NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
65 reportsClear category filter89,000 miles · May 13, 2013
Engine
THE VEHICLE ENGINE SHUT-OFFS IN MOTION. THE FIRST OCCURRENCE, THE VEHICLE WAS GOING 15MPH & THE ENGINE FAILED WHILE TURNING INTO A BLOCK (RESIDENTIAL AREA), AFTER IDLING ROUGH AND HIGH PITCH NOISE COMING FROM THE ENGINE. THE 2ND OCCURRENCE, THE ENGINE FAILED AFTER EXITING THE FREEWAY. THAT TIME, THE VEHICLE WAS STOPPED ON A …
Read full complaint
THE VEHICLE ENGINE SHUT-OFFS IN MOTION. THE FIRST OCCURRENCE, THE VEHICLE WAS GOING 15MPH & THE ENGINE FAILED WHILE TURNING INTO A BLOCK (RESIDENTIAL AREA), AFTER IDLING ROUGH AND HIGH PITCH NOISE COMING FROM THE ENGINE. THE 2ND OCCURRENCE, THE ENGINE FAILED AFTER EXITING THE FREEWAY. THAT TIME, THE VEHICLE WAS STOPPED ON A HILL WHEN THE FAILURE OCCURRED. THE 3RD TIME, THE VEHICLE WAS AT A STOP WHEN THE ENGINE FAILED. ONCE THE FAILURE OCCURRED, THE VEHICLE WAS PLACE IN PARK MODE & RE-STARTED. THE ENGINE STARTED AGAIN & THE VEHICLE WAS DRIVEN HOME. NOTE: SINCE JANUARY 2012, THE VEHICLE HAS BEEN TO THE BMW SERVICE DEPARTMENT SEVERAL TIMES FOR IDLING ROUGH AND HIGH PITCH NOISE FROM ENGINE COMPLAINTS. THE ISSUE NOW HAS PROGRESS TO ENGINE FAILURE IN MOTION. *TR
NHTSA ODI #10511714
54,000 miles · Mar 1, 2013
Engine
TL* THE CONTACT OWNS A 2007 BMW 328I. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED. AFTER A FEW MINUTES, THE VEHICLE STARTED AND OPERATED AS DESIGNED. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED ONCE BEFORE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED NO …
Read full complaint
TL* THE CONTACT OWNS A 2007 BMW 328I. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED. AFTER A FEW MINUTES, THE VEHICLE STARTED AND OPERATED AS DESIGNED. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED ONCE BEFORE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED NO CAUSE FOR FAILURE COULD BE FOUND. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE 54,000.
NHTSA ODI #10500910
57,000 miles · Feb 19, 2013
Engine
I TRIED STARTING MY CAR AND IT WOULD NOT START. FIGURED IT WAS A DEAD BATTERY SO I BOUGHT A NEW ONE AND HAD IT REPLACED. THE CAR WORKED FINE FOR ABOUT 3 DAYS THEN HAD THE SAME PROBLEM AS BEFORE. I CONTACTED THE DEALER, HAD TO HAVE THE CAR TOWED TO THEM, AND WAS TOLD THAT IT WAS THE CONNECTIONS FROM THE BATTERY TO THE ENGINE THAT…
Read full complaint
I TRIED STARTING MY CAR AND IT WOULD NOT START. FIGURED IT WAS A DEAD BATTERY SO I BOUGHT A NEW ONE AND HAD IT REPLACED. THE CAR WORKED FINE FOR ABOUT 3 DAYS THEN HAD THE SAME PROBLEM AS BEFORE. I CONTACTED THE DEALER, HAD TO HAVE THE CAR TOWED TO THEM, AND WAS TOLD THAT IT WAS THE CONNECTIONS FROM THE BATTERY TO THE ENGINE THAT WERE LOOSE AND CAUSING THE CAR TO NOT START. I PICKED UP MY CAR THE NEXT DAY AFTER PAYING $120 TO HAVE THE PROBLEM (WIGGLING SOME WIRES) FIXED. 2 DAYS LATER...SAME PROBLEM. IT HAS BEEN SITTING NOW FOR OVER 2 WEEKS BECAUSE I HAVEN'T HAD TIME TO KEEP GETTING IT TO AND FROM THE DEALERSHIP. AFTER READING ALL OF THESE OTHER REPORTED PROBLEMS I AM NOW TERRIFIED TO DRIVE IT EVER AGAIN. *TR
NHTSA ODI #10498568
48,385 miles · Jul 9, 2012
EngineSteering
VEHICLE WILL NOT START, REPLACED BATTERY AND ICON DISPLAYING ELECTRIC STEERING LOCK (ELV) SHOWS IN THE DASHBOARD. VEHICLE WILL NOT START AS STEERING WHEEL IS LOCKED AND CAN NOT BE RELEASED DEALER SAYS THE STEERING WHEEL COLUMN NEEDS TO BE REPLACED. THIS IS AN EXTREMELY COMMON PROBLEM WITH THESE CARS, DEALER SAID THE SEE ABOUT…
Read full complaint
VEHICLE WILL NOT START, REPLACED BATTERY AND ICON DISPLAYING ELECTRIC STEERING LOCK (ELV) SHOWS IN THE DASHBOARD. VEHICLE WILL NOT START AS STEERING WHEEL IS LOCKED AND CAN NOT BE RELEASED DEALER SAYS THE STEERING WHEEL COLUMN NEEDS TO BE REPLACED. THIS IS AN EXTREMELY COMMON PROBLEM WITH THESE CARS, DEALER SAID THE SEE ABOUT 3 CARS A WEEK WITH THIS PROBLEM. *TR
NHTSA ODI #10464753
70,000 miles · Jun 29, 2012
Engine
TL* THE CONTACT OWNS A 2007 BMW 328I. THE CONTACT STATED THAT THE VEHICLE WOULD STALL SPORADICALLY. THE COOLANT WARNING LIGHT WOULD ILLUMINATE AFTER THE FAILURE. THE CONTACT TOOK THE VEHICLE TO THE DEALER BUT WAS INFORMED THAT THERE WERE NO FAILURES FOUND WITHIN THE VEHICLE. THE DEALER AND MANUFACTURER WAS NOT NOTIFIED. THE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2007 BMW 328I. THE CONTACT STATED THAT THE VEHICLE WOULD STALL SPORADICALLY. THE COOLANT WARNING LIGHT WOULD ILLUMINATE AFTER THE FAILURE. THE CONTACT TOOK THE VEHICLE TO THE DEALER BUT WAS INFORMED THAT THERE WERE NO FAILURES FOUND WITHIN THE VEHICLE. THE DEALER AND MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 70,000.
NHTSA ODI #10463528
Official recalls
6Jul 3, 2024
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Air Bags:frontal
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 25, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
Consequence & remedy
Consequence: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.
Remedy: BMW will notify owners, and dealers will replace the wiring and electrical connectors, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact BMW customer service at 1-800-525-7417.
Nov 12, 2013
BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, model year 2007 328i, 328xi, 335i, 335xi sedans and 328i and 328xi sports wagons, model year 2006-2007 525i, 525xi, 530i, 530xi, 550i sedans and 530xi sports wagons, model year 2006 760i sedans, model year 2006-2007 750i, 750Li, and 760Li sedans, and model year 2006 X5 sports activity vehicles, equipped with certain seat types. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners with an interim notification letter in January 2014 since parts are not currently available. When parts are available, BMW sent a second letter in August and dealers will repair the occupant detection mat to eliminate the possibility that it may crack, free of charge. Additionally, owners of model year 2006-2007 3 Series with standard seats, 5 Series with comfort seats, and Z4 models, will receive an extended warranty on their front passenger seat occupant detection mat. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Feb 7, 2013
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence & remedy
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Additional source detail variants (3)
Electrical System:wiring:fuses And Circuit Breakers
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical SYSTEM:12V/24V/48V Battery:cables
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical System
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration