NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
66 reportsMileage unknown · Jul 12, 2011
Electrical System
BRAKE LIGHT SWITCH FAILURE. HAD IT FIXED, BUT THE PROBLEMS SEEMS TO BE NOT IN THE BRAKE LIGHT SWITCH ITSELF, BUT THE WIRING OR SOCKETS TO THE SWITCH. USED SAME SWITCH, BUT SOON AS CAR IS TURNED OFF AND TURNED BACK ON, SWITCH TENDS TO WORK ONLY FOR A COUPLE OF DAYS AND ABS SYSTEM SHOWS UP AGAIN WITH NO BRAKES LIGHTS AT ALL. TOO…
Read full complaint
BRAKE LIGHT SWITCH FAILURE. HAD IT FIXED, BUT THE PROBLEMS SEEMS TO BE NOT IN THE BRAKE LIGHT SWITCH ITSELF, BUT THE WIRING OR SOCKETS TO THE SWITCH. USED SAME SWITCH, BUT SOON AS CAR IS TURNED OFF AND TURNED BACK ON, SWITCH TENDS TO WORK ONLY FOR A COUPLE OF DAYS AND ABS SYSTEM SHOWS UP AGAIN WITH NO BRAKES LIGHTS AT ALL. TOOK TO AUDI DEALER IN WHICH THEY SAID THAT THERE HAS BEEN MANY PROBLEMS WITHIN THIS SYSTEM. BUT TO TOTALLY FIX THE PROBLEM WOULD RUN ANYWHERE FROM 700.00 TO 1200 DOLLARS ON A 35.00 TO 45.00 PART. NO BRAKES COULD LEAD TO SERIOUS ACCIDENTS NOT KNOWING THAT YOUR BRAKES LIGHTS ARE ACTUALLY OUT. PLEASE PLEASE RECALL THIS ISSUE ON ALL AUDI'S.
NHTSA ODI #10412769
105,000 miles · Jun 2, 2011
Service Brakes, Electric
FAULTY ABS MODULE. *TR
NHTSA ODI #10404171
85,300 miles · May 22, 2011
Electrical SystemFire
2003 A6 QUATTRO AVANT 3.0 CAR RAN FINE DRIVING TO WORK. WHEN LEAVING AT END OF DAY, STARTED CAR AND IT RAN VERY ROUGH I DECIDED TO REVERSE BACK INTO PARKING SPACE AND AT THAT POINT NOTED SMOKE COMING FROM UNDER HOOD (CAR HAD RUN FOR APPROXIMATELY 20 SECONDS). TURNED OFF ENGINE, OPENED HOOD, AND FOUND THE DRIVERS SIDE REAR CO…
Read full complaint
2003 A6 QUATTRO AVANT 3.0 CAR RAN FINE DRIVING TO WORK. WHEN LEAVING AT END OF DAY, STARTED CAR AND IT RAN VERY ROUGH I DECIDED TO REVERSE BACK INTO PARKING SPACE AND AT THAT POINT NOTED SMOKE COMING FROM UNDER HOOD (CAR HAD RUN FOR APPROXIMATELY 20 SECONDS). TURNED OFF ENGINE, OPENED HOOD, AND FOUND THE DRIVERS SIDE REAR COIL PACK BURNING. EXTINGUISHED FLAME USING A BASEBALL CAP TO SMOTHER IT OUT. COIL PACK CONTINUED TO SMOKE AND REIGNITE DUE TO BURNING INSIDE COIL PACK. JAMMED SCREWDRIVER INTO PACK TO ROOT OUT FLAME. HAD CAR TOWED TO AUDI DEALER - AWAITING REPAIR. THERE IS AN ACTIVE RECALL CAMPAIGN FOR BAD COIL PACKS (28F2 / J1) - RECALL STATES CHECK ENGINE LIGHT MAY COME ON AND CAR WILL RUN ROUGH, FURTHER RECOMMENDS RETURING VEHICLE TO DEALER AT THAT TIME. THERE IS APPARENTLY TWO WAYS THE PACK CAN FAIL - A FAULT ON THE HIGH VOLTAGE END JUST BYPASSES THE SPARK TO THE ENGINE BLOCK CAUSING A MISFIRE. A FAULT AT THE LOW VOLTAGE END RESULTS IN A SHORT AND MOST LIKELY A FIRE. THIS POTENTIAL FOR FIRE IS UNDERSTATED BY AUDI AND SHOUD BE CLEARLY IDENTIFIED IN THE RECALL CAMPAIGN TO ENSURE THE RIGHT URGENCY IS PLACED ON THIS ISSUE. THE FACT IS, I WAS ABLE TO REACT AND EXTIGUISH THE FIRE, HAD THIS OCCURED IN OTHER CIRCUMSTANCES THE CAR WOULD MOST LIKELY HAVE COMPLETELY BURNED. *TR
NHTSA ODI #10402332
85,539 miles · Jan 19, 2011
Fuel System, Gasoline
JANUARY 15, 2011 RE: DEFECTIVE INVESTIGATION PE08008 AUDI 2003 A6 LEAKING FUEL FROM GAS TANK ASSEMBLY ATTACHED, PLEASE FIND EVIDENCE I REPORTED MY FUEL TANK LEAKED FUEL TO A LOS ANGELES AUDI DEALER. I BOUGHT THE CAR IN 2006 WITH 66,000 MILES AND REMAINS WITH NO DAMAGE HISTORY. IN 2008, FUEL BEGAN DRIPPING AT THE LOWER DRIV…
Read full complaint
JANUARY 15, 2011 RE: DEFECTIVE INVESTIGATION PE08008 AUDI 2003 A6 LEAKING FUEL FROM GAS TANK ASSEMBLY ATTACHED, PLEASE FIND EVIDENCE I REPORTED MY FUEL TANK LEAKED FUEL TO A LOS ANGELES AUDI DEALER. I BOUGHT THE CAR IN 2006 WITH 66,000 MILES AND REMAINS WITH NO DAMAGE HISTORY. IN 2008, FUEL BEGAN DRIPPING AT THE LOWER DRIVER SIDE VACUUM NIPPLE FLANGE WHICH SHIFTED OFF THE RIM OF THE FUEL TANK. WHEN THE TANK WAS FILLED PASSED HALF FULL, IT WOULD DRIP ONTO THE GROUND. THERE IS A VALID RECALL FOR MOST 2003 SEDAN MODELS AND THE 4.2L OFF-ROAD QUATTRO. THIS MODEL IS A 2003 SEDAN WITH THE 4.2L ENGINE SIZE AND SHOULD CERTAINLY BE INCLUDED IN THESE TWO RELATED RECALLS. DUE TO NO FAULT OF MY OWN, THE NATURE AND SEVERITY OF THE DEFECT, I QUESTIONED THE PROBLEM WAS A MANUFACTURES DEFECT WARRANTING REPAIR AND POTENTIAL RECALL. THEY DISAGREED, SAID IT WAS OUT OF WARRANTY AND QUOTED ME A REPAIR. VALENTINE ASSERTED THE CONDITION WAS NOTED TO MY VIN IN THEIR SYSTEM. LATER THAT YEAR, LA AUDI MADE DIFFERENT REPAIRS AND THE FUEL LEAK CONDITION WAS AGAIN PUT ON THE WORK ORDER. FINALLY IN JUNE 2010, A NEIGHBOR WROTE NOTE THE CAR WAS LEAKING FUEL. IT TANK WAS POURING FUEL AFTER FILLING TO THE THREE-QUARTERS MARK AND PARKING IN OUR SUBTERRANEAN PARKING GARAGE. REPAIR COULD NOT BE AVOIDED. BASED ON LA AUDI'S POSITION, A LOCAL MECHANIC REPLACED THE ENTIRE TANK WITH A SALVAGE ONE HE FOUND. ATTACHED ARE PHOTOS, WORK REPAIR ORDERS, A HAZARD NOTE FROM NEIGHBOR OF THE FUEL LEAK, AND SIGNED DECLARATION THESE ITEM AS AUTHENTIC AND ALL ASSERTIONS ABOVE ARE TRUTHFUL. I APPRECIATE ASSISTANCE OBTAINING RECOVERY FROM AUDI FOR THE REPAIRS AS THEY REFUSED TO WHEN PRESENTED TWICE. YOUR ASSISTANCE IN THIS MATTER IS APPRECIATED. UPDATED PORTABLE 02/18/11
NHTSA ODI #10378891
Mileage unknown · Nov 3, 2010
Fuel System, Gasoline
I OWN A 2003 AUDI A6 QUATTRO 4.2L WHICH I BOUGHT USED AND HAVE DRIVEN IT SINCE 2004. ON OCTOBER 27, 2010 I STARTED SMELLING GAS AND AFTER CHECKING FOUND A LEAK AT THE BASE OF THE GAS TANK. I CHECKED THE WEB AND FOUND OUT THAT THERE IS A RECALL ON OTHER SUB-MODELS. I CALLED AUDI USA WHO CONTACTED A DEALER I CHOSE TO FIX THE PRO…
Read full complaint
I OWN A 2003 AUDI A6 QUATTRO 4.2L WHICH I BOUGHT USED AND HAVE DRIVEN IT SINCE 2004. ON OCTOBER 27, 2010 I STARTED SMELLING GAS AND AFTER CHECKING FOUND A LEAK AT THE BASE OF THE GAS TANK. I CHECKED THE WEB AND FOUND OUT THAT THERE IS A RECALL ON OTHER SUB-MODELS. I CALLED AUDI USA WHO CONTACTED A DEALER I CHOSE TO FIX THE PROBLEM. BUT THE DEALER IS SAYING THAT ALTHOUGH THE RECALL PROBLEM EXISTS IT IS DUE TO AN ACCIDENT WHICH HAPPENED 6 OR 7 YEARS AGO. I THINK THIS IS NOT FAIR. THANK YOU VIN [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10363917
101,000 miles · Oct 5, 2010
Electronic Stability Control (esc)Service Brakes, Hydraulic
I HAVE LOCKED MY BRAKES AND HAD A NEAR ACCIDENT. MY ABS AND ESP HAS STOPPED WORKING ON MY 2003 AUDI A6. I WAS TOLD THE ABS CONTROL UNITS ARE KNOWN TO GO BAD, AND WILL COST OVER A $1000 TO FIX. I CANNOT AFFORD TO FIX. IF THIS IS A WIDESPREAD PROBLEM, SHOULDN'T AUDI BE HELD ACCOUNTABLE FOR ANY TRAFFIC ACCIDENTS DUE TO FAILURE, A…
Read full complaint
I HAVE LOCKED MY BRAKES AND HAD A NEAR ACCIDENT. MY ABS AND ESP HAS STOPPED WORKING ON MY 2003 AUDI A6. I WAS TOLD THE ABS CONTROL UNITS ARE KNOWN TO GO BAD, AND WILL COST OVER A $1000 TO FIX. I CANNOT AFFORD TO FIX. IF THIS IS A WIDESPREAD PROBLEM, SHOULDN'T AUDI BE HELD ACCOUNTABLE FOR ANY TRAFFIC ACCIDENTS DUE TO FAILURE, AND SHOULD THERE BE A RECALL? *TR
NHTSA ODI #10359364
Mileage unknown · Sep 8, 2010
Electrical System
2003 AUDI A6. CONSUMER STATES PROBLEMS WITH GAUGE CLUSTER *TGW THE CONSUMER STATED THE WARNING GAUGES NO LONGER FUNCTIONED AND THE MULTI-FUNCTION LIQUID CRYSTAL DISPLAY DOES NOT INDICATE READABLE INFORMATION. *JB
NHTSA ODI #10354292
Mileage unknown · Jun 16, 2010
Fuel System, Gasoline
2003 AUDI A6. CONSUMER WRITES IN REGARDS TO FUEL LEVEL SENSOR DAMAGED DUE TO RECALL REPAIR *TGW THE CONSUMER STATED HE COMPLIED WITH THE RECALL AND TOOK HIS VEHICLE TO THE AUDI DEALER. THE DEALER FILLED THE GAS TANK; IN ACCORD WITH THE LETTER FROM AUDI. UNFORTUNATELY, AS THE CONSUMER DROVE THE 70 MILES BACK HOME, THE FUEL LEVEL…
Read full complaint
2003 AUDI A6. CONSUMER WRITES IN REGARDS TO FUEL LEVEL SENSOR DAMAGED DUE TO RECALL REPAIR *TGW THE CONSUMER STATED HE COMPLIED WITH THE RECALL AND TOOK HIS VEHICLE TO THE AUDI DEALER. THE DEALER FILLED THE GAS TANK; IN ACCORD WITH THE LETTER FROM AUDI. UNFORTUNATELY, AS THE CONSUMER DROVE THE 70 MILES BACK HOME, THE FUEL LEVEL DECREASED TO LESS THAT 1/4 AND THE WARNING LIGHT CAME ON. SINCE THEN, THE WARNING LIGHT COMES ON AND GOES OFF WITHOUT REGARD TO HOW MUCH FUEL IS IN THE TANK. THE CONSUMER ALSO STATED HE SMELLED GASOLINE PARTICULARLY IN THE MORNING TIME WHEN HE WENT TO HIS GARAGE. HE STATED HE WAS NOT ABLE TO RELY ON THE FUEL GAUGE BECAUSE IT SOMETIMES SHOWED FULL WHEN IT WAS LESS THAN 1/4 OF A TANK. THE CONSUMER STATED HE HAS RAN OUT OF GAS TWICE, ON A COUNTRY ROAD IN MID-WINTER. AFTER MAKING DOZENS OF FRUSTRATING CALLS TO AUDI, THEY FINALLY ARRANGED TO HAVE THE PROBLEM LOOKED AT. THE DEALER STATED THEY DIDN'T HAVE THE PART THEY NEEDED TO REPAIR THE DEFECT AND THEY WOULD CALL WHEN THE PART ARRIVED. THEY ESTIMATED THE REPAIR AT $483.64. THE CONSUMER STATED HE STILL HAS NOT HEARD FROM THE DEALER. THE CONSUMER STATED HE TOOK HIS VEHICLE TO THE DEALER WITH NO FUEL GAUGE PROBLEMS AND IT WAS RETURNED TO HIM WITH PROBLEMS. *JB
NHTSA ODI #10336975
109,598 miles · Jun 9, 2010
Electrical System
2003 AUDI A6. CONSUMER SEEKS REPLY FOR REQUEST FOR REIMBURSEMENT *TGW THE CHECK ENGINE LIGHT ILLUMINATED. THE CONSUMER TOOK THE VEHICLE TO A NEARBY REPUTABLE MECHANIC WHO REPLACED THE IGNITION COIL. THE CONSUMER IS SEEKING REIMBURSEMENT, SINCE AUDI ISSUED A VOLUNTARY CAMPAIGN STATING THEY WOULD REPLACE FOR FREE IF NEEDED. *JB
NHTSA ODI #10335926
59,900 miles · Mar 15, 2010
Power Train
CAR COMPLETELY STOPPED IN THE MIDDLE OF HIGHWAY AND CAR BEHIND ALMOST HIT ME. TRANSMISSION FAILED SUDDENLY. IT HAD TO BE REPLACED. RECURRING PROBLEM WITH AUDI A6 3.0 2003 CVT. *TR
NHTSA ODI #10320034
Official recalls
7May 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Apr 8, 2008
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Aug 28, 2007
ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 28, 20007. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834. THIS RECALL IS A SUPPLEMENT TO A PREVIOUS CAMPAIGN (PLEASE SEE 06V017).
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Jan 23, 2006
ON CERTAIN VEHICLES PRODUCED FROM SEPTEMBER 2002 - MARCH 2003, EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834.
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Oct 9, 2002
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3-SPOKE SPORT STEERING WHEELS, IT IS POSSIBLE THAT THE IGNITER FOR THE DRIVER'S SIDE AIR BAG MAY NOT HAVE BEEN PROPERLY ASSEMBLED.
Consequence & remedy
Consequence: AN IMPROPERLY POSITIONED IGNITER WILL NOT ACTIVATE THE AIR BAG IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE AIR BAGS. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Illustration