NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
87 reports23,000 miles · Jun 19, 2017
Wheels
1 CRACKED RIM AND 1 BENT RIM. THE CRACKED RIM CAUSED AIR TO LEAK FROM THE TIRE, SO I GOT I BECAME AWARE OF IT AFTER TAKING IT INTO A TIRE SHOP TO INVESTIGATE THE ISSUE. 8 MONTHS LATER I TAKE THE CAR BACK IN DUE TO A VIBRATION BETWEEN 35-40MPH AND I WAS SHOWN THAT THE RIM WAS BENT. I DON'T REMEMBER EVER HITTING ANYTHING HARD E…
Read full complaint
1 CRACKED RIM AND 1 BENT RIM. THE CRACKED RIM CAUSED AIR TO LEAK FROM THE TIRE, SO I GOT I BECAME AWARE OF IT AFTER TAKING IT INTO A TIRE SHOP TO INVESTIGATE THE ISSUE. 8 MONTHS LATER I TAKE THE CAR BACK IN DUE TO A VIBRATION BETWEEN 35-40MPH AND I WAS SHOWN THAT THE RIM WAS BENT. I DON'T REMEMBER EVER HITTING ANYTHING HARD ENOUGH TO THINK THAT I COULD HAVE CRACKED OR BENT A RIM. I QUESTION THE STRUCTURAL INTEGRITY OF THEIR 19" RIMS.
NHTSA ODI #10995871
45,000 miles · Jun 7, 2017
Electrical SystemEngineFuel/propulsion System
CHECK ENGINE/ EPC- BOTH LIGHTS HAVE SIGNALED A DOZEN TIMES. THE FIRST FEW TIMES THE DEALERSHIP CALLED THEM "MISFIRES". EVENTUALLY THE CAR "SYMPTOMS" STARTED TO PROGRESS: WHEN CAR IS IDLING, CAR STARTS TO ACT LIKE IT IS ABOUT TO STALL. THEN IT PROGRESSED TO HARD/JERKY SHIFTS INTO 1ST OR 2ND GEAR. NOW EVEN AT HIGHER SPEEDS …
Read full complaint
CHECK ENGINE/ EPC- BOTH LIGHTS HAVE SIGNALED A DOZEN TIMES. THE FIRST FEW TIMES THE DEALERSHIP CALLED THEM "MISFIRES". EVENTUALLY THE CAR "SYMPTOMS" STARTED TO PROGRESS: WHEN CAR IS IDLING, CAR STARTS TO ACT LIKE IT IS ABOUT TO STALL. THEN IT PROGRESSED TO HARD/JERKY SHIFTS INTO 1ST OR 2ND GEAR. NOW EVEN AT HIGHER SPEEDS IT STARTS ACTING UP- GIVING THE FEELING THAT THE CAR MAY STALL. THIS IS A DAILY ISSUE. TWICE NOW CAR HAS FAILED TO ACCELERATE WHILE ENTERING HIGHWAY. THE WORST SITUATION OCCURRED WHEN CAR WAS BUCKING AND REFUSING TO GO INTO 2ND GEAR. I HAD TO PULL OVER, ON THE ON-RAMP, TURN OFF CAR AND RESTART. DASH LIGHTS FADE LIGHT/DARK CONSTANTLY. ORIGINALLY I THOUGHT IT WAS AN AUTOMATIC FEATURE, GOING FROM DAY TO NIGHT TIME LIGHTS. LIKE EVERYTHING ELSE IT HAS INCREASED W/ FREQUENCY & CANNOT BE CONNECTED TO CHANGE DAY/NIGHT LIGHT SETTING CHANGE. KEY FOB DIED WHILE I WAS DRIVING ON HIGHWAY, CAR STALLED ON HIGHWAY. I RESTARTED CAR USING EMERGENCY PROCEDURE (ALIGNING KEY FOB NEXT TO KEY SYMBOL ON DRIVE SHAFT)- THIS IS MEANT TO KEEP CAR RUNNING EVEN W/ DEAD KEY BATTERY. CAR SHUT OFF MULTIPLE TIMES WAITING FOR TOW TRUCK- WHO THEN LOADED MY CAR WHILE RUNNING BECAUSE IT STALLED ON HIM TOO. DID I MENTION THE 4 DAYS PRIOR MY CAR HAD BEEN AT THE DEALERSHIP - SO EITHER WARNING SIGN DIDN'T CORRECTLY NOTIFY OR THEY JUST IGNORED IT. FIXED IGNITION COIL, SPARK PLUGS CURRENT DEALERSHIP DIAGNOSTIC: FAULT TO BAD INJECTOR SOMEHOW NONE OF THE RECALLS THAT APPLY TO 2015 A3S APPLY TO MY VEHICLE. EVEN THOUGH MOST OF THE DECRIPTIONS APPLY TO CAR ISSUES.
NHTSA ODI #10993707
28,000 miles · Jun 5, 2017
Air BagsSeat Belts
TL* THE CONTACT OWNS A 2015 AUDI A3. WHILE DRIVING, THE AIR BAG AND SEAT BELT WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (NIELLO AUDI LOCATED AT 2350 AUBURN BLVD SACRAMENTO, CA 95821, (916) 480-2800) APPROXIMATELY THREE MONTHS AGO, BUT THE DIAGNOSTIC RESULTS AND REPAIRS WERE UNKNOWN. THE CONTACT STAT…
Read full complaint
TL* THE CONTACT OWNS A 2015 AUDI A3. WHILE DRIVING, THE AIR BAG AND SEAT BELT WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (NIELLO AUDI LOCATED AT 2350 AUBURN BLVD SACRAMENTO, CA 95821, (916) 480-2800) APPROXIMATELY THREE MONTHS AGO, BUT THE DIAGNOSTIC RESULTS AND REPAIRS WERE UNKNOWN. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES AFTER THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 28,000.
NHTSA ODI #10993165
Mileage unknown · Jun 1, 2017
Engine
2015 AUDI A3. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE COMPARTMENT FIRE. *LD THE CONSUMER STATED THE ENGINE COMPARTMENT CAUGHT FIRE. THE VEHICLE SAT IN AN OPEN AIR SITE WITHOUT A HOOD OR WINDOWS, EXPOSED TO THE WINTER ELEMENTS. 13 DAYS LATER IT WAS INSPECTED BY THE MANUFACTURER, WHO DETERMINED THE FAILURE TO BE DUE TO ROD…
Read full complaint
2015 AUDI A3. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE COMPARTMENT FIRE. *LD THE CONSUMER STATED THE ENGINE COMPARTMENT CAUGHT FIRE. THE VEHICLE SAT IN AN OPEN AIR SITE WITHOUT A HOOD OR WINDOWS, EXPOSED TO THE WINTER ELEMENTS. 13 DAYS LATER IT WAS INSPECTED BY THE MANUFACTURER, WHO DETERMINED THE FAILURE TO BE DUE TO RODENT NESTING ACTIVITY. *JS
NHTSA ODI #10985349
26,000 miles · Mar 7, 2017
Unknown Or Other
AS I WAS DRIVING ON A STRAIGHTAWAY, I TURNED ON THE HEATER IN MY CAR AND WITHIN MINUTES I WAS FEELING EXTREMELY NAUSEOUS AND FELT LIKE I WAS LOSING CONTROL AND FOCUS. I TRIED TO FIGURE OUT WHAT WAS CAUSING THIS REACTION AND WHY I COULD SMELL A LIGHT FUME IN THE CAR AS THERE WERE NO OTHER VEHICLES IN FRONT OF ME. I TURNED AROUND …
Read full complaint
AS I WAS DRIVING ON A STRAIGHTAWAY, I TURNED ON THE HEATER IN MY CAR AND WITHIN MINUTES I WAS FEELING EXTREMELY NAUSEOUS AND FELT LIKE I WAS LOSING CONTROL AND FOCUS. I TRIED TO FIGURE OUT WHAT WAS CAUSING THIS REACTION AND WHY I COULD SMELL A LIGHT FUME IN THE CAR AS THERE WERE NO OTHER VEHICLES IN FRONT OF ME. I TURNED AROUND TO MY CHILDREN IN THE BACKSEAT TO ASK THEM IF THEY FELT OKAY, AND I SAW THAT THEY WERE NEARLY ASLEEP. I OPENED THE WINDOWS AND TURNED OFF THE HEATER SINCE I REALIZED THE CAR WAS FINE BEFORE I TURNED THE HEATER ON. I ALSO REALIZED IT WAS PROBABLY CARBON MONOXIDE POISONING THAT WAS CAUSING OUR SYMPTOMS. ALTHOUGH MY CHILDREN AND I ARE OKAY AS A RESULT OF MY QUICK ACTIONS, I COULD HAVE PASSED OUT AND CRASHED VERY BADLY, HURTING MY FAMILY AND OTHER INNOCENT PEOPLE.
NHTSA ODI #10959465
42,000 miles · Feb 12, 2017
Engine
VEHICLE WAS IN MOTION ON HIGHWAY TRAVELING AT 65 MPH. ENGINE CEASED WITHOUT WARNING. ABSOLUTELY NO POWER OR ENGINE NOISE WHEN ACCELERATING. VEHICLE WENT FROM 65 TO 0 MPH IN SECONDS. NO STEERING CONTROL AS WELL!! COULD HAVE BEEN KILLED. HEAD OF SERVICE AT AUDI DEALERSHIP SAYS THAT IT HAPPENS ALL THE TIME & AUDI IS DOING ABSOLUTEL…
Read full complaint
VEHICLE WAS IN MOTION ON HIGHWAY TRAVELING AT 65 MPH. ENGINE CEASED WITHOUT WARNING. ABSOLUTELY NO POWER OR ENGINE NOISE WHEN ACCELERATING. VEHICLE WENT FROM 65 TO 0 MPH IN SECONDS. NO STEERING CONTROL AS WELL!! COULD HAVE BEEN KILLED. HEAD OF SERVICE AT AUDI DEALERSHIP SAYS THAT IT HAPPENS ALL THE TIME & AUDI IS DOING ABSOLUTELY NOTHING. SAID DO NOT TAKE CAR BACK...THEY'RE PLAYING "RUSSIAN ROULETTE" WITH YOUR LIFE AND WON'T DO ANYTHING UNTIL SOMEONE GETS KILLED.....UPDATED 06/21/17 *BF *CN
NHTSA ODI #10954092
15,000 miles · Feb 3, 2017
Structure
POOR PAINT. HEADLIGHTS AND PAINT CHIP AND HAVE SMALL DEFECTS CAUSED EASILY FROM NORMAL TRAVEL.
NHTSA ODI #10949301
50,000 miles · Dec 23, 2016
Visibility
TL* THE CONTACT OWNS A 2015 AUDI A3. WHILE DRIVING APPROXIMATELY 55 MPH, THE PANORAMIC SUN ROOF EXPLODED WITHOUT WARNING. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 50,000. UPDATED 02/14/17*LJ
NHTSA ODI #10937190
Mileage unknown · Nov 11, 2016
Fuel/propulsion System
MY AUDI CAR HASNT BEEN RUNNING WELL. I WENT TO MY DEALERSHIP AND NO SENSE OF URGENCY REGARDING THIS MATTER, WAS TOLD THEY WILL CALL ME WHEN THEY HAVE IT BUT "I SHOULD BE FINE". I LEFT MY CAR AT THE DEALERSHIP FOR AN OIL CHANGE 11.11.16 BUT DOESNT FIX THE RECALL "SAFTEY RECALL 20Y5 SUCTION PUMP" . THIS RECALL NOT GETTING FIXED IS…
Read full complaint
MY AUDI CAR HASNT BEEN RUNNING WELL. I WENT TO MY DEALERSHIP AND NO SENSE OF URGENCY REGARDING THIS MATTER, WAS TOLD THEY WILL CALL ME WHEN THEY HAVE IT BUT "I SHOULD BE FINE". I LEFT MY CAR AT THE DEALERSHIP FOR AN OIL CHANGE 11.11.16 BUT DOESNT FIX THE RECALL "SAFTEY RECALL 20Y5 SUCTION PUMP" . THIS RECALL NOT GETTING FIXED IS PUTTING MY SAFETY AT RISK.
NHTSA ODI #10925550
21,000 miles · Jul 19, 2016
StructureVisibility/wiper
I WAS DRIVING AND SUDDENLY HEARD A LOUD EXPLOSION ON THE TOP OF ME, THEN I SAW A MY SUNROOF CRACKED. I STOPPED TO CHECK ON IT AND I CONTINUED DRIVING FOR ABOUT A MILE UNTIL PART OF THE SUNROOF BLEW OFF AND HIT OTHER CARS. NOTHING HIT THE GLASS FOR IT TO BRAKE, IT SIMPLY EXPLODED FROM THE INSIDE OUT (PRESSURE-LIKE EXPLOSION). DEA…
Read full complaint
I WAS DRIVING AND SUDDENLY HEARD A LOUD EXPLOSION ON THE TOP OF ME, THEN I SAW A MY SUNROOF CRACKED. I STOPPED TO CHECK ON IT AND I CONTINUED DRIVING FOR ABOUT A MILE UNTIL PART OF THE SUNROOF BLEW OFF AND HIT OTHER CARS. NOTHING HIT THE GLASS FOR IT TO BRAKE, IT SIMPLY EXPLODED FROM THE INSIDE OUT (PRESSURE-LIKE EXPLOSION). DEALER SAYS IT HAS NO RECALL AT THE MOMENT FOR MY VEHICLE BUT WHILE DOING MY RESEARCH, I FOUND OUT THAT AUDI CAR OWNERS HAVE HAD THE EXACT SAME PROBLEM IN THE PAST WITH NO RESOLUTION YET. CHASSIS MIGHT CAUSE EXTRA TENSION ON SUNROOF CREATING IT TO EXPLODE, OR INSIDE PRESSURE IS TOO STRONG FOR THE GLASS TO RESIST. SUNROOF AND WINDOWS WERE UP (CLOSED) AT THE TIME OF THE INCIDENT.
NHTSA ODI #10886016
Official recalls
5Jun 19, 2019
Volkswagen Group of America, Inc. (Audi) is recalling certain 2015-2016 Audi S3 Sedan, 2015-2019 A3 Sedan and A3 Cabriolet, 2016-2018 A3 e-tron, and 2017-2019 RS3 vehicles. An improper electrical contact may cause the Passenger Occupant Detection System (PODS) to falsely detect a malfunction and deactivate the passenger air bag.
Consequence & remedy
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Audi will notify owners, and dealers will replace the connector and reroute the cable, free of charge. The recall began September 12, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Audi's number for this recall is 69Z4.
Apr 26, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015 Audi A3 1.8T FWD S tronic and 2.0T Quattro S tronic vehicles. The safety certification label has an incorrect vehicle production date. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence & remedy
Consequence: In the event of a vehicle safety recall, an incorrect production date may prevent owners from determining if the recall affects them, increasing their risk of injury or a crash.
Remedy: Audi will notify owners, and dealers will install an overlay label containing the correct vehicle production date, free of charge. The recall June 23, 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 51F5.
Sep 7, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence & remedy
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Additional source detail variants (2)
Fuel System, Gasoline
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Engine And Engine Cooling:exhaust System:emission Control
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Dec 8, 2015
Volkswagen Group of America, LLC (Volkswagen) is recalling certain model year 2015 Audi A3 Cabriolet vehicles manufactured June 5, 2014, to April 1, 2015. The affected vehicles have a driver or front passenger seat whose cover may be incorrectly stitched, preventing the side air bag from properly deploying in the event of a crash.
Consequence & remedy
Consequence: Improper side air bag deployment may increase the risk of injury in the event of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's and/or front passenger's seatback cover, free of charge. Owners were mailed interim notices on February 4, 2016. The recall began on February 29, 2016 . Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 74C9.
Additional source detail variants (2)
Seats
Volkswagen Group of America, LLC (Volkswagen) is recalling certain model year 2015 Audi A3 Cabriolet vehicles manufactured June 5, 2014, to April 1, 2015. The affected vehicles have a driver or front passenger seat whose cover may be incorrectly stitched, preventing the side air bag from properly deploying in the event of a crash.
Consequence: Improper side air bag deployment may increase the risk of injury in the event of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's and/or front passenger's seatback cover, free of charge. Owners were mailed interim notices on February 4, 2016. The recall began on February 29, 2016 . Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 74C9.
Air Bags:side/window
Volkswagen Group of America, LLC (Volkswagen) is recalling certain model year 2015 Audi A3 Cabriolet vehicles manufactured June 5, 2014, to April 1, 2015. The affected vehicles have a driver or front passenger seat whose cover may be incorrectly stitched, preventing the side air bag from properly deploying in the event of a crash.
Consequence: Improper side air bag deployment may increase the risk of injury in the event of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's and/or front passenger's seatback cover, free of charge. Owners were mailed interim notices on February 4, 2016. The recall began on February 29, 2016 . Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 74C9.
Apr 17, 2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015 Volkswagen Golf, and GTI manufactured on February 17, 2014, to May 22, 2014, and Audi A3 manufactured on February 16, 2013, to April 23, 2014. Improper nickel plating of components within the fuel pump may result in the fuel pump failing.
Consequence & remedy
Consequence: If the fuel pump fails, the vehicle will not start, or if the engine is running, it will stop and the vehicle will stall, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the vehicles and replace any affected fuel pumps, free of charge. The recall began on June 16, 2015. Owners may contact Volkswagen at 1-800-893-5298 or Audi at 1-800-253-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration