1989 Blue Bird TC2000

Consequence: IN THE EVENT OF A FRONTAL CRASH, THE REAR ATTACHING BOLT OF THESE SEATS COULD PULL OUT OF THE SEAT LEDGE INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.

Remedy: BLUE BIRD WILL FURNISH TO DISTRIBUTORS AND OWNERS, PARTS AND INSTRUCTIONS NECESSARY TO STRENGTHEN THE PASSENGER SEAT ATTACHMENT AT THE WALL SIDE.

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE FUEL TANK COULD BE DAMAGED, LEAKING FUEL, POSSIBLY RESULTING IN A VEHICLE FIRE.

Remedy: BLUE BIRD WILL SHIP INSTRUCTIONS AND MODIFICATION KITS TO THE OWNERS OF THESE BUSES.

Consequence: WHEN A PASSENGER'S CLOTHING BECOMES CAUGHT IN THE HANDRAIL, AND THE BUS DRIVER CLOSES THE DOOR AND PUTS THE VEHICLE IN MOTION, THE INDIVIDUAL IS SUBJECT TO BEING DRAGGED BY THE BUS. THIS CAN RESULT IN SERIOUS INJURY OR DEATH.

Remedy: OWNERS WILL BE DIRECTED TO REMOVE ALL FORWARD HANDRAILS. PROVISIONS WILL BE MADE FOR THOSE OWNERS OPERATING IN STATES WHICH MANDATE A FORWARD HANDRAIL THAT A REPLACEMENT HANDRAIL WILL BE PROVIDED.

Consequence: THESE PLATES CAN DROP TO THE ROADWAY BECOMING A HAZARD TO FOLLOWING VEHICLES INCREASING THE POTENTIAL FOR AN ACCIDENT.

Remedy: DEALERS WILL INSTALL A MECHANICAL RETAINING DEVICE WHICH CLAMPS THE PLATES TOGETHER AND FASTENED WITH THREADED FASTENERS. BUS OWNERS WILL HAVE THE OPTION OF REPAIRING THEIR OWN VEHICLES.

Consequence: WHEN A PASSENGER'S CLOTHING BECOMES CAUGHT IN THE HANDRAIL, AND THE BUS DRIVER CLOSES THE DOOR AND PUTS THE VEHICLE IN MOTION,THE INDIVIDUAL IS SUBJECT TO BEING DRAGGED BY THE BUS. THIS CAN RESULT INSERIOUS INJURY OR DEATH.

Remedy: DEALERS WILL INSTALL A SET SCREW TO THE METAL CLAMP WHICH RETAINS THE INTERMEDIATE HANDRAIL. A HIGH IMPACT MOLDED PLASTIC "CLAM SHELL" WILL BE PLACED OVER EACH END OF THE INTERMEDIATE HANDRAIL COMPLETELY COVERING THE CLAMP AND ELIMINATING ALL CATCH-POINTS. THE FLANGE OF THE EXISTING FLOOR LINE BRACKET WILL BE CRIMPED SECURING THE VERTICAL SECTION OF THE PRIMARY TUBLAR HANDRAIL AT THE FLOOR LINE.

Consequence: WHEN A PASSENGER'S CLOTHING BECOMES CAUGHT IN THEHANDRAIL, AND THE BUS DRIVER CLOSES THE DOOR AND PUTS THE VEHICLE IN MOTION, THEINDIVIDUAL IS SUBJECT TO BEING DRAGGED BY THE BUS. THIS CAN RESULT IN SERIOUSINJURY OR DEATH.

Remedy: REPLACE OR REPOSITION THE HANDRAILS TO STOP CLOTHING FROM BECOMING CAUGHT.

Consequence: THE DISENGAGED DOOR LOCK ALLOWS THE DOOR TO OPEN WITHOUTPRIOR WARNING AND ENDANGER OCCUPANTS NEAR THE DOOR IF THE VEHICLE IS IN MOTION.

Remedy: MODIFY THE VANDAL DOOR LOCKS WITH BLUE BIRD SUPPLIED KITS.

Consequence: IN THE EVENT OF A MAJOR SHORT-CIRCUIT, INADEQUATE CIRCUITPROTECTION COULD RESULT IN A FIRE IN THE REAR ENGINE COMPARTMENT.

Remedy: THE STANDARD EQUIPMENT CIRCUIT MUST BE REMOVED.

Consequence: A SHORT COULD RESULT IN HEADLIGHT LOSS WHICH PRESENTS APOTENTIAL FOR AN ACCIDENT.

Remedy: REPLACE DIMMER SWITCH WITH NEW 14 GAUGE WIRE WITH PROPERLY CRIMPED CONNECTIONS.

Consequence: THIS COULD CAUSE LOSS OF STEERING CONTROL THAT COULDRESULT IN AN ACCIDENT.

Remedy: REPAIR USING A POSITIVE LOCKING METHOD.

Consequence: THIS WOULD CAUSE THE BRAKE BOOSTER TO SELF-APPLY AND RESULT IN FULL BRAKE APPLICATION, WITHOUT WARNING, WHICH COULD RESULT IN AN ACCIDENT.

Remedy: REPLACE HYDRAULIC BRAKE BOOSTER.

Consequence: FUEL SPILLAGE DURING AND AFTER A CRASH, IN EXCESS OF LIMIT ALLOWED BY FMVSS 301, COULD CAUSE A FIRE NEAR A SOURCE OF IGNITION.

Remedy: RELOCATE FUEL FILTER - SEPARATOR TO ELIMINATE INTERFERENCE WITH CROSSMEMBER IN ANY CRASH.

Consequence: THIS COULD CAUSE LOSS OF BUS BRAKING CONTROL AND RESULTIN AN ACCIDENT.

Remedy: REPLACE DEFECTIVE BRAKE DRUMS.

Consequence: THIS COULD ADVERSELY AFFECT STEERING CONTROL WITHPOTENTIAL FOR AN ACCIDENT.

Remedy: TORQUE RETAINING NUT TO SPECIFICATION AND APPLY LOCKTITE.