2021 Audi E-TRON Sportback

2021 Audi e-tron, 44,749 miles. Right after a scheduled service at Audi [XXX] on XXX, I noticed a loud droning/humming noise from the drivetrain while driving. The noise tracks with vehicle speed - it gets louder and higher-pitched as the car goes faster. I called the dealership to report it as soon as I got the car back in late XXX. Nobody responded. The noise is still present today, roughly five months later, at about 48,000 miles. The symptom matches Audi's own technical service bulletin 2047920 (rev 7), which covers 2020-2025 Audi vehicles including the e-tron: a humming/booming noise while driving whose frequency rises with speed, caused by mechanical damage to the front wheel bearing. Multiple other e-tron owners report the same speed-correlated drone on owner forums, including a bearing failure inside the drive motor and a full rear drive unit failure. I am concerned that a failing drivetrain bearing could degrade suddenly at highway speed. Manufacturer response to date: my phone report right after the April 2026 service got no response. I raised the noise in writing to Audi of America on XXX (their reference XXX). Audi's XXX reply addressed only warranty expiration and pointed me back to the dealer; no inspection or diagnosis of the noise has been offered. A dealer-scheduled service visit is set for XXX. Separate context on dealer handling: in XXX Audi of [XXX] told me to pay out of pocket for covered service while my Audi Care plan was still active (through XXX). An [XXX] service advisor later wrote to Audi regional staff that 'the service may have been eligible for coverage at the time of the visit.' I am asking NHTSA to investigate this as a defect pattern across 2020-2025 e-tron vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving my 2021 Audi e-tron Sportback Prestige, the high-voltage battery warning light illuminated on the dashboard. At the same time, regenerative braking stopped functioning, resulting in reduced energy recovery and a noticeable decrease in driving range. Before taking the vehicle to an Audi dealership, I had the diagnostic trouble codes read by an independent repair shop. The technician advised me to take the vehicle to Audi because the diagnostic information reportedly indicated a potential high-voltage battery thermal runaway condition. I took the vehicle to an authorized Audi dealership. The dealer cleared the fault codes and returned the vehicle to me without replacing any high-voltage battery components or performing repairs. I was not advised that the vehicle was unsafe to drive. A few weeks later, the high-voltage battery warning light returned. I brought the vehicle back to the dealership, where I was informed that a high-voltage battery module had failed. The dealer has now recommended replacing the battery module at an estimated cost of approximately $12,000. I am concerned that the vehicle was returned to me after a reported high-voltage battery fault was simply cleared rather than repaired. I am also concerned that replacing only a single battery module may not address the underlying issue. Additionally, I am aware of high-voltage battery recalls involving other Audi, Porsche, and Volkswagen electric vehicles, and I believe this failure should be evaluated to determine whether it represents a similar safety defect. This issue presents a significant safety concern because it involves the high-voltage battery system, loss of regenerative braking, reduced vehicle range, and a reported battery thermal-related fault. I am requesting that NHTSA investigate whether this is a broader safety issue affecting 2021 Audi e-tron Sportback vehicles.

The contact owns a 2021 Audi E-Tron Sportback. The contact received notification of NHTSA Campaign Number: 23V867000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The VIN was not available.