2011 BMW 328I

The contact owns a 2011 BMW 328I. The contact stated that the headlights and taillights remained illuminated after the vehicle was turned off. Additionally, the vehicle intermittently failed to start up. The contact stated that AAA jump-started the vehicle, and it was determined that the battery was in good working condition. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact associated the failure to NHTSA Campaign Number: 17V676000 (Electrical System); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000.

Footwell module (FRM) module went out after negative battery disconnect to change fuse. Module being inoperable is causing windows to not operate,interior lighting not working, headlights stay dim (not good for nightime driving), blinkers inoperable (not good for driving with windows not working- no arm signals), dash light also inoperable.

The contact owns a 2011 BMW 328I. The contact stated that while attempting to start the vehicle, the electrical system failed to function as intended. The contact stated there was no warning light illuminated. The vehicle eventually started; however, the failure occurred. The vehicle was not diagnosed or repaired. The contact stated that the failure persisted. The manufacturer had been informed of the failure and transferred the contact to the NHTSA Hotline. The contact researched online and related the failure to NHTSA Campaign Number: 13V044000 (Electrical System); however, the VIN was not included. The failure mileage was approximately 116,000.

Previously reported on February 20, 2024. NHTSA #1157301 RDC failure caused complete loss of all dashboard functions except the radio - loss of lights/turn signals/ speedometer/ tachometer/ HVAC etc. Received a call from BMW customer service today February 26,2024 at 4:38 EST duration 17 minutes. BMW informed me the conversation was recorded. I request that NHTSA obtain the transcript for that telephone call. This note will be sent to BMW with request to send a transcript of the call to NHTSA. BMW Custom Relations representative was polite. Her purpose for the call - "to inform me that BMW is cooperating with NHTSA".The person assigned had no useful information nor could she obtain any information to answer questions. Though BMW documents all reported parts failures and complications, she had no ability to provide information relevant to the RDC module problems.The call was useless from an owners viewpoint. It did not improve Customer Relations. The VANOS recall was also discussed.NHTSA: #23V-707 Recall notification October 2023 BMW has not provided a date when the repair will be available. Vanos Bolt problems were identified for my vehicle in 2014!!! A 10 year warranty without mileage limitation was created but BMW owners were not notified - unless engine failure occurred and the car presented to a BMW dealership. I am more than frustrated that repairs have not been initiated. The local BMW dealership would like to repair the car but cannot proceed without corporate approval. Parts are indeed available locally. BMW has been aware of the problems for a DECADE. Furthermore, the valve cover gasket has been replaced twice since 2014. The VANOS bolts were never inspected. The valve cover was replaced last at 149,000 miles. A mechanic advised replacing the VANOS bolts but did not inspect them. Cost of repair $1500. I declined. Abysmal customer service!

Tire pressure yellow warning light on. RDC module ordered but repair not completed. After starting the car at a gas station, multiple warning lights appeared in red including "car on a raised lift in red" which signifies car is to be taken directly for service. Drove to local mechanic one mile away. While observing the car with engine running at idle, ALL dashboard lights and functions stopped: No speedometer, No tachometer, No warning lights, No turn signals, No headlights, RDC module subsequently replaced with resolution of the problem. Opening the old RDC module demonstrated significant green corrosion - likely occurred over a long period of time. IF the loss of all dashboard function had occurred while driving, it would have presented very dangerous safety issues. Situation reviewed with local BMW dealership and BMW corporate customer relations. No recalls or warnings have been issued. Expressed my concerns in detail. This is a potentially dangerous problem for the BMW E90 models. The RDC module is located in the passenger rear wheel well and repeatedly exposed to wet/ snow/ slush conditions. This is a dangerous location outside the vehicle for the RDC module. The Tire pressure monitor system is a non-critical function. Repair of the RDC module is considered optional - yellow warning light. This event demonstrates that there is a serious risk when the RDC module is not functioning properly. BMW should make owners aware and offer replacement before dangerous events occur.

While driving at city speed limit the headlights started flicking on-off very difficult to see in the dark. I pulled over to the side of the road for safety but now realized the turn signals not working and also the hazard lights are not working either. I was in a very dangerous situation sitting on the side of the road without any warning light on. Not only for mine safety but also dangerous for other drivers passing by without seen my car in the dark. Its due to well known BMW FOOTWELL MODULE that has high failure incidents rate but BMW refused not to do a recall. Since this a safety issue NHTSA should request BMW to do a recall instead of just extended the warranty to 10/150K miles which my car is not qualify for. I've contacted BMW customer care but they refused to offer any assistance. I feel that BMW has deserted their customer and leaving a high cost burden on their customers although failure/flaw was directly from BMW.

The Battery died and had to jump start to take it for a replacement. Once the car started, there was warning related to the lighting system malfunction. I couldnt open the windows and the lights were not functional. Even after the battery was replaced, the functions were not restored. Dealer is recommending replacement of FRM module costing $1250. I understand there was a recall/repair offered for 10 years which i just missed by a year. Looks like it is a well known issue and caused by a simple battery issue causing huge safety issues. I had to drive the car to the dealer without any lights/indicator with tremendous risks. It is an irony that they will fix this issue for only 10 years when there is a clear manufacturing defect and safety issue. Would like to get any help on this issue.