Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
625–50K
850–75K
1075–100K
14100–150K
3150K+
50 reports with mileage · 16 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Gasoline. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports5 fire reports1 injury reports
What owners actually said
66 reports
38,593 miles · Aug 4, 2008
Electrical System
THE LED PORTION OF THE INSTRUMENT CLUSTER FADES OUT ON HOT DAYS MAKING THE GEAR SELECTION INDICATOR (PRND321) SHOWN IN THE DISPLAY UNREADABLE. THIS IS A SAFETY ISSUE BECAUSE THE DRIVER NEEDS TO KNOW WHAT GEAR THAT TRANSMISSION IS IN AT ALL TIMES AND A FADING DISPLAY LEADS THE DRIVER TO GUESS RATHER THAN KNOW. THIS FADING STARTE…
Read full complaint
THE LED PORTION OF THE INSTRUMENT CLUSTER FADES OUT ON HOT DAYS MAKING THE GEAR SELECTION INDICATOR (PRND321) SHOWN IN THE DISPLAY UNREADABLE. THIS IS A SAFETY ISSUE BECAUSE THE DRIVER NEEDS TO KNOW WHAT GEAR THAT TRANSMISSION IS IN AT ALL TIMES AND A FADING DISPLAY LEADS THE DRIVER TO GUESS RATHER THAN KNOW. THIS FADING STARTED THREE YEARS AGO AND HAS GOTTEN PROGRESSIVELY WORSE WITH TIME. IT ONLY HAPPENS ON HOT DAYS WHEN THE CAR IS PARKED OR DRIVEN IN THE SUN. WE HAVE LOTS OF SUNNY DAYS IN CALIFORNIA! *TR
NHTSA ODI #10236925
40,655 miles · Jun 24, 2008
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2003 AUDI A6. APPROXIMATELY ONE YEAR AGO, THE CONTACT SMELLED A STRONG ODOR OF GASOLINE WHENEVER HE PLACED FUEL IN THE VEHICLE. HE ALSO NOTICED FUEL LEAKING ON THE GARAGE FLOOR. HE ASSUMED THAT HE WAS PLACING TOO MUCH FUEL INTO THE VEHICLE. IN THE BEGINNING OF JUNE OF 2008, THE CONTACT MADE SURE TO FILL…
Read full complaint
TL*THE CONTACT OWNS A 2003 AUDI A6. APPROXIMATELY ONE YEAR AGO, THE CONTACT SMELLED A STRONG ODOR OF GASOLINE WHENEVER HE PLACED FUEL IN THE VEHICLE. HE ALSO NOTICED FUEL LEAKING ON THE GARAGE FLOOR. HE ASSUMED THAT HE WAS PLACING TOO MUCH FUEL INTO THE VEHICLE. IN THE BEGINNING OF JUNE OF 2008, THE CONTACT MADE SURE TO FILL THE VEHICLE TO THE CORRECT AMOUNT TO AVOID ANY FUEL LEAKAGE. WITHIN HALF AN HOUR OF PARKING THE VEHICLE, THE CONTACT SMELLED A STRONG GASOLINE ODOR AND NOTICED A MUCH LARGER PUDDLE OF GASOLINE UNDERNEATH THE VEHICLE. HE CALLED THE DEALER AND WAS ADVISED TO HAVE THE VEHICLE TOWED; HOWEVER, THE CONTACT REFUSED AND DROVE THE VEHICLE TO THE DEALER. A DIAGNOSIS WAS PERFORMED AND THEY STATED THAT THERE WAS A CRACK IN THE CHECK VALVE OF THE FUEL TANK THAT COULD NOT BE REPAIRED. THE ENTIRE FUEL TANK NEEDED TO BE REPLACED. THE CONTACT PROCEEDED WITH THE REPAIRS, WHICH WERE COMPLETED WITHIN A WEEK. THE FAILURE MILEAGE WAS 38,000 AND CURRENT MILEAGE WAS 40,000. UPDATED 07/16/08. *LJ UPDATED 07/16/08
NHTSA ODI #10232161
Mileage unknown · Apr 5, 2008
Electrical SystemFire
I WAS DRIVING MY 2003 AUDI A6 3.0 QUATTRO ON THURSDAY 04/03/2008 AROUND 10:30PM. I WAS TRAVELING 25MPH ON SYLVAN AVENUE IN ENGLEWOOD CLIFFS, NJ THE CHECK ENGINE LIGHT ILLUMINATED ON MY DASH BOARD AND STARTED FLASHING, I IMMEDIATELY PULLED OVER TO THE SIDE OF THE ROAD TO DIAGNOSE THE PROBLEM, WHEN I PULLED OVER I SAW SMOKE COMING…
Read full complaint
I WAS DRIVING MY 2003 AUDI A6 3.0 QUATTRO ON THURSDAY 04/03/2008 AROUND 10:30PM. I WAS TRAVELING 25MPH ON SYLVAN AVENUE IN ENGLEWOOD CLIFFS, NJ THE CHECK ENGINE LIGHT ILLUMINATED ON MY DASH BOARD AND STARTED FLASHING, I IMMEDIATELY PULLED OVER TO THE SIDE OF THE ROAD TO DIAGNOSE THE PROBLEM, WHEN I PULLED OVER I SAW SMOKE COMING OUT FROM UNDER THE HOOD OF MY CAR. I IMMEDIATELY TURNED OF THE VEHICLE AND POPPED THE HOOD TO SEE WHAT WAS GOING ON... I POPPED THE HOOD TO FIND THE IGNITION COIL ON THE THIRD CYLINDER (BACK LEFT CYLINDER) HAD STARTED ON FIRE WITH ABOUT 12INCHES OF FLAMES. THANK GOD THIS ALL HAPPENED I ABOUT 30 SECONDS AND I WAS ABLE TO GET THE FIRE OUT, OTHERWISE THE WHOLE CAR WOULD HAVE BURNED TO THE GROUND. IF I WAS STUCK IN TRAFFIC OR ON THE HIGHWAY THIS CAR WOULD HAVE MOST DEFINITELY BURNED TO THE GROUND. I FEEL VERY LUCKY MY TWO YEAR OLD DAUGHTER WAS NOT IN THE CAR WITH ME. NEVERTHELESS, THE IGNITION COIL IS COMPLETELY MELTED AS WELL AS THE WIRING HARNESS. I ALWAYS HAVE DONE ALL THE MANUFACTURER RECOMMENDATIONS ON THE VEHICLE AND THE CAR WAS JUST AT THE DEALER SERVICE CENTER ON 04/01/2008 FOR MAINTENANCE, I HAD THEM LOOK OVER THE WHOLE CAR AND THEY SAID EVERYTHING WAS FINE. AFTER SPEAKING TO SERVICE TECHNICIANS AT AUDI I HAVE FOUND THIS TO BE A COMMONLY RECURRING PROBLEM WITH THEIR IGNITION COILS, SPECIFICALLY PERTAINING TO THE THIRD CYLINDER, THEY CLAIM IT OVERHEATS BECAUSE THE DESIGN IS TO CLOSE TO THE CATALYTIC CONVERTER. ALL I KNOW IS SOMETHING SHOULD BE DONE, I HAVE PICTURES OF THE DAMAGE WHERE YOU CAN CLEARLY SEE SOME TYPE OF ELECTRICAL MALFUNCTION THAT I WOULD BE MORE THEN WILLING TO SHARE. PLEASE SOMEONE DO SOMETHING BEFORE A LIFE IS LOST FROM THIS MANUFACTURER ERROR.!!! *TR
NHTSA ODI #10223446
50,000 miles · Nov 6, 2007
Fuel System, Gasoline
WITH NO INCIDENT TO MY AUDI (ACCIDENT, IMPACT, DIS-REPAIR) FUEL AND GAS FUMES LEAK. VEHICLE NOW SPILLS FUEL/FUMES WHEN TANK IS FULL TO 3/4. VISUAL INSPECTION SHOWS FUEL STAINS STARTING FROM THE TOP OF THE FUEL TANK ON THE DRIVER SIDE JUST UNDER THE REAR SEAT. VEHICLE IS NOW NOT BEING DRIVEN TO DETERMINE WHAT IS THE BEST COURSE O…
Read full complaint
WITH NO INCIDENT TO MY AUDI (ACCIDENT, IMPACT, DIS-REPAIR) FUEL AND GAS FUMES LEAK. VEHICLE NOW SPILLS FUEL/FUMES WHEN TANK IS FULL TO 3/4. VISUAL INSPECTION SHOWS FUEL STAINS STARTING FROM THE TOP OF THE FUEL TANK ON THE DRIVER SIDE JUST UNDER THE REAR SEAT. VEHICLE IS NOW NOT BEING DRIVEN TO DETERMINE WHAT IS THE BEST COURSE OF ACTION FOR REPAIR. *TR
NHTSA ODI #10208020
48,400 miles · Mar 19, 2007
Tires
TL*- THE CONTACT OWNS A 2003 2003 AUDI A6 QUARTO. WHILE DRIVING 65MPH ON THE HIGHWAY THE CONTACT HEARD A LOW BUMPING SOUND. THE VEHICLE THEN STARTED TO PULL TO THE RIGHT. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THEY INFORMED THE CONTACT THAT BOTH FRONT TIRES STEEL BELTS WERE COMPLETELY SHREDDED. THE ROAD CONDITIONS WERE CLE…
Read full complaint
TL*- THE CONTACT OWNS A 2003 2003 AUDI A6 QUARTO. WHILE DRIVING 65MPH ON THE HIGHWAY THE CONTACT HEARD A LOW BUMPING SOUND. THE VEHICLE THEN STARTED TO PULL TO THE RIGHT. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THEY INFORMED THE CONTACT THAT BOTH FRONT TIRES STEEL BELTS WERE COMPLETELY SHREDDED. THE ROAD CONDITIONS WERE CLEAR. THERE WEREN'T ANY POT HOLES NOR OTHER ROAD HAZARDS VISIBLE. THE FAILURE MILEAGE WAS 12000 MILES ON THE KUMHO ECSTA ASX TIRES. THE VEHICLE CURRENTLY HAS 44800 MILES.
2003 AUDI A6 HAD FOUR TIRES REPLACED DUE TO CRACKING OF THE SIDEWALL. *KB ***NAR*** THE CONSUMER BELIEVES THAT WHEN TOUCHING THE CURB WHILE PARKING, THE SIDEWALL BEING SO THIN AND LOW PROFILE, SIMPLY CRACK, FAIL AND PUNCTURE. THE SIDEWALLS CANNOT BE FIXED. THIS PROBLEM HAS OCCURRED FOUR TIMES IN THE LAST TWO YEARS. (PIRELLI …
Read full complaint
2003 AUDI A6 HAD FOUR TIRES REPLACED DUE TO CRACKING OF THE SIDEWALL. *KB ***NAR*** THE CONSUMER BELIEVES THAT WHEN TOUCHING THE CURB WHILE PARKING, THE SIDEWALL BEING SO THIN AND LOW PROFILE, SIMPLY CRACK, FAIL AND PUNCTURE. THE SIDEWALLS CANNOT BE FIXED. THIS PROBLEM HAS OCCURRED FOUR TIMES IN THE LAST TWO YEARS. (PIRELLI P6 FOUR SEASON LOW PROFILES TIRES). *NM *NM
NHTSA ODI #10163715
32,300 miles · Feb 27, 2006
Fuel System, Gasoline
MY 2003 A6 AUDI QUATTRO "DIED" WHILE IN RUSH HOUR TRAFFIC ON AN INTERSTATE HWAY. IT WAS DETERMINED THAT THIS WAS DUE TO FUEL PUMP FAILURE. VIN # NOT PART OF RECENT FUEL PUMP RECALL BY MANUFACTURER. *NM
NHTSA ODI #10151370
71,000 miles · Feb 20, 2006
Exterior Lighting
BRAKE LIGHTS NO LONGER WORK (ANY). BRAKE LIGHTS WILL NOT TURN ON NO MATTER HOW MANY TIMES THE PEDAL IS DEPRESSED. *JB
NHTSA ODI #10150669
23,000 miles · Feb 9, 2006
Electrical SystemEngine And Engine Cooling
FAULTY IGNITION COILS (SO FAR 3 OUT OF 6 CYLINDERS WENT BAD). ON THREE OCCASIONS AFTER STARTING AND PUTTING THE CAR INTO THE GEAR, SHAKING ENSUED AND THE "CHECK ENGINE" LIGHT TURNED ON. THE CAR HAD TO BE TOWED EACH TIME TO THE DEALER WHERE THE FAULTY PARTS WERE REPLACED. *JB
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 28, 20007. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834. THIS RECALL IS A SUPPLEMENT TO A PREVIOUS CAMPAIGN (PLEASE SEE 06V017).
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
ON CERTAIN VEHICLES PRODUCED FROM SEPTEMBER 2002 - MARCH 2003, EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834.
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3-SPOKE SPORT STEERING WHEELS, IT IS POSSIBLE THAT THE IGNITER FOR THE DRIVER'S SIDE AIR BAG MAY NOT HAVE BEEN PROPERLY ASSEMBLED.
Consequence & remedy
Consequence: AN IMPROPERLY POSITIONED IGNITER WILL NOT ACTIVATE THE AIR BAG IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE AIR BAGS. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
2003 Audi A6 Problems, Complaints & Recalls | Skip That Year
Illustration