NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
14 reportsClear category filterMileage unknown · May 27, 2026
EngineFuel/propulsion SystemPower Train
I am formally requesting a neutral third-party arbitration review under the Magnuson-Moss Warranty Act to compel American Honda Motor Co. to provide a permanent mechanical remedy—specifically, the sourcing and installation of a brand-new, redesigned engine assembly (Engine #Four)— This vehicle frame is now on its third engine bl…
Read full complaint
I am formally requesting a neutral third-party arbitration review under the Magnuson-Moss Warranty Act to compel American Honda Motor Co. to provide a permanent mechanical remedy—specifically, the sourcing and installation of a brand-new, redesigned engine assembly (Engine #Four)— This vehicle frame is now on its third engine block. Car was bought 11/30/2024. At Grubbs Acura, fuel pump safety recall that involves flashing/re-calibrating the Engine Control Unit (FI-ECU) software was done. Just a few weeks after new fuel pump, the vehicle displayed sudden stalling symptoms. The engine suffered a terminal, catastrophic internal collapse. The vehicle was towed to Grubbs Acura where Corporate Honda directed a forced out-of-pocket internal engine teardown. The physical teardown explicitly confirmed a catastrophic connecting rod bearing failure (spun bearing) identical to the structural manufacturing flaws currently under active federal investigation by the NHTSA under Preliminary Evaluation PE25008 / RQ24-025. Corporate Honda subsequently issued a verbal agreement to fully reimburse my out-of-pocket teardown fees. Because a manufacturer will never fund diagnostic labor if evidence of owner fault is present, this corporate reimbursement serves as formal validation that no owner maintenance neglect occurred, and that the engine died exclusively from an inherent component defect. Gunn Acura (San Antonio, TX) confirmed with my vin, that Engine #3 was a warranty/dealer-installed replacement unit at 22,000 miles. It failed after less than 40,000 miles of total operation. A professionally manufactured and dealer-installed engine is reasonably expected to last well beyond 40,000 miles. The manufacturer network cannot utilize arbitrary part-ownership rules or uncooperative, fragmented dealer communications. The original factory-installed engine and the dealer-installed replacement engine both suffered identical connecting rod bearing failures.
NHTSA ODI #11740358
Mileage unknown · Oct 1, 2025
Fuel/propulsion System
I had the stop bearing rod recall performed on my 2019 Acura TLX along with a fuel pump recall. After less than 10,000 miles I am informed that my high pressure fuel pump has failed. When the did the recall on the vehicle they only did the low pressure fuel pump when there is known issue of the high pressure fuel pump failing.
NHTSA ODI #11690741
Mileage unknown · Feb 13, 2025
EngineFuel/propulsion System
On several occasions I have experienced issues with the performance of my vehicle. Upon start up and attempting to move forward while the car is in drive the vehicle hesitates to move and feels like it is going to choke and stop. I have experienced this same issue at stops while the car is in operation. There is an open recall f…
Read full complaint
On several occasions I have experienced issues with the performance of my vehicle. Upon start up and attempting to move forward while the car is in drive the vehicle hesitates to move and feels like it is going to choke and stop. I have experienced this same issue at stops while the car is in operation. There is an open recall for 2015-20 TLX no SH-AWD Fuel Pump Mtr Saf Recall Exp2, RECALL DATE:12/18/2023 which has yet to be fixed. I have been told by Tempe Acura that the parts are not available and basically I will be called when the parts are available. My safety and the safety of others are at risk when the car is not accelerating and causing a stalling or non-movement of the car. I have experienced the car stalling abruptly and coming to hard stops. The problem has been confirmed by the dealer by notice in the mail. The vehicle has been inspected when another recall was fixed which took over a year to resolve. This specific issue has yet to be resolved. There was another issue of the car stalling, which the dealer states that the electronic system needed a computer update. The problem first appeared when I purchased the car from {XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11642588
Mileage unknown · Feb 7, 2025
EngineFuel/propulsion System
1. Fuel pump module and engine crankshaft. 2. For the fuel pump module, the engine may not start or can stall while driving; increasing the risk of crashing or injury. For the engine crankshaft, the connecting rod bearing can prematurely wear and seize, causing engine damage. The damaged engine may run improperly or stall while…
Read full complaint
1. Fuel pump module and engine crankshaft. 2. For the fuel pump module, the engine may not start or can stall while driving; increasing the risk of crashing or injury. For the engine crankshaft, the connecting rod bearing can prematurely wear and seize, causing engine damage. The damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury. 3. The problem hasn’t been reproduced or confirmed by the dealer. 4. The vehicle hasn’t been inspected. 5. There were no warning signs. I have received letters in mail regarding the recalls, however the dealership has advised the first available appointment to service my car is September 2025.
NHTSA ODI #11641434
Mileage unknown · Sep 5, 2024
Fuel/propulsion System
Driving on the hwy on left most lane, car started jerking when accelerating and slowing when hitting the accelerator. Check engine light blinks on and off while this is happening. Scary and terrifying moment on the hwy, was able to get into emergency lane and slowly get car off hwy into parking lot. Got the car towed to Acura, t…
Read full complaint
Driving on the hwy on left most lane, car started jerking when accelerating and slowing when hitting the accelerator. Check engine light blinks on and off while this is happening. Scary and terrifying moment on the hwy, was able to get into emergency lane and slowly get car off hwy into parking lot. Got the car towed to Acura, they ran "diagnostics" and could not replicate the problem or even find the check engine code. They recommended 7 items of which some were complete nonsense and upselling instead of finding the solution to dangerous problem. Seems like the fuel pump issue and they won't confirm anything. Saying I need at oil change with 40% left on indicator, tire rotation, ac filter, and other non sense upsells instead of finding the problem that almost caused accident. Acura dealership had no clue when fuel pump part will come in and I have no other vehicle. NHTSA needs to fine Acura and tell them to stop selling new cars and fix the 2.5 million on the road today with problem. Need help on this!
NHTSA ODI #11612915
Mileage unknown · Aug 23, 2024
Fuel/propulsion System
My car has had problems with the fuel pump... I have made an appointment at the Acura dealership three times now and when I take the car in they tell me that they don't have the part that needs to be replaced...
NHTSA ODI #11610551
Mileage unknown · Aug 7, 2024
EngineFuel/propulsion System
I received two recalls and multiple notices saying the parts are not available for the recall. Over 6 months later I receive a notice the parts are finally available. I tried to make an appointment with my local dealer and was told they will not repair unless the check engine light is on. If what happens in the recall (fire, c…
Read full complaint
I received two recalls and multiple notices saying the parts are not available for the recall. Over 6 months later I receive a notice the parts are finally available. I tried to make an appointment with my local dealer and was told they will not repair unless the check engine light is on. If what happens in the recall (fire, crash or injury), how will I be able to get the check engine light to come on? I'm afraid to drive the car because I don't want to be stranded, plus I don't want the car to catch fire, cause a crash or be injured. Why isn't Honda/Acura making the parts to correct this problem and why is the dealer not complying with the recall notices I'm receiving? On the Acura recall website, when I enter my VPN, it notes to please take immediate action to have your vehicle repaired but the dealer won't do it! As I'm looking at the additional details below...it appears that a fire, crash or injury needs to happen. Unbelievable!
NHTSA ODI #11606989
Mileage unknown · Nov 28, 2023
EngineFuel/propulsion SystemUnknown Or Other
It was a recall on my car trying to be proactive about the situation.
NHTSA ODI #11557343
Mileage unknown · Mar 14, 2022
Fuel/propulsion System
NHTSA RECALL NUMBER:19V-060 appears to be EXACTLY what is going on with my vehicle. I was broke down on the side of the road with warning lights on my dashboard. After having it towed to my mechanic they were able to identify the issue is related to the fuel pump. I looked up issues with my 2019 Acura TLX and fuel pumps and foun…
Read full complaint
NHTSA RECALL NUMBER:19V-060 appears to be EXACTLY what is going on with my vehicle. I was broke down on the side of the road with warning lights on my dashboard. After having it towed to my mechanic they were able to identify the issue is related to the fuel pump. I looked up issues with my 2019 Acura TLX and fuel pumps and found that there is a recall. Only my VIN does not qualify for the recall. However, the issue described in the recall is EXACTLY what's going on with my TLX. I was lucky enough not to have an accident but I very well could of if I had not pulled off the highway!
NHTSA ODI #11456640
Mileage unknown · Oct 21, 2021
EngineFuel/propulsion System
My Acura TLX engine Drive reduced completely on the highway, Went going 60 to 25 roughly up to date maintenance 100% oil life and Now Im concern that’s my vechile has been manufactured failed. Since I purchased my vehicle my seat beats get stuck unable to clip belt. My car came with speakers not working dealer tried to tell me I…
Read full complaint
My Acura TLX engine Drive reduced completely on the highway, Went going 60 to 25 roughly up to date maintenance 100% oil life and Now Im concern that’s my vechile has been manufactured failed. Since I purchased my vehicle my seat beats get stuck unable to clip belt. My car came with speakers not working dealer tried to tell me I was crazy, until the speaker system was check Yess sure enough no speaker sound at all. In my main base front center Speaker ( VeryBig Deal) all of this last Friday my TLX aspec 3.5v6 has been Making noise and running at a very low reduced speed for no apparent reason while flashing a Engine sign. Flash blank with warning engine. This Event has put me at risk of safety and protection of customer purchase violations as I developed change in my daily life being blind sided about my Acura TLX Car safety and manufacturing issues. I complaint about this after purchase of vechile and They fixed the repair at no charge. But who wants they car ripped apart never in same fresh condition as purchase. I now receive bends in dash board related to speaking replacements documented in Acura Profile. Yes it hasn’t been my car has been diagnostic and going for rare down of engine components at the Acura dealer. This is outrageous and so scary knowing I have too been dealt a bad TLX.
NHTSA ODI #11437589
Official recalls
6May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Mar 25, 2021
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Acura MDX, MDX Sport Hybrid, RDX, TLX, Honda Accord, Civic Hatchback, Insight, 2019 Acura ILX, Honda Accord Hybrid, Civic Coupe, Civic Coupe Si, Civic Sedan, Civic Sedan Si, Civic Type R, Fit, HR-V, Odyssey, Passport, Pilot and Ridgeline, and 2018-2019 CR-V vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the fuel pump assembly, free of charge. Owner letters were mailed May 18, 2021. Owners may contact Honda customer service at 1-888-234-2138. Note: This recall is an expansion of recall 20V-314.
Apr 12, 2019
Honda (American Honda Motor Co.) is recalling certain 2018-2019 Acura MDX and Honda Pilot vehicles and 2019 Acura RLX, RLX Sport Hybrid, TLX and Honda Odyssey and Ridgeline vehicles. The timing belt teeth may separate from the belt.
Consequence & remedy
Consequence: Teeth separation from the timing belt may result in an engine stall, increasing the risk of crash.
Remedy: Honda will notify owners, and dealers will inspect the vehicle and replace any affected timing belt free of charge. Vehicles receiving a replacement timing belt will also have the engine inspected and any damaged components will be replaced for free. The recall began June 7, 2019. Honda owners may contact customer service at 1-888-234-2138. Honda's number for this recall is L4M. Acura owners may contact customer service at 1-888-234-2138. Acura's number for this recall is Z4L.
Jan 29, 2019
Honda (American Honda Motor Co.) is recalling certain 2016-2018 Acura MDX, 2015-2019 Acura TLX and 2015-2017 Honda Accord vehicles, equipped with a 3.5L V6 engine. Particulates in fuel may adhere to the internal components of the fuel pump, reducing its performance.
Consequence & remedy
Consequence: Reduced fuel pump performance can result in an engine stall, increasing the risk of crash.
Remedy: Honda will notify owners, and dealers will update the fuel injection engine control unit (FI-ECU) software and, if necessary, replace the fuel pump, free of charge. The recall began March 25, 2019. Owners may contact customer service at 1-888-234-2138. Acura's recall number for this recall is P3W. Honda's recall number for this recall is N3X.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
Illustration