IllustrationTOOK IN FOR 70K SERVICE BECAUSE OF LOSS OF POWER AND WAS NOTIFIED TURBOS WERE BAD, HAD BOTH TURBOS REPLACED ALONG WITH LINES.
2013 Audi S6
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all S6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
425–50K
2050–75K
375–100K
2100–150K
0150K+
30 reports with mileage · 12 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports0 injury reports
Engine complaints
33 reportsAFTER DRIVING THE VEHICLE UNDER NORMAL DRIVING CONDITIONS, I ARRIVED AT MY DESTINATION AND WITHOUT ANY WARNING OR DASH LIGHTS THE VEHICLE SHUT OFF ROUGHLY. SINCE IT SOUNDED WEIRD, I TRIED STARTING THE VEHICLE BACK UP AGAIN. THE ENGINE WOULD CRANK BUT WOULDN'T START. THE VEHICLE WAS INSPECTED BY A VOLKSWAGEN DEALERSHIP WHERE IT W…
Read full complaint
AFTER DRIVING THE VEHICLE UNDER NORMAL DRIVING CONDITIONS, I ARRIVED AT MY DESTINATION AND WITHOUT ANY WARNING OR DASH LIGHTS THE VEHICLE SHUT OFF ROUGHLY. SINCE IT SOUNDED WEIRD, I TRIED STARTING THE VEHICLE BACK UP AGAIN. THE ENGINE WOULD CRANK BUT WOULDN'T START. THE VEHICLE WAS INSPECTED BY A VOLKSWAGEN DEALERSHIP WHERE IT WAS DETERMINED ONE OF THE TWO TURBOCHARGERS HAD FAILED. THE PASSENGER SIDE TURBINE WHEEL WAS BROKEN AND THE DRIVER SIDE TURBO WAS SHOWING SIGNS OF THE TURBINE WHEEL CATCHING THE HOUSING. BOTH TURBOS WERE REPLACED ALONG WITH THE TURBO OIL SCREEN.
WHILE DRIVING VEHICLE STALLED ON CRAIG AND CLAYTON STREET HAD TO GET IT TOWED WAS TOLD WAS LACK OF OIL TO TURBOS AND TURBOS BLEW
HAVING JUST EXITED THE INTERSTATE AND STOPPED AT THE END OF THE EXIT RAMP, MY 2013 AUDI S6 STARTED TO STALL AS I WAS TURNING ONTO A SECONDARY ROAD. I MANAGED TO PULL THE CAR OVER TO THE SIDE OF THE ROAD BEFORE I LOST ALL FORWARD POWER, AVOIDING TRAFFIC IN MOTION IN PROXIMITY TO MY VEHICLE. THE CAR WOULD NOT RESTART AFTER A CHECK…
Read full complaint
HAVING JUST EXITED THE INTERSTATE AND STOPPED AT THE END OF THE EXIT RAMP, MY 2013 AUDI S6 STARTED TO STALL AS I WAS TURNING ONTO A SECONDARY ROAD. I MANAGED TO PULL THE CAR OVER TO THE SIDE OF THE ROAD BEFORE I LOST ALL FORWARD POWER, AVOIDING TRAFFIC IN MOTION IN PROXIMITY TO MY VEHICLE. THE CAR WOULD NOT RESTART AFTER A CHECK TO INSURE THINGS SUCH AS A PROPER AMOUNT OF FUEL WAS IN THE GAS TANK. AFTER REPEATED ATTEMPTS AT STARTING THE CAR FAILED, I HAD THE S6 FLAT BEDDED TO THE NEAREST AUDI DEALER FOR REPAIR. I SPOKE TO THE DEALERSHIP SEVERAL DAYS AFTER THE INCIDENT AND THEY DIAGNOSED THE PROBLEM AS TWO FAILED TURBOCHARGERS. THE FAILURE WAS ATTRIBUTED TO THE TURBOCHARGER OIL SCREEN CLOGGING PROBLEM. I WAS TOLD THE REPLACEMENT (PARTS + LABOR) WOULD BE IN THE $12,000+ RANGE. I AUTHORIZED THE OUT OF WARRANTY REPAIR AS THE CAR WAS IN EXCELLENT AND WELL MAINTAINED CONDITION AND I WAS NOT READY TO SCRAP IT. THE DEALER SEVERAL DAYS LATER INFORMED ME THAT AUDI CORPORATE HAD REVIEWED THE FAILURE AND WAS WILLING TO ABSORB 75% OF THE ESTIMATED REPAIR BILL AS THE S6 HAD JUST COME OUT OF WARRANTY AND HAD BEEN PROPERLY DEALER MAINTAINED. SEVERAL WEEKS LATER I WAS ABLE TO PICK UP THE CAR WITH A PAYMENT DUE FOR REPAIRS (AFTER AUDI 75% COVERAGE) OF $2674.26 WITH THE NEW TURBOS INSTALLED AND THE S6 WAS NOW RUNNING PROPERLY AGAIN. I NOW HESITATE TO USE THE CAR FOR ANY LONG TRIPS ON THE HIGHWAY DUE TO CONCERN I MAY HAVE A RECURRENCE OF THIS TURBO FAILURE EVEN THOUGH THE CAR IS BEING DEALER SERVICED PROPERLY AT THE SUGGESTED INTERVALS. FURTHER, I BELIEVE THIS INHERENT PROBLEM HAS DIMINISHED THE RESALE OR TRADE-IN VALUE OF THIS 2013 AUDI S6. I WAS FORCED TO RENT A CAR FOR SEVERAL DAYS TO RETURN HOME AFTER THIS FAILURE WHICH IN TOTAL COST WAS $500+.
ENGINE SHUT DOWN WHILE ON FREEWAY AT 60MPH SPEED DUE TO TURBO FAILURE. 60,000 MILES ON ENGINE. ISSUE CAUSED BY OIL PICKUP SCREEN BEING CLOGGED AND STARVED THE TURBOS FROM OIL, THUS RESULTED IN FAILURE AND ENGINE SHUT DOWN.
THE TURBOS ON THE S6 FAILED AFTER ONLY 50,000 MILES. THIS MAKES THE CAR HAVE DANGEROUSLY LOW POWER AND NEARLY UNDRIVEABLE. THIS IS AN EXTREMELY COMMON OCCURRENCE FOR AUDI 4.0TT MODELS, AND AUDI EVEN ISSUED A TSB REGARDING THE ISSUE TO IT'S SERVICE CENTERS. BUT TO DATE, AUDI HAS NOT RECTIFIED THE ISSUE OR MADE CONTACT WITH TH…
Read full complaint
THE TURBOS ON THE S6 FAILED AFTER ONLY 50,000 MILES. THIS MAKES THE CAR HAVE DANGEROUSLY LOW POWER AND NEARLY UNDRIVEABLE. THIS IS AN EXTREMELY COMMON OCCURRENCE FOR AUDI 4.0TT MODELS, AND AUDI EVEN ISSUED A TSB REGARDING THE ISSUE TO IT'S SERVICE CENTERS. BUT TO DATE, AUDI HAS NOT RECTIFIED THE ISSUE OR MADE CONTACT WITH THOSE WHO ARE OUT OF THE WARRANTY PERIOD. BLOWN TURBOS CAUSE ALL SORTS OF ISSUES, INCLUDING POTENTIAL ENGINE DAMAGE, CYLINDER MISFIRES, FUEL PRESSURE ISSUES, AND OVER-HEATING. ON MY PARTICULAR VEHICLE, THE TURBOS FAILED SIMPLY BY STARTING THE CAR AFTER SITTING IN THE GARAGE FOR A FEW DAYS, UNDRIVEN. COST TO REPLACE TURBOS AND MAKE REPAIRS IS $10,000 TO $15,000.
MY TURBOCHARGERS FAILED, WHICH I UNDERSTAND IS NOT UNCOMMON WITH THIS ENGINE. IT WAS DRIVING NORMALLY. I STOPPED FOR AN ERRAND AND IT RESTARTED WITH GREAT DIFFICULTY. I THEN DROVE SOME ADDITIONAL DISTANCE AND IT STALLED IN TRAFFIC. IT STALLED REPEATEDLY WHENEVER THE RPM'S FELL BELOW 2000. I ENDED UP RUNNING A RED LIGHT, TO AVOID…
Read full complaint
MY TURBOCHARGERS FAILED, WHICH I UNDERSTAND IS NOT UNCOMMON WITH THIS ENGINE. IT WAS DRIVING NORMALLY. I STOPPED FOR AN ERRAND AND IT RESTARTED WITH GREAT DIFFICULTY. I THEN DROVE SOME ADDITIONAL DISTANCE AND IT STALLED IN TRAFFIC. IT STALLED REPEATEDLY WHENEVER THE RPM'S FELL BELOW 2000. I ENDED UP RUNNING A RED LIGHT, TO AVOID SLOWING DOWN, KNOWING IT WOULD STALL. FORTUNATELY, I WAS IN AN UNCROWDED AREA. IT LOOKS LIKE AUDI HAS ALREADY ISSUED A TECHNICAL SERVICE BULLETIN REGARDING THE PROPENSITY FOR TURBO FAILURE. I WOULD LIKE TO SEE MORE THAN THAT HAPPEN.
SUSPENSION CONTROL ARM BUSHINGS WORN OUT CAUSING SQUEAKING AND UNEXPECTED VEHICLE PATH DURING ACCELERATION IN ALL SITUATIONS. OIL FILTER UNDER PVC VALVE CLOGGED AND STARVED TURBOCHARGER OF OIL CAUSING FAILURE.
THE TURBOS ON THE CAR BOTH BROKE AT THE INTERMEDIATE SHAFT BEFORE 75,000 MILES. THE CAR WAS CRUISING ON THE FREEWAY, AND THE MOMENT I SLOWED DOWN TO TAKE THE EXIT, THE CAR LOST POWER AND SHUT DOWN. I HAD TO MAKE AN EMERGENCY STOP ON THE SIDE OF THE EXIT WITH LITTLE TO NO ROOM TO PULL OVER.
TURBOS ARE DAMAGED AND THE DEALER SAID IT WILL COST $13,000.00 TO FIX I HAD WARRANTEE TILL 120K OR 7 YEARS AND IT HAPPENED AT 7 YEARS ONE MONTH AND 116,000 MILES. AUDI OF AMERICA WHERE NOT WILLING TO HELP EVEN THOUGH THERE WAS GRINDING THAT OCCURED TWO MONTHS BEFORE THE WARRANTEE TIME. IT HAPPENED WHEN IN MOTION DRIVING FROM …
Read full complaint
TURBOS ARE DAMAGED AND THE DEALER SAID IT WILL COST $13,000.00 TO FIX I HAD WARRANTEE TILL 120K OR 7 YEARS AND IT HAPPENED AT 7 YEARS ONE MONTH AND 116,000 MILES. AUDI OF AMERICA WHERE NOT WILLING TO HELP EVEN THOUGH THERE WAS GRINDING THAT OCCURED TWO MONTHS BEFORE THE WARRANTEE TIME. IT HAPPENED WHEN IN MOTION DRIVING FROM STARTUP.
Official recalls
322V178000 · Engine And Engine Cooling:engine:gasoline:turbo/supercharger
Mar 23, 2022
Volkswagen Group of America, Inc. (Audi) is recalling certain 2013-2017 A8, S6 Sedan, S7, S8, and 2014-2017 RS7 vehicles. The turbocharger oil supply strainer can become blocked, causing wear to the bearings due to lack of lubrication.
Consequence & remedy
Consequence: Worn bearings can cause the turbine wheel to contact the turbocharger housing or cause the shaft to break, causing an engine stall and increasing the risk of a crash.
Remedy: Dealers will replace the oil strainer and perform an oil change, free of charge. Owner notification letters were mailed August 4, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 21H7.
18V370000 · Air Bags:sensor:occupant Classification
Jun 4, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2018 Audi S6 and S7, 2012-2018 A7 and A6 Sedan, and 2014-2018 RS7 vehicles equipped with basic seats (with or without heating). Stress or wear of the body-sensing mat within the front passenger seat may cause the Passenger Occupant Detection System (PODS) control module to malfunction.
Consequence & remedy
Consequence: If the PODS module malfunctions, the front passenger air bag may not deploy properly in the event of a crash, increasing the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will install a PODS system repair kit, free of charge. The recall began November 29, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 74D5.
13V450000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Sep 23, 2013
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2013-2014 Audi S6 and S7 vehicles equipped with 4.0L engines. Due to manufacturing tolerance issues, a fuel line may leak fuel.
Consequence & remedy
Consequence: A fuel leak, in the presence of an ignition source, may result in a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel line, free of charge. The safety recall is planned to begin in late October 2013. Owners may contact Audi of America at 1-800-822-2834. Volkswagen's number for this campaign is 20U6/L8.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA22001 · Engine Stall - Turbo Failure
Opened Apr 4, 2022 · Closed May 26, 2023
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:oil/lubrication:filter/screen
On March 29, 2021, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE 21-009) after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7 equipped with the 4.0L, twin-turbocharged engine. Complainants reported the vehicles would stall with no warning while driving at highway or city traffic speeds. Several of the complainants alleged an inability to restart. The complaints alleged the major contributing factor to the engine stalling was the failure of the turbochargers. The complaints cited the turbocharger failure was a result of oil starvation due to a clogged oil strainer in the turbocharger oil supply line.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making servicing the component difficult. The oil strainer removes particles and carbon deposits from the oil before lubricating the turbochargers. Over time, if the debris is not removed from the oil strainer, it becomes clogged and prevents oil from flowing to the turbochargers. This causes the turbine bushings to run dry and overheat resulting in turbine shaft failure due to thermal stress.On April 04, 2022, PE21-009 was upgraded to an Engineering Analysis (EA22-001) to further assess the scope, frequency, and potential safety related consequences of the alleged defect. Volkswagen filed recall 22V-178 to replace the 30?m mesh oil strainer with a 90?m mesh oil strainer in the subject vehicles. VW introduced the larger mesh oil strainer into production in March of 2017 effecting the 2017-2018MY vehicles.ODI reviewed information from VW for vehicles that had the larger mesh installed in production. The data received showed, since the new oil strainer size of 90?m went into production for the 2017-2018MY, there has not been any reported incidents of turbocharger failures due to oil starvation or other failures that could be related to the larger screen mesh. In view of the recall being conducted by VW and lack of any detrimental side effect to the turbocharger caused by the larger mesh, ODI is closing this Engineering Analysis (EA). The agency reserves the right to take additional action if warranted by future circumstances.11502847,11506565,11494663,11488813,11486393,11480926,11479882,11476289,11466761 11464663,11463254,11460580,11460496,11458973,11458804,11457556,11454753,11452668 11452589,11452584,11452383,11452175,11452111,11451724,11451724,11450995,11450988 11449661,11447092,11443657,11442867,11440536,11440052,11439959,11438691,11436461 11435619,11433925,11433733,11432336,11431661,11431421,11429704,11429584,11428128 11426929,11424203,11423603,11423337,11422431,11421084,11420626,11420342,11419693 11418884,11418437,11418433,11418135,11417635,11417351,11416095,11414578,11414235 11414064,11413359,11413285,11413214,11407510,11407450,11406897,11406821,11406637 11406460,11406416,11406291,11406287,11406277,11406273,11406263,11406256,11406251 11406229,11406222,11406208,11406204,11406197,11406182,11406015,11404665,11404426 11404348,11403823,11403430,11403268,11402684,11399435,11397821,11396241,11394763 11391037
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
On March 29, 2021, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE 21-009) after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7 equipped with the 4.0L, twin-turbocharged engine. Complainants reported the vehicles would stall with no warning while driving at highway or city traffic speeds. Several of the complainants alleged an inability to restart. The complaints alleged the major contributing factor to the engine stalling was the failure of the turbochargers. The complaints cited the turbocharger failure was a result of oil starvation due to a clogged oil strainer in the turbocharger oil supply line.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making servicing the component difficult. The oil strainer removes particles and carbon deposits from the oil before lubricating the turbochargers. Over time, if the debris is not removed from the oil strainer, it becomes clogged and prevents oil from flowing to the turbochargers. This causes the turbine bushings to run dry and overheat resulting in turbine shaft failure due to thermal stress.On April 04, 2022, PE21-009 was upgraded to an Engineering Analysis (EA22-001) to further assess the scope, frequency, and potential safety related consequences of the alleged defect. Volkswagen filed recall 22V-178 to replace the 30?m mesh oil strainer with a 90?m mesh oil strainer in the subject vehicles. VW introduced the larger mesh oil strainer into production in March of 2017 effecting the 2017-2018MY vehicles.ODI reviewed information from VW for vehicles that had the larger mesh installed in production. The data received showed, since the new oil strainer size of 90?m went into production for the 2017-2018MY, there has not been any reported incidents of turbocharger failures due to oil starvation or other failures that could be related to the larger screen mesh. In view of the recall being conducted by VW and lack of any detrimental side effect to the turbocharger caused by the larger mesh, ODI is closing this Engineering Analysis (EA). The agency reserves the right to take additional action if warranted by future circumstances.11502847,11506565,11494663,11488813,11486393,11480926,11479882,11476289,11466761 11464663,11463254,11460580,11460496,11458973,11458804,11457556,11454753,11452668 11452589,11452584,11452383,11452175,11452111,11451724,11451724,11450995,11450988 11449661,11447092,11443657,11442867,11440536,11440052,11439959,11438691,11436461 11435619,11433925,11433733,11432336,11431661,11431421,11429704,11429584,11428128 11426929,11424203,11423603,11423337,11422431,11421084,11420626,11420342,11419693 11418884,11418437,11418433,11418135,11417635,11417351,11416095,11414578,11414235 11414064,11413359,11413285,11413214,11407510,11407450,11406897,11406821,11406637 11406460,11406416,11406291,11406287,11406277,11406273,11406263,11406256,11406251 11406229,11406222,11406208,11406204,11406197,11406182,11406015,11404665,11404426 11404348,11403823,11403430,11403268,11402684,11399435,11397821,11396241,11394763 11391037
Engine And Engine Cooling:engine:oil/lubrication:filter/screen
On March 29, 2021, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE 21-009) after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7 equipped with the 4.0L, twin-turbocharged engine. Complainants reported the vehicles would stall with no warning while driving at highway or city traffic speeds. Several of the complainants alleged an inability to restart. The complaints alleged the major contributing factor to the engine stalling was the failure of the turbochargers. The complaints cited the turbocharger failure was a result of oil starvation due to a clogged oil strainer in the turbocharger oil supply line.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making servicing the component difficult. The oil strainer removes particles and carbon deposits from the oil before lubricating the turbochargers. Over time, if the debris is not removed from the oil strainer, it becomes clogged and prevents oil from flowing to the turbochargers. This causes the turbine bushings to run dry and overheat resulting in turbine shaft failure due to thermal stress.On April 04, 2022, PE21-009 was upgraded to an Engineering Analysis (EA22-001) to further assess the scope, frequency, and potential safety related consequences of the alleged defect. Volkswagen filed recall 22V-178 to replace the 30?m mesh oil strainer with a 90?m mesh oil strainer in the subject vehicles. VW introduced the larger mesh oil strainer into production in March of 2017 effecting the 2017-2018MY vehicles.ODI reviewed information from VW for vehicles that had the larger mesh installed in production. The data received showed, since the new oil strainer size of 90?m went into production for the 2017-2018MY, there has not been any reported incidents of turbocharger failures due to oil starvation or other failures that could be related to the larger screen mesh. In view of the recall being conducted by VW and lack of any detrimental side effect to the turbocharger caused by the larger mesh, ODI is closing this Engineering Analysis (EA). The agency reserves the right to take additional action if warranted by future circumstances.11502847,11506565,11494663,11488813,11486393,11480926,11479882,11476289,11466761 11464663,11463254,11460580,11460496,11458973,11458804,11457556,11454753,11452668 11452589,11452584,11452383,11452175,11452111,11451724,11451724,11450995,11450988 11449661,11447092,11443657,11442867,11440536,11440052,11439959,11438691,11436461 11435619,11433925,11433733,11432336,11431661,11431421,11429704,11429584,11428128 11426929,11424203,11423603,11423337,11422431,11421084,11420626,11420342,11419693 11418884,11418437,11418433,11418135,11417635,11417351,11416095,11414578,11414235 11414064,11413359,11413285,11413214,11407510,11407450,11406897,11406821,11406637 11406460,11406416,11406291,11406287,11406277,11406273,11406263,11406256,11406251 11406229,11406222,11406208,11406204,11406197,11406182,11406015,11404665,11404426 11404348,11403823,11403430,11403268,11402684,11399435,11397821,11396241,11394763 11391037
PE21009 · Engine Stall - Turbo Failure
Opened Mar 29, 2021 · Closed May 27, 2022
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:oil/lubrication:filter/screen
On March 29, 2021, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 21-009 after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7. The subject vehicles are equipped with 4.0L, twin-turbocharged engine. Complainants reported that the vehicles stall suddenly with no warning while driving on the highway or in city traffic. Several of the complainants alleged an inability to restart. The complaints allege the major contributing factor to the engine stalling is the failure of the turbochargers. The complaints further allege the turbocharger failure is a result of oil starvation due to a clogged oil strainer.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making regular service difficult. The oil strainer removes dirty particles and carbon deposits from the oil before flowing to lubricate the Turbochargers. Overtime if the debris are not removed from the oil strainer, it clogs the strainer and prevents free flow of oil to the turbochargers and makes the turbine bushings to run dry and overheat which causes the turbine shaft to break due to thermal stress. In VW's response to ODI's Information Request letter, VW provided approximately 611 warranty claims with unique VINs, 70 Field Reports and 45 Consumer complaints. These reports allege engine stalling due to turbocharger failure similar to the NHTSA reports described above. To date, NHTSA has received approximately 98 allegations of stall due to turbocharger failures. The total of 824 reports shown in the table above eliminates duplicate reports received by both ODI and the manufacturer.This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA) to further assess the scope, frequency, and potential safety related consequences of the alleged defect of engine stalling due to turbocharger failureThe ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers:11452589, 11452584, 11452383, 11450995, 11450988, 11449661, 11447092, 11442867 11440536, 11440052, 11439959, 11438691, 11436461, 11435619, 11431661, 11429704 11429584, 11426929, 11424203, 11423603, 11423337, 11421084, 11420626, 11420342 11418884, 11418437, 11418433, 11417635, 11417351, 11416095, 11414235, 11413359 11413214, 11413285, 11413133, 11407510, 11407450, 11407289, 11406821, 11406416 11406291, 11406277, 11406273, 11406256, 11406251, 11406229, 11406222, 11406204 11406197, 11406182, 11404665, 11404426, 11404348, 11403430, 11403268, 11399435 11397821, 11396241, 11394763, 11391037, 11388662, 11387166, 11377446, 11363283 11354107, 11344193, 11342497, 11342360, 11340302, 11325065, 11324163, 11322168, 11321144, 11318477, 11306754, 11279429, 11268109, 11256706, 11252723, 11246579 11234853, 11234714, 11231582, 11231013, 11230589, 11229484, 11222281, 11218822 11218749, 11217604, 11209168, 11209142, 11197149, 11191243, 11175842, 11170776 11164032, 11152418.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
On March 29, 2021, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 21-009 after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7. The subject vehicles are equipped with 4.0L, twin-turbocharged engine. Complainants reported that the vehicles stall suddenly with no warning while driving on the highway or in city traffic. Several of the complainants alleged an inability to restart. The complaints allege the major contributing factor to the engine stalling is the failure of the turbochargers. The complaints further allege the turbocharger failure is a result of oil starvation due to a clogged oil strainer.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making regular service difficult. The oil strainer removes dirty particles and carbon deposits from the oil before flowing to lubricate the Turbochargers. Overtime if the debris are not removed from the oil strainer, it clogs the strainer and prevents free flow of oil to the turbochargers and makes the turbine bushings to run dry and overheat which causes the turbine shaft to break due to thermal stress. In VW's response to ODI's Information Request letter, VW provided approximately 611 warranty claims with unique VINs, 70 Field Reports and 45 Consumer complaints. These reports allege engine stalling due to turbocharger failure similar to the NHTSA reports described above. To date, NHTSA has received approximately 98 allegations of stall due to turbocharger failures. The total of 824 reports shown in the table above eliminates duplicate reports received by both ODI and the manufacturer.This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA) to further assess the scope, frequency, and potential safety related consequences of the alleged defect of engine stalling due to turbocharger failureThe ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers:11452589, 11452584, 11452383, 11450995, 11450988, 11449661, 11447092, 11442867 11440536, 11440052, 11439959, 11438691, 11436461, 11435619, 11431661, 11429704 11429584, 11426929, 11424203, 11423603, 11423337, 11421084, 11420626, 11420342 11418884, 11418437, 11418433, 11417635, 11417351, 11416095, 11414235, 11413359 11413214, 11413285, 11413133, 11407510, 11407450, 11407289, 11406821, 11406416 11406291, 11406277, 11406273, 11406256, 11406251, 11406229, 11406222, 11406204 11406197, 11406182, 11404665, 11404426, 11404348, 11403430, 11403268, 11399435 11397821, 11396241, 11394763, 11391037, 11388662, 11387166, 11377446, 11363283 11354107, 11344193, 11342497, 11342360, 11340302, 11325065, 11324163, 11322168, 11321144, 11318477, 11306754, 11279429, 11268109, 11256706, 11252723, 11246579 11234853, 11234714, 11231582, 11231013, 11230589, 11229484, 11222281, 11218822 11218749, 11217604, 11209168, 11209142, 11197149, 11191243, 11175842, 11170776 11164032, 11152418.
Engine And Engine Cooling:engine:oil/lubrication:filter/screen
On March 29, 2021, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 21-009 after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7. The subject vehicles are equipped with 4.0L, twin-turbocharged engine. Complainants reported that the vehicles stall suddenly with no warning while driving on the highway or in city traffic. Several of the complainants alleged an inability to restart. The complaints allege the major contributing factor to the engine stalling is the failure of the turbochargers. The complaints further allege the turbocharger failure is a result of oil starvation due to a clogged oil strainer.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making regular service difficult. The oil strainer removes dirty particles and carbon deposits from the oil before flowing to lubricate the Turbochargers. Overtime if the debris are not removed from the oil strainer, it clogs the strainer and prevents free flow of oil to the turbochargers and makes the turbine bushings to run dry and overheat which causes the turbine shaft to break due to thermal stress. In VW's response to ODI's Information Request letter, VW provided approximately 611 warranty claims with unique VINs, 70 Field Reports and 45 Consumer complaints. These reports allege engine stalling due to turbocharger failure similar to the NHTSA reports described above. To date, NHTSA has received approximately 98 allegations of stall due to turbocharger failures. The total of 824 reports shown in the table above eliminates duplicate reports received by both ODI and the manufacturer.This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA) to further assess the scope, frequency, and potential safety related consequences of the alleged defect of engine stalling due to turbocharger failureThe ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers:11452589, 11452584, 11452383, 11450995, 11450988, 11449661, 11447092, 11442867 11440536, 11440052, 11439959, 11438691, 11436461, 11435619, 11431661, 11429704 11429584, 11426929, 11424203, 11423603, 11423337, 11421084, 11420626, 11420342 11418884, 11418437, 11418433, 11417635, 11417351, 11416095, 11414235, 11413359 11413214, 11413285, 11413133, 11407510, 11407450, 11407289, 11406821, 11406416 11406291, 11406277, 11406273, 11406256, 11406251, 11406229, 11406222, 11406204 11406197, 11406182, 11404665, 11404426, 11404348, 11403430, 11403268, 11399435 11397821, 11396241, 11394763, 11391037, 11388662, 11387166, 11377446, 11363283 11354107, 11344193, 11342497, 11342360, 11340302, 11325065, 11324163, 11322168, 11321144, 11318477, 11306754, 11279429, 11268109, 11256706, 11252723, 11246579 11234853, 11234714, 11231582, 11231013, 11230589, 11229484, 11222281, 11218822 11218749, 11217604, 11209168, 11209142, 11197149, 11191243, 11175842, 11170776 11164032, 11152418.