TL* THE CONTACT OWNS A 2004 ACURA TL. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE AIR BAG WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THE DASHBOARD WAS CRACKED AROUND THE PASSENGER SIDE AIR BAG. THE CONTACT ALSO STATED THAT WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE DECELERATED A…
Read full complaint
TL* THE CONTACT OWNS A 2004 ACURA TL. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE AIR BAG WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THE DASHBOARD WAS CRACKED AROUND THE PASSENGER SIDE AIR BAG. THE CONTACT ALSO STATED THAT WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE DECELERATED AS THE CHECK ENGINE WARNING LIGHT FLASHED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE AIR BAG SENSOR NEEDED TO BE RESET. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 81,000.
NHTSA ODI #10894282
100,000 miles · Jul 23, 2016
Air BagsUnknown Or Other
MAJOR CRACKS AROUND PASSENGER SIDE AIRBAG ON 2004 ACURA TL. APPARENTLY THOUSANDS OF OTHER TL OWNERS ARE EXPERIENCING THIS DEFECT. THE CRACKS APPEAR TO AFFECT THE AIRBAG FUNCTIONALITY. QUOTES IN TERMS OF REPLACEMENT ARE AROUND $1800. HOWEVER, THIS IS HAPPENING NOT DUE TO OWNER ERROR OR FAULT, BUT RATHER TO ALL ACURAS, GARAGE STOR…
Read full complaint
MAJOR CRACKS AROUND PASSENGER SIDE AIRBAG ON 2004 ACURA TL. APPARENTLY THOUSANDS OF OTHER TL OWNERS ARE EXPERIENCING THIS DEFECT. THE CRACKS APPEAR TO AFFECT THE AIRBAG FUNCTIONALITY. QUOTES IN TERMS OF REPLACEMENT ARE AROUND $1800. HOWEVER, THIS IS HAPPENING NOT DUE TO OWNER ERROR OR FAULT, BUT RATHER TO ALL ACURAS, GARAGE STORED AND OTHERWISE.
NHTSA ODI #10887983
80,000 miles · Jul 1, 2016
Air Bags
TAKADA RECALL I AM HOPING YOU CAN FIND OUT INFORMATION FOR 2004 TL OWNERS. HONDA AND ACURA'S FOR THE YEARS 2001-03 AND 05 AND BEYOND HAVE BEEN INCLUDED IN THE TAKATA RECALL. I FIND IT HARD TO BELIEVE THAT 04 ACURA TLS HAVE AIRBAGS SOURCED FROM A COMPANY OTHER THAN TAKATA. AND I HAVE BEEN UNABLE TO FIND ANY RELIABLE IN…
Read full complaint
TAKADA RECALL I AM HOPING YOU CAN FIND OUT INFORMATION FOR 2004 TL OWNERS. HONDA AND ACURA'S FOR THE YEARS 2001-03 AND 05 AND BEYOND HAVE BEEN INCLUDED IN THE TAKATA RECALL. I FIND IT HARD TO BELIEVE THAT 04 ACURA TLS HAVE AIRBAGS SOURCED FROM A COMPANY OTHER THAN TAKATA. AND I HAVE BEEN UNABLE TO FIND ANY RELIABLE INFORMATION OUT FROM ACURA OR HONDA. I WOULD LIKE TO UNDERSTAND WHY THE 04 ACURA TLS ARE NOT LISTED IN THE RECALL, YET ACURA AND HONDA CARS IN THE YEARS BEFORE AND AFTER 04 ARE. I EVEN CONTACTED THE DEALERSHIP ABOUT HAVING A PROACTIVE AIR BAG REPLACEMENT EVEN THOUGH THE 04 ACURA TL IS CURRENTLY NOT PART OF THE RECALL. I WAS TOLD THEY COULD REPLACE THE AIRBAG, BUT THAT THE REPLACEMENT WOULD BE THE SAME AIRBAG THAT THE CAR WAS MANUFACTURED WITH. I WOULD LIKE ADDITIONAL INFORMATION TO BE PROVIDED WHY ACURA/HONDA IS CONVINCED THAT THE 2004 ACURA TLS DO NOT NEED TO BE INCLUDED IN THE RECALL. ANY HELP THE GOVERNMENT CAN PROVIDE WOULD BE APPRECIATED. THANKS.
NHTSA ODI #10882015
130,000 miles · Jun 4, 2016
Air Bags
2004 ACURA TL WITH APPROX 130,000 MILES. CRACK AROUND THE PASSENGER SIDE AIRBAG. STARTED 2 WEEKS AGO AND IS GETTING LARGER. VEHICLE WITH NO AIRBAG DEPLOYMENT OR ACCIDENT HISTORY.
NHTSA ODI #10872531
Mileage unknown · May 20, 2016
Air Bags
TAKATA RECALL PROBLEM...PASSENGER SIDE OF CAR ON DASHBOARD-OUTLINE OF AIRBAG APPEARED, BREAK IN LEATHER ON DASHBOARD. NO CAR ACCIDENT OCCURRED. AIRBAG HAS NOT DEPLOYED AS OF YET. NOTICED CRACK ON DASHBOARD WEEK OF 5/15/2016
NHTSA ODI #10870088
69,620 miles · May 12, 2016
Air BagsUnknown Or Other
MY DASHBOARD HAS TWO LARGE CRACKS RUNNING THE WIDTH OF THE DASHBOARD, ALONG WHERE THE AIRBAGS ARE SUPPOSED TO DEPLOY. NO ACCIDENT CAUSED THIS DEFECT.
NHTSA ODI #10864641
120,000 miles · May 1, 2016
Air Bags
AIRBAG LIGHT SENSOR ON DASHBOARD ALWAYS.
NHTSA ODI #10862439
110,000 miles · May 1, 2016
Air Bags
AIR BAG LIGHT SENSOR IS ON AND ALL THE DASH IS CRACKED AND WE ARE AFRAID THE AIR BAG WILL NOT DEPLOY IN A ACCIDENT OR RANDOMLY WILL DEPLOY WITHOUT A ACCIDENT.
NHTSA ODI #10862437
Mileage unknown · Apr 26, 2016
Air BagsUnknown Or Other
MULTIPLE CRACKS ON THE DASHBOARD THAT ARE CLOSE TO THE PASSENGER AIRBAG ON THE FRONT RIGHT HAND SIDE. CRACKS ALSO HAPPEN THROUGHOUT THE DASHBOARD BY THE INSTRUMENT CLUSTER AND THE MIDDLE CLOSE TO THE WINDSHIELD. VERY BAD MATERIAL ACURA USED TO MAKE THESE WITH. SHOULD BE A RECALL DUE TO THE SAFETY ISSUE WITH THE AIRBAG ALSO.
NHTSA ODI #10861582
Mileage unknown · Apr 15, 2016
Air BagsStructure
THE DASHBOARD STARTED CRACKING. NOW, IT HAS CRACKS ALL OVER. PASSENGER SIDE AND DRIVER SIDE. THIS MAY CAUSE ISSUE WITH THE AIRBAGS. I LOOKED ON LINE AND THIS IS VERY COMMON IN 2004 TLS. ACURA REFUSES TO FIX THE ISSUE. SOME HAVE ALSO EXPERIENCED ISSUES WITH THEIR AIR BAGS DUE TO THE CRACKING.
Honda (American Honda Motor Co.) is recalling specific 2003 Acura 3.2CL, 2013-2016 ILX, 2013-2014 ILX Hybrid, 2003-2006 MDX, 2007-2016 RDX, 2002-2003 3.2TL, 2004-2006, and 2009-2014 TL, 2010-2013 ZDX and 2001-2007 and 2009 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2007 and 2010-2011 CR-V, 2003-2011 Element, 2007 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The affected vehicles received a replacement driver air bag inflator as part of a previous Takata inflator recall remedy or a replacement driver air bag module containing the same inflator type as a service part. Due to a manufacturing error, in the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode.
Consequence & remedy
Consequence: An explosion of an inflator within the driver frontal air bag module may result in sharp metal fragments striking the driver, front seat passenger or other occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the driver's air bag inflator with an alternate inflator, free of charge. The recall began April 10, 2019. Honda owners may contact customer service at 1-888-234-2138. Honda's number for this recall is O41. Acura owners may contact customer service at 1-888-234-2138. Acura's number for this recall is U40.
HONDA IS RECALLING 273,000 MY 2004-2008 ACURA TL VEHICLES. PROLONGED HIGH UNDER-HOOD TEMPERATURES MAY CAUSE THE POWER STEERING HOSE TO DETERIORATE PREMATURELY CAUSING THE HOSE TO CRACK AND LEAK POWER STEERING FLUID.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKING ONTO A HOT CATALYTIC CONVERTER WILL GENERATE SMOKE AND POSSIBLY LEAD TO AN UNDER-HOOD FIRE.
Remedy: DEALERS WILL INSTALL A NEW HEAT RESISTANT POWER STEERING HOSE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 28, 2008. OWNERS MAY CONTACT ACURA AT 800-382-2238. THIS IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 07V551).
HONDA IS RECALLING 129,600 MY 2004-2005 ACURA TL VEHICLES. IF WATER ENTERS THE WINDSHIELD WIPER MOTOR BREATHER PORT, WHICH IS DESIGNED TO ALLOW THE MOTOR TO VENT WARM AIR DURING NORMAL OPERATION, IT CAN RESULT IN CORROSION INSIDE THE MOTOR HOUSING. THIS COULD CAUSE A FAILURE OF THE ELECTRICAL CIRCUIT BREAKER INSIDE THE MOTOR HOUSING.
Consequence & remedy
Consequence: IF THE CIRCUIT BREAKER FAILS, IT WILL CAUSE THE WINDSHIELD WIPER MOTOR TO BECOME INOPERATIVE, WHICH CAN INCREASE THE LIKELIHOOD OF A CRASH IN CERTAIN CONDITIONS.
Remedy: DEALERS WILL INSPECT THE WINDSHIELD WIPER MOTOR FOR SIGNS OF CORROSION. IF NO SIGNS OF CORROSION ARE PRESENT, A SNORKEL TUBE WILL BE ADDED TO THE WIPER MOTOR BREATHER PORT TO PREVENT WATER FROM ENTERING THE WIPER MOTOR HOUSING AND FOAM TAPE WILL BE INSTALLED ON THE COWL ABOVE THE WIPER MOTOR TO DIRECT WATER AWAY FROM THE WIPER MOTOR. IF SIGNS OF CORROSION DAMAGE ARE OBSERVED ON THE WIPER MOTOR, THE MOTOR WILL BE REPLACED, AND THE BREATHER TUBE AND FOAM TAPE WILL ALSO BE INSTALLED TO PREVENT WATER INTRUSION ON THE NEW WIPER MOTOR. THE RECALL BEGAN ON APRIL 28, 2008. OWNERS MAY CONTACT ACURA AT 1-800-382-2238.
ON SOME MINI VANS, SPORT UTILITY AND PASSENGER VEHICLES, CERTAIN OPERATING CONDITIONS CAN RESULT IN HEAT BUILD-UP BETWEEN THE COUNTERSHAFT AND SECONDARY SHAFT SECOND GEARS IN THE AUTOMATIC TRANSMISSION, EVENTUALLY LEADING TO GEAR TOOTH CHIPPING OR GEAR BREAKAGE.
Consequence & remedy
Consequence: GEAR FAILURE COULD RESULT IN TRANSMISSION LOCKUP, WHICH COULD RESULT IN A CRASH.
Remedy: ON VEHICLES WITH 15,000 MILES OR LESS, THE DEALER WILL UPDATE THE TRANSMISSION WITH A SIMPLE REVISION TO THE OIL COOLER RETURN LINE TO INCREASE LUBRICATION TO THE SECOND GEAR. ON VEHICLES WITH MORE THAN 15,000 MILES, THE DEALER WILL INSPECT THE TRANSMISSION TO IDENTIFY GEARS THAT HAVE ALREADY EXPERIENCED DISCOLORATION DUE TO OVERHEATING. IF DISCOLORATION EXISTS, THE TRANSMISSION WILL BE REPLACED IF DISCOLORATION IS NOT PRESENT, THE DEALER WILL PERFORM THE REVISION TO THE OIL COOLER RETURN LINE. THE RECALL BEGAN ON APRIL 21, 2004, FOR PILOT, ODYSSEY, AND MDX OWNERS. OWNERS OF THE ACCORD VEHICLES WILL START RECEIVING LETTERS ON JUNE 28, 2004, AND ON JUNE 29, 2004, FOR OWNERS OF THE TL AND CL VEHICLES. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE07060 · Windshield Wiper Motor Failure
Opened Nov 29, 2007 · Closed Mar 5, 2008
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED FEBRUARY 26, 2008, THAT A SAFETY RELATED RECALL HAS BEEN INITIATED TO CORRECT THIS PROBLEM ON CERTAIN MODEL YEAR 2004 AND 2005 ACURA TL VEHICLES.THE RECALL AFFECTS APPROXIMATELY 129,600 SUBJECT VEHICLES MANUFACTURED BETWEEN MARCH 2003 AND MAY 2005.THE DEFECT INVOLVES WATER INTRUSION INTO THE WIPER MOTOR HOUSING THAT MAY RESULT IN CORROSION AND FAILURE OF A CIRCUIT BREAKER THAT WILL DISABLE THE WIPER MOTOR.CORRECTIVE ACTION CONSISTS OF INSTALLING A NEW WIPER MOTOR WHERE CORROSION IS FOUND AS WELL AS A BREATHER TUBE ON BOTH NEW AND EXISTING WIPER MOTORS TO PREVENT WATER INTRUSION INTO THE HOUSING.NHTSA HAS ASSIGNED NUMBER 08V-092 TO THIS RECALL ACTION.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED FEBRUARY 26, 2008, THAT A SAFETY RELATED RECALL HAS BEEN INITIATED TO CORRECT THIS PROBLEM ON CERTAIN MODEL YEAR 2004 AND 2005 ACURA TL VEHICLES.THE RECALL AFFECTS APPROXIMATELY 129,600 SUBJECT VEHICLES MANUFACTURED BETWEEN MARCH 2003 AND MAY 2005.THE DEFECT INVOLVES WATER INTRUSION INTO THE WIPER MOTOR HOUSING THAT MAY RESULT IN CORROSION AND FAILURE OF A CIRCUIT BREAKER THAT WILL DISABLE THE WIPER MOTOR.CORRECTIVE ACTION CONSISTS OF INSTALLING A NEW WIPER MOTOR WHERE CORROSION IS FOUND AS WELL AS A BREATHER TUBE ON BOTH NEW AND EXISTING WIPER MOTORS TO PREVENT WATER INTRUSION INTO THE HOUSING.NHTSA HAS ASSIGNED NUMBER 08V-092 TO THIS RECALL ACTION.
Visibility:windshield Wiper/washer:motor
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED FEBRUARY 26, 2008, THAT A SAFETY RELATED RECALL HAS BEEN INITIATED TO CORRECT THIS PROBLEM ON CERTAIN MODEL YEAR 2004 AND 2005 ACURA TL VEHICLES.THE RECALL AFFECTS APPROXIMATELY 129,600 SUBJECT VEHICLES MANUFACTURED BETWEEN MARCH 2003 AND MAY 2005.THE DEFECT INVOLVES WATER INTRUSION INTO THE WIPER MOTOR HOUSING THAT MAY RESULT IN CORROSION AND FAILURE OF A CIRCUIT BREAKER THAT WILL DISABLE THE WIPER MOTOR.CORRECTIVE ACTION CONSISTS OF INSTALLING A NEW WIPER MOTOR WHERE CORROSION IS FOUND AS WELL AS A BREATHER TUBE ON BOTH NEW AND EXISTING WIPER MOTORS TO PREVENT WATER INTRUSION INTO THE HOUSING.NHTSA HAS ASSIGNED NUMBER 08V-092 TO THIS RECALL ACTION.
2004 Acura Tl Problems, Complaints & Recalls | Skip That Year
Illustration