NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
194 reportsClear category filterMileage unknown · Dec 30, 2022
Engine
* What component failed: The VANOS gear bolts broken on the 2011 BMW 328i. *How was your safety put at risk? The car will suddenly stall during high speed driving that risk some car will hint from behind or high possibility of lost the control. The car stall and shaking very bad during high speed driving *Has the problem been co…
Read full complaint
* What component failed: The VANOS gear bolts broken on the 2011 BMW 328i. *How was your safety put at risk? The car will suddenly stall during high speed driving that risk some car will hint from behind or high possibility of lost the control. The car stall and shaking very bad during high speed driving *Has the problem been confirmed by dealer and independent service center. Yes. It was confirmed by dealer and independent service center. There are four broken bolts were discovered on the oil pan. The broken bolts were come from VANOS gear. *The vehicle has inspected by BMW dealer and independent service. *Check Engine light was on. No symptoms of the problem prior to the failure. After failure, the symptom is the car stalls during driving. The attached doc include the recall related to VANOS assembly bolts. However, the BMW refuse to take responsibility for recall my car to fix the problem and failed to notice me for the recall until the car failure due to this VANOS problem. I visited BMW dealer so many times and dealer is not notified me for this recall.
NHTSA ODI #11499538
Mileage unknown · Dec 13, 2022
Engine
.
NHTSA ODI #11497352
Mileage unknown · Nov 23, 2022
Electrical SystemEngine
This car has a heater problem with the PCV that causes the car to not run in cold weather. The PCV fails intermittently and the car will not idle or run in cold weather. BMW issued this recall in March but it is not November and they have offered no fix for this. It is a safety issue and it's also affecting how the car runs. How…
Read full complaint
This car has a heater problem with the PCV that causes the car to not run in cold weather. The PCV fails intermittently and the car will not idle or run in cold weather. BMW issued this recall in March but it is not November and they have offered no fix for this. It is a safety issue and it's also affecting how the car runs. How could we be 8 months into this without a fix?
NHTSA ODI #11494775
Mileage unknown · Nov 14, 2022
Engine
Recall was issued March 2022. The remedy is still not available.
NHTSA ODI #11493504
Mileage unknown · Nov 11, 2022
Engine
My 2011 328i convertible has the Vanos Cam shaft bolts broken, and the dealership never said anything about the recall for this issue. When I brought it to their attention they gave me a bill for $800 to find what I told them was wrong with the car. For the 10 years I had the car I have only use one dealership for repairs, and h…
Read full complaint
My 2011 328i convertible has the Vanos Cam shaft bolts broken, and the dealership never said anything about the recall for this issue. When I brought it to their attention they gave me a bill for $800 to find what I told them was wrong with the car. For the 10 years I had the car I have only use one dealership for repairs, and had an additional warranty on my vehicle and NOTHING was said about the bolt heads breaking off on the sprocket cam
NHTSA ODI #11493208
Mileage unknown · Oct 30, 2022
Engine
The Vanos Cam Tensioners bolts were a known issue (to back out and shear inside of the engine) in my car and a few years prior, and BMW recalled 150,000~ and gave 170,000~ vehicles a 10year unlimited mile warranty on the issue. My car had this issue a month ago and BMW would not help (a year out of the warranty with only 74,000 …
Read full complaint
The Vanos Cam Tensioners bolts were a known issue (to back out and shear inside of the engine) in my car and a few years prior, and BMW recalled 150,000~ and gave 170,000~ vehicles a 10year unlimited mile warranty on the issue. My car had this issue a month ago and BMW would not help (a year out of the warranty with only 74,000 miles). A BMW dealer diagnosed it and I got it repaired at an independent shop for $5,000+. I’ve seen other people have this issue after the warranty so obviously 10 years was not sufficient. This issue can lead to stalling while driving and rough running. Luckily, I heard the awful noise from my engine before it got worse and could’ve been catastrophic/dangerous. The car did not even have a CEL at the time. This can be a dangerous thing to happen and BMW did not fix all vehicles that were affected which is crazy to me, I also never got even a notice in my 2 1/2 years of ownership! Thank you guys for your time, I am hoping BMW will make this right, but I can’t believe such a large company would try and let something this serious go.
NHTSA ODI #11491520
Mileage unknown · Oct 24, 2022
Engine
The bolts for my VANOS adjuster unit failed at approximately 143,000 miles on my 2011 328i xDrive Wagon (chassis code E91). In 2014, BMW issued a recall (campaign No. 14V-176) for this exact issue. On the first page under the "Model" section, it is stated that the E91 chassis is affected. However, on the second page, the E91 ch…
Read full complaint
The bolts for my VANOS adjuster unit failed at approximately 143,000 miles on my 2011 328i xDrive Wagon (chassis code E91). In 2014, BMW issued a recall (campaign No. 14V-176) for this exact issue. On the first page under the "Model" section, it is stated that the E91 chassis is affected. However, on the second page, the E91 chassis is not listed under "Affected Vehicles". When checking the VIN number, my car does not have an open recall regarding this issue. However, the engine equipped in my car is also equipped in other models that are eligible for the recall, and my engine is clearly suffering from the exact failure described by the recall. I request the NHTSA to investigate why BMW did not include my model in this recall, and require BMW to issue the recall for my model.
NHTSA ODI #11490595
Mileage unknown · Oct 11, 2022
Engine
The VANOS adjustment unit develops an internal oil leakage that will no longer allow the VANOS to adjust quickly enough. This will result in activation of the engine emergency mode and the engine malfunction will become permanently active. BMW Service bulletin that is applicable: SI B11 07 14 Recall Campaign 14V-176 Documentat…
Read full complaint
The VANOS adjustment unit develops an internal oil leakage that will no longer allow the VANOS to adjust quickly enough. This will result in activation of the engine emergency mode and the engine malfunction will become permanently active. BMW Service bulletin that is applicable: SI B11 07 14 Recall Campaign 14V-176 Documentation was inspected by local BMW dealership. They denied the recall due to the VIN not being attached to the Service Bulletin and Recall Campaign. Background: My VIN has motor type N52K and vehicle production is April 2011. The vehicle was running rough and had developed an oil leak from the oil pan gasket. The current service bulletin it states: “Affected Vehicles: This recall involves certain E70, E71, E82, E88, E89, E90, E92, F10 and F25 vehicle’s with the N51, N52K and N52T engines produced from September 2009 to November 2011.”
NHTSA ODI #11488873
Mileage unknown · Sep 1, 2022
Electrical SystemEngineUnknown Or Other
There is a safety recall on my car. This recall involves an engine component known as the Positive Crankcase Ventilation (PCV) valve heater. The PCV valve heater may not have been produced to specifications which could lead to a short circuit. BMW DOES NOT HAVE AN AVAILABLE REMEDY FOR THIS RECALL AND DOES NOT HAVE ANY TIMELIN…
Read full complaint
There is a safety recall on my car. This recall involves an engine component known as the Positive Crankcase Ventilation (PCV) valve heater. The PCV valve heater may not have been produced to specifications which could lead to a short circuit. BMW DOES NOT HAVE AN AVAILABLE REMEDY FOR THIS RECALL AND DOES NOT HAVE ANY TIMELINE FOR FIXING IT.
NHTSA ODI #11482507
Mileage unknown · Aug 15, 2022
Engine
My 2011 BMW 328i turned off while i was at stop sign at top of the street. My children and I could of died! Car starts but keep shutting off. Smells like its also burning! No remedy available still. Now have no vehicle to drive!!!!!
NHTSA ODI #11479432
Official recalls
7Jul 3, 2024
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Air Bags:frontal
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 25, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
Consequence & remedy
Consequence: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.
Remedy: BMW will notify owners, and dealers will replace the wiring and electrical connectors, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact BMW customer service at 1-800-525-7417.
Apr 10, 2014
BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.
Consequence & remedy
Consequence: If the bolts loosen or break the engine may have reduced power or stall. An engine stall increases the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty to address this condition. The recall began on September 24, 2014. Owners may contact BMW at 1-800-525-7417.
Feb 7, 2013
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence & remedy
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Additional source detail variants (3)
Electrical System:wiring:fuses And Circuit Breakers
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical SYSTEM:12V/24V/48V Battery:cables
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical System
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Sep 15, 2011
BMW IS RECALLING CERTAIN MODEL YEAR 2011 328I XDRIVE AND 335I XDRIVE VEHICLES MANUFACTURED FROM FEBRUARY 8, 2011, THROUGH JULY 29, 2011. THE FRONT DRIVESHAFT ATTACHMENT BOLTS MAY NOT HAVE BEEN TIGHTENED TO SPECIFICATION. IF THE BOLTS WERE NOT TIGHTENED TO SPECIFICATION, THEY MAY BECOME LOOSE.
Consequence & remedy
Consequence: IF THE BOLTS LOOSEN, IT COULD LEAD TO A LOSS OF POWER TO THE FRONT WHEELS AND ULTIMATELY A VEHICLE BREAKDOWN, INCREASING THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE FRONT DRIVESHAFT ATTACHMENT BOLTS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration