IllustrationREPLACED CYLINDER BANK 1 RIGHT SIDE! *TR
2004 Audi A6
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Audi A6 do not stand out strongly from the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all A6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
725–50K
550–75K
775–100K
5100–150K
1150K+
27 reports with mileage · 8 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports2 fire reports1 injury reports
What owners actually said
35 reportsPASSENGER SIDE MECHANICAL VERTICAL ADJUSTER DOES NOT FUNCTION IS LAMP POINT TO ABOUT 10 FEET TO THE FRONT OF THE VEHICLE. DIVER SIDE ADJUSTER APPEAR TO FUNCTION OK. ONLINE BLOGS CONFER MULTIPLE PROBLEMS WITH AUDI HEADLIGHT ADJUSTERS AS COMMON, RECURRENT, AND COSTLY TO FIX. DRIVING WITH POORLY AIMED LIGHTS IS OBVIOUSLY SAFETY IS…
Read full complaint
PASSENGER SIDE MECHANICAL VERTICAL ADJUSTER DOES NOT FUNCTION IS LAMP POINT TO ABOUT 10 FEET TO THE FRONT OF THE VEHICLE. DIVER SIDE ADJUSTER APPEAR TO FUNCTION OK. ONLINE BLOGS CONFER MULTIPLE PROBLEMS WITH AUDI HEADLIGHT ADJUSTERS AS COMMON, RECURRENT, AND COSTLY TO FIX. DRIVING WITH POORLY AIMED LIGHTS IS OBVIOUSLY SAFETY ISSUE. *TR
TL*THE CONTACT OWNS A 2004 AUDI A6. THE CONTACT STATED THAT WHEN REFUELING THE VEHICLE OVER THE THREE QUARTER CAPACITY LEVEL, A SUBSTANTIAL AMOUNT OF FUEL WOULD LEAK UNDERNEATH THE VEHICLE NEAR THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND STATED THAT THE FUEL TANK ROLLOVER VALVE WAS …
Read full complaint
TL*THE CONTACT OWNS A 2004 AUDI A6. THE CONTACT STATED THAT WHEN REFUELING THE VEHICLE OVER THE THREE QUARTER CAPACITY LEVEL, A SUBSTANTIAL AMOUNT OF FUEL WOULD LEAK UNDERNEATH THE VEHICLE NEAR THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND STATED THAT THE FUEL TANK ROLLOVER VALVE WAS LEAKING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT EXPRESSED SIGNIFICANT CONCERN OF THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 90,000. THE VIN WAS UNAVAILABLE.
2004 AUDI A6 SEDAN, 3.0 ENGINE DEVELOPED A SUDDEN LOSS OF POWER JUST BEFORE VEHICLE STALLED WHILE DRIVING ON HIGHWAY AT 65 MPH. VEHICLE WAS TOWED TO REPAIR SHOP WHERE IT WAS DETERMINED THAT THE FUEL PUMP HAD FAILED. *TR
TL*THE CONTACT OWNS A 2004 AUDI A6 AVANT. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT HAD BEEN ILLUMINATING INTERMITTENTLY. THE DEALER STATED THAT THE CONTACT SHOULD NOT WORRY ABOUT THE LIGHT. WHILE DRIVING 65 MPH, THE CONTACT SWERVED TO MISS A DEER AND LOST CONTROL OF THE VEHICLE. IT BEGAN TO ROCK BACK AND FORTH AND THE BRAK…
Read full complaint
TL*THE CONTACT OWNS A 2004 AUDI A6 AVANT. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT HAD BEEN ILLUMINATING INTERMITTENTLY. THE DEALER STATED THAT THE CONTACT SHOULD NOT WORRY ABOUT THE LIGHT. WHILE DRIVING 65 MPH, THE CONTACT SWERVED TO MISS A DEER AND LOST CONTROL OF THE VEHICLE. IT BEGAN TO ROCK BACK AND FORTH AND THE BRAKES WERE INOPERATIVE. THE CONTACT HIT GUARDRAILS ON BOTH THE DRIVER AND PASSENGER SIDES. THE VEHICLE THEN TIPPED ON ITS SIDE AND WENT INTO A RAVINE. THE ENGINE WAS STILL RUNNING AND THE WHEELS WERE STILL SPINNING. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUFFERED INJURIES TO THE COLLAR BONE, RIBS, A CONCUSSION, AND LOST TEETH. THE DEALER STATED THAT THERE COULD HAVE BEEN A PROBLEM WITH THE COMPUTER. THE VEHICLE WAS DESTROYED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 190,000. UPDATED 04/08/11
CAR'S ENGINE STOPPED WHILE AT A RED LIGHT. WOULD NOT START AFTER FAILURE. ULTIMATELY, CAUSE WAS DETERMINED TO BE A FAILED FUEL PUMP. I SAW THAT THERE WAS A RECALL ON THE FUEL PUMP FOR 2003 A6 MODELS INCLUDING 3L VEHICLES, BUT NOT FOR 2004 MODELS.]
I AM WRITING ABOUT MY 2004 A6 AVANT, WHICH HAS 78,000 MILES. AT A RECENT OIL SERVICE AT AN INDEPENDENT GARAGE, IT WAS SUGGESTED THAT THERE WAS A PROBLEM WITH THE CATALYTIC CONVERTERS. EXHAUST WAS LEAKING FROM BOTH SIDES, I WAS TOLD. I TOOK THE CAR TO MY AUDI DEALER, WHERE THEY CHECKED THE EXHAUST SYSTEM. THE MECHANIC WHO E…
Read full complaint
I AM WRITING ABOUT MY 2004 A6 AVANT, WHICH HAS 78,000 MILES. AT A RECENT OIL SERVICE AT AN INDEPENDENT GARAGE, IT WAS SUGGESTED THAT THERE WAS A PROBLEM WITH THE CATALYTIC CONVERTERS. EXHAUST WAS LEAKING FROM BOTH SIDES, I WAS TOLD. I TOOK THE CAR TO MY AUDI DEALER, WHERE THEY CHECKED THE EXHAUST SYSTEM. THE MECHANIC WHO EXAMINED THE CAR CONCURRED THAT THE CATALYTIC CONVERTERS NEEDED TO BE REPLACED. UNDER A FEDERALLY MANDATED WARRANTY, THE CATALYTIC CONVERTERS ARE COVERED FOR EIGHT YEARS OR 80,000 MILES. YET THE DEALER HAS DECLINED TO COVER REPLACEMENT BECAUSE THE "CHECK ENGINE" LIGHT WAS NOT ON. I WAS GIVEN A REPAIR ESTIMATE OF $2,400. *TR
I FILED A COMPLAINT ABOUT MY 2004 AUDI A6 IN DEC OF 2009. I REPORTED THAT MY BACK PASSENGER SEAT HAD ALMOST CAUGHT FIRE, AND WAS BURNT. BOTH MY SEAT CUSHION AND UPPER BACK CUSHION WERE BURNED. AT THE TIME I HAD NOT CONTACTED AUDI, YET FILED A COMPLAINT, BECAUSE I FELT AND STILL DO THAT THIS WAS A MAJOR SAFETY HAZARD. SINCE MY LA…
Read full complaint
I FILED A COMPLAINT ABOUT MY 2004 AUDI A6 IN DEC OF 2009. I REPORTED THAT MY BACK PASSENGER SEAT HAD ALMOST CAUGHT FIRE, AND WAS BURNT. BOTH MY SEAT CUSHION AND UPPER BACK CUSHION WERE BURNED. AT THE TIME I HAD NOT CONTACTED AUDI, YET FILED A COMPLAINT, BECAUSE I FELT AND STILL DO THAT THIS WAS A MAJOR SAFETY HAZARD. SINCE MY LAST COMPLAINT I DID CONTACT BOTH MY DEALERSHIP (ROTH AUDI IN ERIE, PA) AND AUDI HEADQUARTERS AKA: AUDI CUSTOMER RELATIONS. THEY WERE VERY WILLING TO WORK WITH ME, SEEMED EXTREMELY CONCERNED AND SAID NOT TO WORRY BECAUSE I STILL HAD A WARRANTY LEFT ON MY CAR. WELL AFTER THE CAR RETURNED HOME FROM THE DEALERSHIP THEY ONLY FIXED HALF OF THE PROBLEM! THE DEALERSHIP SAID AUDI TOLD THEM TO REPLACE THE BOTTOM CUSHION ONLY. THE DEALERSHIP PAINTED OVER THE TOP CUSHION AND I FOUND THIS OUT AFTER I BEGAN WIPING MY SEAT, BECAUSE I THOUGHT I HAD SMUDGE MARKS ON IT... NOPE PAINT WAS COMING OFF AND COULD SEE THE BURNED SEAT UNDERNEATH THE PAINT. I CALLED AUDI BACK, AND THEY HAD ME TAKE IT BACK TO THE DEALER TO BE ASSESSED AGAIN. AFTER 6 DAYS OR SO THE PERSON I HAD BEEN DEALING WITH FROM AUDI CUSTOMER RELATIONS CALLED TO SAY WE CANT REPLACE THAT PART OF THE SEAT BECAUSE THEY FOUND NO DEFECT IN THE HEATING ELEMENT. SO IN ESSENCE, THEY ONLY DID HALF OF THEIR JOB SINCE THE SEAT BURNED FROM ONE INCIDENT! I HAVE SINCE CONTACTED THE FTC, AND THE ATTORNEY GENERAL RE: THIS ISSUE. I WILL NOT STOP THERE IF I DO NOT GET THIS RESOLVED. THE ENTIRE SEAT SHOULD HAVE BEEN COVERED UNDER THE WARRANTY. CONSIDERING VW RECALLED MANY OF THEIR CARS FOR THE SAME REASON, AND AUDI IS OWNED BY VW I WOULD THINK THEY WOULD BE A BIT MORE CONCERNED ABOUT THEIR CUSTOMERS. I HAVE VIEWED MANY FORUMS, AND FOUND THERE WERE A LOT OF COMPLAINTS SIMILAR TO MINE WITH REGARDS TO THE HEATED SEATING EITHER CATCHING ON FIRE OF BURNING THE SEAT. I'D LIKE TO KNOW IF NHTSA IS HONESTLY LOOKING INTO THIS? THANK YOU. *TR
TL* THE CONTACT OWNS A 2004 AUDI A6. THE CONTACT STATED WHEN THE VEHICLE IS PARKED THE THROTTLE FLUCTUATES. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THE DEALER CHANGE THE MASS AIR FLOW METER. THAT DID NOT REMEDY THE THROTTLE FLUCTUATION SO THE DEALER REMOVED THE MASS AIR FLOW METER. THE DEALER THEN RESET THE COMPUTER F…
Read full complaint
TL* THE CONTACT OWNS A 2004 AUDI A6. THE CONTACT STATED WHEN THE VEHICLE IS PARKED THE THROTTLE FLUCTUATES. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THE DEALER CHANGE THE MASS AIR FLOW METER. THAT DID NOT REMEDY THE THROTTLE FLUCTUATION SO THE DEALER REMOVED THE MASS AIR FLOW METER. THE DEALER THEN RESET THE COMPUTER FOR THE THROTTLE BODY AND THAT DID NOT REMEDY THE ISSUE AS WELL. THE DEALER DOES NOT KNOW WHAT IS CAUSING THE THROTTLE TO FLUCTUATE. THE CONTACT STATED THE THROTTLE FLUCTUATION IS CAUSING THE VEHICLE TO LUNGE FORWARD WHEN THE VEHICLE IS IDLE. THE FAILURE MILEAGE WAS 94,500.
SUDDEN LOSS OF ENGINE POWER WHILE DRIVING A 2004 AUDI A6 AVANT ON HIGHWAY 280 SOUTH IN NORTHERN CALIFORNIA. THE CAR SUDDENLY LOST ALL ENGINE POWER AND STALLED ON THE HIGHWAY. THE CAR STOPPED BEFORE REACHING THE HIGHWAY CURB. THE HIGHWAY POLICE WHO CAME BY SEEING THE FLASHERS ON THE CAR ASSISTED IS PUSHING THE CAR SAFELY INTO TH…
Read full complaint
SUDDEN LOSS OF ENGINE POWER WHILE DRIVING A 2004 AUDI A6 AVANT ON HIGHWAY 280 SOUTH IN NORTHERN CALIFORNIA. THE CAR SUDDENLY LOST ALL ENGINE POWER AND STALLED ON THE HIGHWAY. THE CAR STOPPED BEFORE REACHING THE HIGHWAY CURB. THE HIGHWAY POLICE WHO CAME BY SEEING THE FLASHERS ON THE CAR ASSISTED IS PUSHING THE CAR SAFELY INTO THE HIGHWAY CURB AREA. THE CAR HAD TO BE TOWED TO THE DEALER FOR DIAGNOSTICS AND REPAIRS. THE DEALER IDENTIFIED THAT THE FUEL PUMP HAD FAILED. *TR
Official recalls
411V267000 · Fuel System, Other:storage:tank Assembly
May 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
08V157000 · Fuel System, Gasoline:storage:tank Assembly
Apr 8, 2008
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
06V198000 · Electrical System
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
04V133000 · Electrical System
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.