SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2004 Aprilia Rsv Mille

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
3Owner complaints

Model-year median: 2

0Recall campaigns

View recall details →

0Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
1
20033
2004
Compare all Rsv Mille years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Fuel System, Gasoline
2Service Brakes, Hydraulic
2Electrical System
1Power Train
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 2 of 3 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Fuel System, Gasoline. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Fuel System, Gasoline complaints

2 reports
Clear category filter
1,000 miles · Jul 10, 2006
Electrical SystemFuel System, GasolinePower Train

RE 2004 RSV MILLE FACTORY MOTORCYCLE. 5/10/04 HARD TO SHIFT GEARS AND FIND NEUTRAL BECAUSE THE CLUTCH WAS NOT DISENGAGING FULLY WHILE DRIVING. THEREFORE DIFFICULT TO STOP MOTORCYCLE. DEALER BLED CLUTCH LINE. 7/20/04 ENGINE TURNED OFF WHILE I WAS RIDING AT ABOUT 35-40 MILES PER HOUR AND THE REAR WHEEL UNEXPECTEDLY LOCKED U…

Read full complaint

RE 2004 RSV MILLE FACTORY MOTORCYCLE. 5/10/04 HARD TO SHIFT GEARS AND FIND NEUTRAL BECAUSE THE CLUTCH WAS NOT DISENGAGING FULLY WHILE DRIVING. THEREFORE DIFFICULT TO STOP MOTORCYCLE. DEALER BLED CLUTCH LINE. 7/20/04 ENGINE TURNED OFF WHILE I WAS RIDING AT ABOUT 35-40 MILES PER HOUR AND THE REAR WHEEL UNEXPECTEDLY LOCKED UP. ELECTRICAL WIRE AND CONNECTORS MELTED DUE TO ENGINE HEAT. REPLACE AND REROUTED WIRES. 2/8/05 LEAKING GASOLINE FROM THE FUEL CAP. FUEL CAP WAS REPLACED UNDER WARRANTY BECAUSE IT WAS DEFECTIVE. DEALER FOUND THAT THERE WAS NO REAR BRAKE AND NOTED THIS SPECIFICALLY AS A SAFETY ITEM AND THAT AGAIN THERE WAS VERY LITTLE CLUTCH DISENGAGEMENT. NOTE THE PARAGRAPH ABOVE REGARDING THE CLUTCH. 10/2005 STARTER WAS MELTED AND BATTERY WAS NOT CHARGING. NO REPAIR AFTER 9 MONTHS THOUGH WAS UNDER WARRANTY. POTENTIAL WHEEL SEIZURE WHEN BATTERY FAILS. *NM

NHTSA ODI #10162034

5,000 miles · May 10, 2005
Fuel System, Gasoline

DT: FUEL LINE QUICKLY DISCONNECTED ON 2004 APRILIA RST FUTURA. CALLER WAS TRYING TO DISCONNECT FUEL LINE. WHEN IT WAS TOUCHED IT FELL APART IN HANDS. BOUGHT NEW METAL, QUICKLY DISCONNECTED FUEL LINE THAT REPLACED THE ONE THAT BROKE.*AK

NHTSA ODI #10120567

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.