODI #10469521
114,000 miles · Jul 11, 2012
Electrical System
CENTRAL LOCKING MECHANISM IS GOING CRAZY. IF I WERE IN A CRASH, THE CAR IS SUPPOSED TO UNLOCK THE DOORS, TURN ON THE FLASHERS, ETC. THIS WILL NOT HAPPEN WITH THE CENTRAL LOCKING MECHANISM WORKING INTERMITTENTLY. IF I AM INJURED IN AN ACCIDENT IT MAY BE MORE DIFFICULT FOR PARAMEDICS TO GET TO ME. I WAS ACTUALLY LOCKED IN MY C…
Read full complaint
CENTRAL LOCKING MECHANISM IS GOING CRAZY. IF I WERE IN A CRASH, THE CAR IS SUPPOSED TO UNLOCK THE DOORS, TURN ON THE FLASHERS, ETC. THIS WILL NOT HAPPEN WITH THE CENTRAL LOCKING MECHANISM WORKING INTERMITTENTLY. IF I AM INJURED IN AN ACCIDENT IT MAY BE MORE DIFFICULT FOR PARAMEDICS TO GET TO ME. I WAS ACTUALLY LOCKED IN MY CAR TODAY WHEN I ARRIVED AT SCHOOL. I HAD TO CRAWL OUT THE WINDOW AND THANKFULLY I WAS ABLE TO ROLL UP THE WINDOW WITH THE KEY IN THE DOOR. I HAVE READ THAT THIS MAY STOP WORKING AS WELL. THIS IS VERY CONCERNING, ONLINE I HAVE READ THAT THIS CAN COST AROUND $750.00 TO FIX AT THE LOCAL BMW STEALERSHIP (WHOOPS, DEALERSHIP). BMW SHOULD FIX THIS IF THEY ARE CONCERNED WITH THEIR DRIVERS SAFETY. *TR
NHTSA ODI #10465300
Official recalls
6Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2000-2005 323iT, 325iT, 325xiT, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323Ci, 325Ci, 328Ci, 330Ci, M3 Coupe, 323Cic, 325Cic, 330Cic, and M3 Convertible vehicles equipped with non-desiccated frontal Takata PSAN inflators and PSPI passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the passenger's front air bag, free of charge. The recall began February 13, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jun 11, 2018
BMW of North America, LLC (BMW) is recalling certain model year 2000 323i sedans, coupes, convertibles, and Sports Wagons; 2000 328i sedans and coupes; 2001-2005 325i sedans, coupes, convertibles, and Sport Wagons; 2001-2005 325xi sedans and Sports Wagons; 2006 325i coupes and convertibles; 2001-2006 330i sedans, coupes, and convertibles; 2001-2005 330xi sedans; and 2001-2006 M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure that could cause the air bag inflator to rupture upon deployment of the air bag.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, excessive internal pressure could cause rupturing of the inflator resulting in metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger side frontal air bag, free of charge. An interim notice was mailed to owners in September 2014. A second notice was mailed when an adequate supply of parts became available, on December 1, 2014. Owners may contact BMW customer service at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
May 28, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi Sedans, and 325xi and 325i Sportswagons, 2002-2006 330Ci, 325Ci, and M3 Convertibles and 325i, 330i, and M3 Coupes, 2002-2003 M5, 540i, 525i Sedan, and 530i Sedans, and 540i and 525i Sportswagons, and 2003 X5 3.0i and 4.4i Sports Activity Vehicles. Please note that the 5-series and X5 vehicles are only included if they are equipped with the optional sports steering wheel. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall began Aug 2016. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall supersedes recall 14V-348 in its entirety. Additionally, vehicles that have had their driver side frontal air bag replaced previously as part of a recall remedy need to have their air bag replaced under this recall as well. Note: On December 17, 2015 BMW removed the model year 2004 X5 3.0i and 4.4i Sports Activity vehicle from this recall. Those vehicles were mistakenly identified as including the air bags that are subject to this recall.
May 2, 2013
BMW is recalling certain model year 2002-2003 325i, 325xi, 330i, 330xi sedans; 325Ci and 330Ci coupes and convertibles; 325iT and 325xiT Sports Wagons; and M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW intends to issue initial notifications to owners informing them of the safety defect in June 2013. Once replacement parts are available, estimated for July, BMW will notify owners again to contact their dealers and schedule a replacement of the passenger air bag, free of charge. Owners may contact BMW customer service at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Aug 26, 2011
BMW IS RECALLING CERTAIN MODEL YEAR 2002-2005 325I, 325XI, 330I, AND 330XI VEHICLES MANUFACTURED FROM SEPTEMBER 1, 2001, THROUGH MARCH 1, 2005. OVER TIME, RESISTANCE IN THE ELECTRICAL CONTACTS MAY CAUSE ONE OR MORE REAR LAMP FUNCTIONS (TAIL LIGHT, BRAKE LIGHT, AND/OR TURN-SIGNAL), WITHIN THE VEHICLE'S BODY PANEL, TO STOP WORKING.
Consequence & remedy
Consequence: INTERMITTENT LIGHT OPERATION REDUCES THE ABILITY TO WARN OTHER MOTORISTS OF THE DRIVER'S INTENTIONS. THIS COULD CAUSE A VEHICLE CRASH WITHOUT WARNING.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Additional source detail variants (3)
Exterior Lighting:turn Signal
BMW IS RECALLING CERTAIN MODEL YEAR 2002-2005 325I, 325XI, 330I, AND 330XI VEHICLES MANUFACTURED FROM SEPTEMBER 1, 2001, THROUGH MARCH 1, 2005. OVER TIME, RESISTANCE IN THE ELECTRICAL CONTACTS MAY CAUSE ONE OR MORE REAR LAMP FUNCTIONS (TAIL LIGHT, BRAKE LIGHT, AND/OR TURN-SIGNAL), WITHIN THE VEHICLE'S BODY PANEL, TO STOP WORKING.
Consequence: INTERMITTENT LIGHT OPERATION REDUCES THE ABILITY TO WARN OTHER MOTORISTS OF THE DRIVER'S INTENTIONS. THIS COULD CAUSE A VEHICLE CRASH WITHOUT WARNING.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Exterior Lighting:brake Lights
BMW IS RECALLING CERTAIN MODEL YEAR 2002-2005 325I, 325XI, 330I, AND 330XI VEHICLES MANUFACTURED FROM SEPTEMBER 1, 2001, THROUGH MARCH 1, 2005. OVER TIME, RESISTANCE IN THE ELECTRICAL CONTACTS MAY CAUSE ONE OR MORE REAR LAMP FUNCTIONS (TAIL LIGHT, BRAKE LIGHT, AND/OR TURN-SIGNAL), WITHIN THE VEHICLE'S BODY PANEL, TO STOP WORKING.
Consequence: INTERMITTENT LIGHT OPERATION REDUCES THE ABILITY TO WARN OTHER MOTORISTS OF THE DRIVER'S INTENTIONS. THIS COULD CAUSE A VEHICLE CRASH WITHOUT WARNING.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Exterior Lighting:tail Lights
BMW IS RECALLING CERTAIN MODEL YEAR 2002-2005 325I, 325XI, 330I, AND 330XI VEHICLES MANUFACTURED FROM SEPTEMBER 1, 2001, THROUGH MARCH 1, 2005. OVER TIME, RESISTANCE IN THE ELECTRICAL CONTACTS MAY CAUSE ONE OR MORE REAR LAMP FUNCTIONS (TAIL LIGHT, BRAKE LIGHT, AND/OR TURN-SIGNAL), WITHIN THE VEHICLE'S BODY PANEL, TO STOP WORKING.
Consequence: INTERMITTENT LIGHT OPERATION REDUCES THE ABILITY TO WARN OTHER MOTORISTS OF THE DRIVER'S INTENTIONS. THIS COULD CAUSE A VEHICLE CRASH WITHOUT WARNING.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Apr 29, 2003
ON CERTAIN PASSENGER VEHICLES, THE WINDOW LIFTING ANTI-PINCHING DEVICE MIGHT NOT FUNCTION PROPERLY.
Consequence & remedy
Consequence: OCCUPANTS COULD BE PINCHED BY A WINDOW THAT IS BEING CLOSED.
Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, REPLACE THE ELECTRONIC CONTROL UNIT FOR THE WINDOW LIFTING ANTI-PINCHING DEVICE. OWNER NOTIFICATION BEGAN MAY 27, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA09019 · Rear Lamp Illumination
Opened Dec 18, 2009 · Closed Sep 28, 2011
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Additional source detail variants (4)
Exterior Lighting
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:brake Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:tail Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
PE09036 · Rear Lamp Illumination
Opened Aug 7, 2009 · Closed Dec 22, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Additional source detail variants (4)
Exterior Lighting
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:brake Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:tail Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
DP09002 · Rear Lamp Illumination
Opened Apr 8, 2009 · Closed Aug 6, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Additional source detail variants (5)
Exterior Lighting:back Up Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:brake Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:tail Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Illustration