2012 Audi S4

VEHICLE FLASHES A GEARBOX MALFUNCTION WARNING AND MOST ELECTRONICS WENT DEAD. VEHICLE WOULD NOT ACCELERATE CAUSING ME TO NEARLY BE REAR ENDED. AFTER TURNING OFF CAR AND RESTARTING THE VEHICLE CONTINUES TO LOSE POWER RANDOMLY EVERY MILE OR SO. THIS CREATED VERY UNSAFE CONDITIONS ON A BUSY FREEWAY. THE PROBLEM TURNED OUT TO BE A FAULTY SENSOR IN THE TRANSMISSION. AUDI HAS ISSUED A TECHNICAL SERVICE BULLETIN ON THIS ISSUE BUT WILL NOT ACKNOWLEDGE THE HUGE SAFETY ISSUE WITH THIS DEFECTIVE TRANSMISSION.

WHILE DRIVING APPROACHING A STOPLIGHT, I RECEIVED A "GEARBOX MALFUNCTION. OK TO CONTINUE DRIVING WITH LIMITED FUNCTIONALITY" ERROR. THE CAR THEN BARELY ACCELERATED AND I COULD NOT GO MORE THAN 20MPH (I WAS ON A BUSY ROAD SPEED LIMIT 35MPH BUT EVERYONE GOES ABOUT 50). I WAS ABLE TO FINALLY GET IT TO DRIVE WELL ENOUGH TO GET IT TO THE DEALER. DEALER SAID IT NEEDS A NEW CIRCUIT BOARD WHICH IS NOT COVERED BY ONLY THE POWER TRAIN WARRANTY, AS IT IS CONSIDERED AN ELECTRONIC COMPONENT.

PREMATURE TRANSMISSION MECHATRONIC FAILURE. CAR UNABLE TO REVERSE DURING A 3 POINT TURN IN A ROADWAY ACROSS TRAIN TRACKS. SINCE NEW THE CAR HAD A CLUNKY TRANSMISSION. IT PROGRESSIVELY GOT WORSE BUT WHEN BROUGHT TO THE DEALER IT WAS ALWAYS, "OPERATING WITHIN MANUFACTURER'S SPECIFICATIONS" THIS IS THE 2ND AUDI IN A ROW THAT HAS BEEN BROUGHT IN MULTIPLE TIMES FOR A PROBLEM THAT THE DEALER CLAIMS ISN'T A PROBLEM AND IS "OPERATING IN SPECS OF THE MANUFACTURER".

A GEARBOX MALFUNCTION (WITH CODES P179E AND P179F) MAY CAUSE THE CAR ENTER ONE OF THE "LIMP MODE" STATES, WHICH CAN CUT ENGINE POWER FROM THE TRANSMISSION. A MESSAGE ON THE DASH MAY SAY "GEARBOX MALFUNCTION" WITH A MESSAGE IF THE CAR IS DRIVEABLE OR MUST BE BROUGHT TO THE REPAIR SHOP. IN SOME CASES, THIS LOSS OF POWER CAN MAKE THINGS DIFFICULT TO PULL OVER SAFELY, AS THE STALL CAN HAPPEN IN AN INTERSECTION, OR IN STOP AND GO TRAFFIC ON THE FREEWAY. AUDI HAS RECOGNIZED THIS PROBLEM IN THE FORM OF A TSB (2032211), HOWEVER, ALL CARS WITH THIS PARTICULAR TRANSMISSION MAY EXPERIENCE A SIMILAR ISSUE, AT ANY TIME, DESPITE FOLLOWING MANUFACTURER SERVICE INTERVALS. THE ISSUE MAY APPEAR TO BE INTERMITTENT AND MAY NOT ENTER FULL LIMP MODE UNTIL MANY MILES LATER. MY INITIAL ENCOUNTER WITH QUESTIONABLE TRANSMISSION BEHAVIOR WAS ABOUT 10-15K MILES PRIOR. THIS PARTICULAR CASE DOCUMENTED WAS THE WORST SCENARIO, BUT SIMILAR SCENARIOS (COMING OFF THE FREEWAY AND STALLING SHORTLY AFTER STOPPING, OR NOT BEING ABLE TO ENGINE BRAKE PROPERLY DUE TO TRANSMISSION REFUSING TO SHIFT) HAVE ALSO BEEN EXPERIENCED.

I AM A MECHNIC WITH 10 YEARS OF EXPERIENCE AND I JUST STARTED THIS NEW JOB TWO WEEKS AGO. THEIR JUST THREE MECHNICS IN THE SHOP. WE HAD A 2012 AUDI S4 COME INTO THE SHOP WITH THE OWNER COMPLAINING OF BRAKE PROBLEMS. THE OWNER OF THE CAR SAID THE SOMTIMES ALL THE SUDDEN HIS BRAKES WOULD GO OUT WHILE HE WAS DRIVING AND HIS BRAKE PEDEL FELT SOFT. I TOOK ON THE WORK. MY SHOP FOREMAN TOLD ME TO BLEED THE BRAKES OUT. SO I DID. I NOTICED THT THE BRAKE RESIVIOR HAD A THICK GREEN SUBTANCE IN IT. I KNEW FROM MY EXPERIENCE THAT THEIR WAS A LOT OF WATER AND OTHER CONTAMINATION IN THE SYSTEM. I IMEADITLY INFORMD MY FOREMAN THAT THE SYSTEM NEEDED TO BE FLUSHED AND CLEANED. MY FOREMAN TOLD ME THT THE CAR WAS DONE AND TO MOVE ON. I IMEADITLY EXPRESSED MY CONCERN AND GAVE MY PROFESSIONAL ADVICE THAT THAT CAR WAS NOT TO BE DRIVING UNTIL IT WAS FIXD. THE BRAKES COULD FAIL ANYTIME AND SOMONE COULD BE KILLED. HRS LATER I LOOKED OUTSIDE AND SEEN THE CARS OWNER AND HIS KIDS GET INTO THE CAR AND DRIVE OFF. I AGAIN EXPRESSED MY CONCERN TO THE FOREMAN. HE HAD TOLD THE CUSTOMER THT IT WAS FIXED. MY FORMAN JUST LET THIS COSTMER LEAVE OUT IN A CAR WITH HIS KIDS THE WAS UNSAFE TO BE ON THE ROAD. THE CAR IS A DEATH TRAP. MY FOREMAN JUST DIDNT CARE. NEXT DAY THE CAR CAME BACK WITH THE COSTOMER COMPLAING THE HIS BRAKES FAILD ON HIM AND THAT THEY WHERE NOT FIXED. IF SOMEONE HAD BEEN KILLED THAN IT WOULD BE MY FOREMANS FALT FOR NEGLANCE. I THINK HE SHOULD GOTO JAIL FOR THIS. IT IS MORALY WRONG AND DANGEROUS. WHT IS IT GONNA TAKE FOR THEASE TYPE OF ACTIONS FROM HIM TO STOP. HOPFULLY NOT FOR SOMONEMTO DIE FIRST.