2020 Audi Q7

I am filing a complaint concerning serious safety risks associated with my 2020 Audi Q7 (VIN: [XXX] ) purchased as a Certified Pre-Owned vehicle from Audi Dominion San Antonio. It is currently under service at Audi Central Houston, where multiple concerning events occurred. Timeline and Issues: - Initial diagnosis identified a fire-damaged electrical harness, estimated at $1,400 for replacement. - After repair attempts, the vehicle began smoking, and the diagnosis expanded to include additional compromised electrical lines. The revised quote skyrocketed to $4,700 (later reduced to $3,100). - After nearly two months in service, I was informed that the AC compressor is now deemed "bad" due to debris from the harness, an issue not mentioned in previous inspections. Safety Concerns: 1. Inconsistent Diagnosis: There was no mention of compressor damage during initial assessments. This late-stage discovery indicates negligence or potential additional damage during servicing. 2. Risky AC Activation: A technician attempted to clean the compromised AC compressor and activated the system, a procedure that is dangerous given the debris. This could lead to refrigerant leaks and electrical shorts. 3. Conflicting Statements: Audi Central Houston claims the compressor was previously damaged but also attempted to restore it. Such contradictions raise serious concerns about service integrity. 4. Certified Pre-Owned Credibility: The emergence of these costly issues questions the reliability guarantees of vehicles sold under Audi's Certified Pre-Owned program. Given that the vehicle began smoking shortly after being parked and had not undergone prior electrical work, I underscore the severe safety risks posed by potential electrical fires and undisclosed damage. These issues could endanger lives and property if not properly addressed. I strongly urge Audi USA and the NHTSA to investigate this matter for potential technical service bulletins or recalls, especially fo INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION A

In July 2023, my 2020 Audi Q7 experienced a complete electrical failure at highway speeds due to a Belt Starter Generator (BSG) malfunction. Audi replaced the BSG with the same faulty part. Months later, I noticed increased oil consumption and loud engine noise. Despite multiple service visits and reporting these issues, Audi failed to properly diagnose the problem. In January 2025, despite a clear check engine light indicating a problem, Audi dismissed my concerns. Just weeks later, in February 2025, the engine catastrophically failed due to undiagnosed internal damage. Audi repeatedly ignored diagnostic warnings and failed to address my complaints, putting my safety at risk. Audi consistently dismissed my concerns, attributing engine noise and oil consumption to normal wear. The failures posed safety risks, including sudden loss of power while driving. Despite documented defects, Audi refused to take responsibility or perform proper diagnostics, resulting in continued safety hazards. I am formally requesting NHTSA to investigate the widespread issues affecting the 2020 Audi Q7, including the BSG system and excessive oil consumption leading to engine failure.” Additional Details: •Component/System Failure: The 48V Belt Starter Generator (BSG) and the engine failed. The vehicle is available for inspection upon request. •Safety Risks: The electrical failure at highway speeds caused a sudden loss of power. The engine failure posed a risk of the vehicle shutting down unexpectedly while driving. •Problem Confirmation: The Audi dealership confirmed the engine failure and acknowledged the presence of metal shavings in the oil, indicating severe internal damage. •Inspections: The vehicle has been inspected by the Audi dealership, and Audi representatives acknowledged the issue. •Warning Signs: The check engine light illuminated in January 2025. Additional symptoms included loud engine noise (‘tractor-like’) and increased oil consumption, which Audi dismissed.

while driving the vehicle, I received a warning that there was an electrical system failure. Then the entire care shut off in the middle of the highway. There was no way to get the vehicle into neutral to push it to a safer location out of traffic. I was in the vehicle with my two children. This left us stranded in the middle of the highway with a significant amount of traffic. There was no way to get the vehicle back on. This seems to be a known issue with Audi and they have notified the dealerships about it but have not issued a recall. Please expedite this as a recall. There could not have been a more dangerous situation for me and my children.

The contact owns a 2020 Audi Q7. The contact stated that while driving approximately 55 MPH, the messages "Electrical Malfunction" and "Stop Vehicle" were displayed. The contact stated that moments later the vehicle shut off and failed to restart. The vehicle was towed to the residence and later examined by an independent mechanic who diagnosed that the alternator was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were contacted regarding the failure, but no assistance was provided. The failure mileage was 70,000.

Our 2020 Audi Q7 (50,100 miles) suffered a catastrophic electrical failure while traveling on the freeway at 65+MPH. Suddenly the engine warning light went on, and then seconds later the entire interior lit up like a Christmas tree before it succumbed to a complete and catastrophic electrical failure. EVERYTHING failed – the car had zero power. No acceleration, brakes, steering, SOS, hazards / turn signals, brake lights, airbags, door locks, etc. My wife and child sat there in a steel box traveling at a high rate of speed while obstacles navigated around them; had they been hit, the air bags would not have deployed. This car nearly cost me my family. Audi replaced the alternator and the battery, and denied my buy-back claim because the incident hasn’t happened multiple times, and therefore doesn’t qualify for the lemon law. We continue to experience problems with the car – most recently: acceleration hesitation and recent warning lights saying 1. camera sensor failure (only to have them start working again), 2. tire pressure warnings (despite all the tire pressures being normal), and 3. warnings notifying me that lights are out (despite all lights operating normally). I believe Audi is underestimating the severity of the situation. We were fortunate that the initial failure on the freeway did not result in injuries or fatalities. I cannot fathom the idea of waiting for the vehicle to fail multiple times before taking it off the road, potentially putting lives at risk. The car has only been serviced at Audi dealerships. My family and I no longer feel safe in this car. While selling it is an option, I cannot, in good conscience, endanger someone else's life by not disclosing the vehicle's history and the well-known electrical defects Audi has.

Received a yellow "electrical failure" warning while driving, instructing me to call Audi for service. Audi indicated that the car remained safe to drive, and offered a service appointment greater than one month later. Driving the car the next day, the electrical failure icon converted to red and a message said to pull over immediately. The car was able to make it to a local repair shop, with electrical systems failing one-by-one (starting with heating and progressing from there). On reaching the shop, the car was no longer driveable and had to be pushed into the garage to be assessed. The problem could not be identified at the local shop, so the car was towed to Audi dealer. Problem was found to be the generator. Have been waiting on replacement part for greater than 30 days, with no ETA as of today. Primary safety concern is that the car became undriveable within minutes of the red warning. Had I been on a highway or in heavy traffic, my car could have stalled in the middle of a busy roadway. Even if I had pulled off onto the shoulder, the risk to my family would have been quite high.

While driving at high speeds on the Freeway with my wife and 2 children (ages 4 & 5), an alert on the dashboard said - Electric System Malfunction. Drove straight to the near by dealership and was told not to turn off the vehicle as it might not start. Service Advisor said we were lucky it didn't stop on the freeway as it has for others. He asked us to collect our belongings as the car was not drivable due to a known electrical system malfunction. He said this was a known issue as there were many others impacted with this same issue and have been waiting months for the parts. He also said Audi of America is well aware of the issue but don't want to publicize it as they don't have the parts available to repair all the impacted vehicles. He provided me with the Audi TSB 27 22 41 showing they knew about it since at least March 2021 (Attached).

TWO ISSUES: THE SMALL PORTABLE AIR PUMP THAT CAME WITH THE CAR WOULD BLOW THE FUSE TO THE 12V CIGARETTE LIGHTER. AFTER A NEW FUSE IS PUT IN, THIS WOULD HAPPEN ON ABOUT EVERY THIRD OR FOURTH TIME OF USING OF THE PUMP. I HAVE REPLACED ABOUT 5 FUSES ALREADY. THE SECOND ISSUE IS THE SQUEAKING OF THE REAR BRAKES WHEN BACKING UP DURING COLD OR HOT. HOWEVER, IT DOES HAPPEN MORE WHEN COLD/IN THE MORNING. A FACTORY DEALERSHIP HAD LOOK AT THE ISSUE BUT FOUND NOTHING.