Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
125–50K
750–75K
775–100K
6100–150K
1150K+
23 reports with mileage · 23 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports4 fire reports2 injury reports
What owners actually said
46 reports
74,000 miles · Jun 25, 2007
Electrical System
DASH INDICATED TAILLIGHT WAS OUT WHEN IT WASN'T, THIS WAS RANDOM ON AND OFF FOR A FEW MONTHS. AFTER A FEW MONTHS THE DASH PANEL INDICATOR LIGHT STAYED ON. AS I WAS DRIVING ONE DAY I NOTICED THE SMELL OF SMOKE COMING FROM THE TRUNK. I STOPPED, AND NOTICED THE MELTED WIRES FROM THE TAIL LIGHT HARNESS. AS I LOOKED AT THEM I COULD …
Read full complaint
DASH INDICATED TAILLIGHT WAS OUT WHEN IT WASN'T, THIS WAS RANDOM ON AND OFF FOR A FEW MONTHS. AFTER A FEW MONTHS THE DASH PANEL INDICATOR LIGHT STAYED ON. AS I WAS DRIVING ONE DAY I NOTICED THE SMELL OF SMOKE COMING FROM THE TRUNK. I STOPPED, AND NOTICED THE MELTED WIRES FROM THE TAIL LIGHT HARNESS. AS I LOOKED AT THEM I COULD SEE THEM SPARKING WHEN CERTAIN MOVEMENTS OCCURRED., VERY DANGEROUSLY AND ERRATIC. BOTH MALE AND FEMALE SIDES MELTED. I HAVE NOTICED THE OTHER SIDE WAS BEGINNING TO HAVE THE SAME SYMPTOMS, RANDOM INDICATIONS OF A TAIL LIGHT OUT WHEN THERE WAS NONE. THIS WAS BROUGHT TO THE DEALERSHIPS ATTENTION , SAVAGE BMW, AS WELL AS BMWNA. I BROUGHT UP THE FACT THAT IT WAS A COMMON PROBLEM THAT SHOULD BE LOOKED INTO, AND THEY REFUSED TO COVER IT, AND DIDNT TAKE MUCH CONCERN INTO THE MATTER. THEY WERE E CHARGING ME $400+ TO FIX JUST THE ONE SIDE. *AK
NHTSA ODI #10194154
53,000 miles · Jun 8, 2007
Exterior Lighting
TL*THE CONTACT OWNS A 2002 BMW 330CI. THE CONTACT NOTICED THAT THE WARNING LIGHT ILLUMINATED, WHICH INDICATED THAT A TAIL LIGHT WAS NOT WORKING. HE REPLACED THE BULBS, HOWEVER, THE WARNING LIGHT REMAINED ILLUMINATED. THE CONTACT ALSO NOTICED THAT THE WIRING HARNESS PLUG WAS MELTED. THE DEALER HAS NOT INSPECTED THE VEHICLE. …
Read full complaint
TL*THE CONTACT OWNS A 2002 BMW 330CI. THE CONTACT NOTICED THAT THE WARNING LIGHT ILLUMINATED, WHICH INDICATED THAT A TAIL LIGHT WAS NOT WORKING. HE REPLACED THE BULBS, HOWEVER, THE WARNING LIGHT REMAINED ILLUMINATED. THE CONTACT ALSO NOTICED THAT THE WIRING HARNESS PLUG WAS MELTED. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE CURRENT MILEAGE IS 57,626 AND FAILURE MILEAGE WAS 53,000.
NHTSA ODI #10192762
61,000 miles · Jan 28, 2007
Electrical SystemFire
AFTER DRIVING MY 2002 BMW X 5 FIVE BLOCKS FROM MY HOME, I SMELLED SOMETHING BURNING AND PARKED THE CAR. FROM THE TIME IT TOOK ME TO GET OUT AND WALK TO THE REAR OF THE CAR, IT WAS FILLED WITH BLACK SMOKE AND IN SHORT ORDER THE CAR BURNED. MY INSURANCE COMPANY DECLARED IT A TOTAL LOSS AND HIRED AN INDEPENDENT PROFESSIONAL COMPANY…
Read full complaint
AFTER DRIVING MY 2002 BMW X 5 FIVE BLOCKS FROM MY HOME, I SMELLED SOMETHING BURNING AND PARKED THE CAR. FROM THE TIME IT TOOK ME TO GET OUT AND WALK TO THE REAR OF THE CAR, IT WAS FILLED WITH BLACK SMOKE AND IN SHORT ORDER THE CAR BURNED. MY INSURANCE COMPANY DECLARED IT A TOTAL LOSS AND HIRED AN INDEPENDENT PROFESSIONAL COMPANY THAT SPECIALIZES IN VEHICLE FIRES AND CAUSATION. THE CONCLUSSION OF THE REPORT WAS THAT IT WAS AN ELECTRICAL SHORT, ORIGINATING IN THE CENTER OF THE DASH. I HAVE SINCE RESEARCHED THIS SITUATION WITH BMW FIRES ON DIFFERENT WEB SIGHTS, INCLUDING ROADFLY, AND HAVE FOUND TO MY SHOCK, THERE ARE WAY TO MANY OTHER BMW OWNERS OUT THERE WITH A SIMULAR SITUATION. THIS IS AN EXTREMELY DANGEROUS PROBLEM THAT COULD CAUSE SOMEONES LIFE. IF MY GRANDCHILD OR ELDERLY MOTHER HAD BEEN IN THE CAR WITH ME, I WOULD NOT HAVE BEEN ABLE TO GET THEM OUT IN TIME! I APPRECIATE YOUR HELP. THANK YOU, HOPE PESSIS. *NM
NHTSA ODI #10180938
62,265 miles · Jan 15, 2007
Power Train
WHILE DRIVING ABOUT 30 MPH, CAR STOPPED AND WOULD NOT RESTART, TOWED TO SHOP, WAS TOLD I CHANGED FROM LOW RPM TO HIGH RPM CAUSING VALVE TO BEND. I WAS NOT DRIVING FAST AND THERE WAS NO REASON TO CHANGE FROM LOW RPM TO HIGH RPM THEY WOULD NOT WARRANTY A NEW ENGINE/VALVE/HEAD JOB. I HAD TO PAY FROM POCKET. *JB
NHTSA ODI #10178769
88,800 miles · Nov 19, 2006
Service Brakes, HydraulicCrash
STRUCK A VEHICLE IN FRONT OF ME. THE ABS DID NOT ENGAGE WHEN I TRIED TO STOP IN THE RAIN. THE VEHICLE IN FRONT OF ME DID NOT HAVE ANY DAMAGE BUT MY CAR HAD OVER $5700 WORTH OF DAMAGE. *NM
NHTSA ODI #10173822
Mileage unknown · Nov 5, 2006
Tires
OWN A 325CI COUPE THAT HAS HAD SEPARATION TIRE SEPARATION ON 3 TIRES BF GOODRICH 225/45R17. ONE TIRE SEPARATED ABOUT 3 WEEKS AGO ON THE VEHICLE AND THEN YESTERDAY TWO MORE TIRE SEPARATED. WHEN I REPLACED THIS TWO TIRES THE MECHANIC FOUND THAT THE OTHER REMAINING TIRE ON THE VEHICLE WAS DOING THE SAME THING. I WOULD LIKE TO KNOW…
Read full complaint
OWN A 325CI COUPE THAT HAS HAD SEPARATION TIRE SEPARATION ON 3 TIRES BF GOODRICH 225/45R17. ONE TIRE SEPARATED ABOUT 3 WEEKS AGO ON THE VEHICLE AND THEN YESTERDAY TWO MORE TIRE SEPARATED. WHEN I REPLACED THIS TWO TIRES THE MECHANIC FOUND THAT THE OTHER REMAINING TIRE ON THE VEHICLE WAS DOING THE SAME THING. I WOULD LIKE TO KNOW IF THERE HAS BEEN ANY RECALL OR OTHER COMPLAINTS ON THIS TIRE. *NM
BMW of North America, LLC (BMW) is recalling certain 2000-2005 323iT, 325iT, 325xiT, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323Ci, 325Ci, 328Ci, 330Ci, M3 Coupe, 323Cic, 325Cic, 330Cic, and M3 Convertible vehicles equipped with non-desiccated frontal Takata PSAN inflators and PSPI passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the passenger's front air bag, free of charge. The recall began February 13, 2020. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi Sedans, and 325xi and 325i Sportswagons, 2002-2006 330Ci, 325Ci, and M3 Convertibles and 325i, 330i, and M3 Coupes, 2002-2003 M5, 540i, 525i Sedan, and 530i Sedans, and 540i and 525i Sportswagons, and 2003 X5 3.0i and 4.4i Sports Activity Vehicles. Please note that the 5-series and X5 vehicles are only included if they are equipped with the optional sports steering wheel. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall began Aug 2016. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall supersedes recall 14V-348 in its entirety. Additionally, vehicles that have had their driver side frontal air bag replaced previously as part of a recall remedy need to have their air bag replaced under this recall as well. Note: On December 17, 2015 BMW removed the model year 2004 X5 3.0i and 4.4i Sports Activity vehicle from this recall. Those vehicles were mistakenly identified as including the air bags that are subject to this recall.
BMW is recalling certain model year 2002-2003 325i, 325xi, 330i, 330xi sedans; 325Ci and 330Ci coupes and convertibles; 325iT and 325xiT Sports Wagons; and M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW intends to issue initial notifications to owners informing them of the safety defect in June 2013. Once replacement parts are available, estimated for July, BMW will notify owners again to contact their dealers and schedule a replacement of the passenger air bag, free of charge. Owners may contact BMW customer service at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP09002 · Rear Lamp Illumination
Opened Apr 8, 2009 · Closed Aug 6, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Additional source detail variants (5)
Exterior Lighting:back Up Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:brake Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:tail Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
2002 BMW 330CI Problems, Complaints & Recalls | Skip That Year
Illustration