Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
Electrical SystemElectronic Stability Control (esc)Steering
NOTICED A VERY SLIGHT TAPPING WHEN THE CAR WAS FIRST CRANKED--BUT NO ENGINE WARNING LIGHTS. AFTER DRIVING IT FOR A FEW MILES, A WARNING LIGHT INDICATING "CHARGING MALFUNCTION" FLASHED ON, AND THE BATTERY SYMBOL APPEARED. BECAUSE I WAS THE PASSENGER, I GOOGLED "BMW 328I CHARGING MALFUNCTION" AND THE FIRST RESULT THAT CAME UP RE…
Read full complaint
NOTICED A VERY SLIGHT TAPPING WHEN THE CAR WAS FIRST CRANKED--BUT NO ENGINE WARNING LIGHTS. AFTER DRIVING IT FOR A FEW MILES, A WARNING LIGHT INDICATING "CHARGING MALFUNCTION" FLASHED ON, AND THE BATTERY SYMBOL APPEARED. BECAUSE I WAS THE PASSENGER, I GOOGLED "BMW 328I CHARGING MALFUNCTION" AND THE FIRST RESULT THAT CAME UP READ "BMW/ JANUARY 2013/ RECALL CAMPAIGN NO. 12V-550: ENGINE BELT IDLER PULLEY BOLT" FOR MYS 2009-2012 BMW X5 XDRIVE 35S SAVS. BEFORE I COULD INFORM DRIVER, HE COMPLAINED THAT HE HAD LOST POWER STEERING. AS WE WERE LITERALLY YARDS FROM OUR DESTINATION, WE PARKED, AND RETURNED TO THE CAR TWO HOURS LATER. WHEN WE RECRANKED THE CAR, SAME WARNINGS. WE DECIDED TO DRIVE TO LOCAL BMW SERVICE STATION. AT A STOP LIGHT A FEW MILES FURTHER, MANY WARNING LIGHTS TURNED ON SIMULTANEOUSLY, THE WINDSHIELD WIPERS TURNED ON, BUT THE PANEL SAID IT WAS STILL DRIVABLE AND NEEDED SERVICE SOON. WHEN THE LIGHT CHANGED, THE PANEL WENT OFF, AND THE CAR WAS STOPPED DEAD IN THE MIDDLE OF A MAJOR ROAD. PUSHED IT TO THE SIDE OF THE ROAD TO FIND THE BOLT BROKEN AND THE PULLEY AND BELT LOOSE. UPON HAVING IT TOWED TO BMW REPAIR, WE WERE TOLD THE A/C COMPRESSOR W/CLUTCH, BELT TENSIONER AND BELT, AND OIL FILTER HOUSING GASKET NEEDED TO BE REPLACED TO THE TUNE OF ABOUT $5090. (CAR HAD BEEN GIVEN A CLEAN BILL OF HEALTH DURING LAST OIL CHANGE, AND THE A/C WAS WORKING WELL EARLIER THAT MORNING.) WONDERING WHY THE EBIP BOLT WAS RECALLED IN SO MANY OTHER BMW MODELS THAT YEAR BUT NOT IN OURS. INFORMATION CONTAINED IN THEIR RECALL NOTIFICATION EXACTLY MATCHED THE DESCRIPTION OF OUR PROBLEM.
BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
Remedy: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Defect investigations
0
No exact-year investigations in this snapshot.
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration