NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
18 reportsClear category filter122,220 miles · May 4, 2026
Engine And Engine Cooling
The contact owns a 2017 Acura MDX. The contact stated that while driving at 40 MPH the engine seized. All the warning lights illuminated. The contact stated that the failure was due to NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling). The vehicle was towed to an independent mechanic who determined there was an intern…
Read full complaint
The contact owns a 2017 Acura MDX. The contact stated that while driving at 40 MPH the engine seized. All the warning lights illuminated. The contact stated that the failure was due to NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling). The vehicle was towed to an independent mechanic who determined there was an internal engine failure. The local dealer was contacted, where it was diagnosed that there was rod bearing and engine failure. The vehicle was not repaired. The manufacturer was contacted and opened a case. The claim was denied. The failure mileage was approximately 122,220.
NHTSA ODI #11735497
93,000 miles · Nov 14, 2025
Engine And Engine Cooling
The contact owns a 2017 Acura MDX. The contact stated that the dealer recommended that the timing belt be replaced. After the timing belt was replaced, there was a ticking sound coming from the vehicle while being started. The sound occurred while driving at various speeds or while the vehicle was idling. The check engine warnin…
Read full complaint
The contact owns a 2017 Acura MDX. The contact stated that the dealer recommended that the timing belt be replaced. After the timing belt was replaced, there was a ticking sound coming from the vehicle while being started. The sound occurred while driving at various speeds or while the vehicle was idling. The check engine warning light was illuminated while driving approximately 60 MPH. The contact pulled over, turned off, and restarted the vehicle, and the warning light was no longer illuminated. The vehicle was returned to the dealer, who diagnosed that the short block, bearings, and the oil pan needed to be replaced. The dealer recommended that the engine needed to be replaced. The vehicle was not repaired. The contact learned of NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling); however, the VIN was not included. The manufacturer was informed of the failure and confirmed that the VIN was not included in the recall. The failure mileage was approximately 93,000.
NHTSA ODI #11699328
76,000 miles · May 29, 2025
Engine And Engine Cooling
The contact owns a 2017 Acura MDX. The contact stated while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. There was no warning light illuminated. The vehicle was towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. …
Read full complaint
The contact owns a 2017 Acura MDX. The contact stated while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. There was no warning light illuminated. The vehicle was towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling); however, the VIN was not included. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 76,000.
NHTSA ODI #11663630
160,000 miles · May 27, 2025
Engine And Engine Cooling
The contact owns a 2017 Acura MDX. The contact stated that while driving 25 MPH, there an abnormal sound coming from the engine. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the connecting rod bearing, resulting in damages to the engine. The contact was informed that the e…
Read full complaint
The contact owns a 2017 Acura MDX. The contact stated that while driving 25 MPH, there an abnormal sound coming from the engine. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the connecting rod bearing, resulting in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that three years prior the vehicle was diagnosed with connecting road bearing failure. The vehicle was under warranty and the engine was replaced. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling); however, the VIN was not included. The manufacturer was notified of the failure. The failure mileage was approximately 160,000.
NHTSA ODI #11663240
111,000 miles · May 9, 2025
Engine And Engine Cooling
The contact owns a 2017 Acura MDX. The contact stated that while his wife was driving approximately 35 MPH, the check engine warning light was displayed, and the vehicle was driving rough and failed to properly accelerate. The vehicle was slowly driven to the nearby local dealer who examined the engine and discovered metal shavi…
Read full complaint
The contact owns a 2017 Acura MDX. The contact stated that while his wife was driving approximately 35 MPH, the check engine warning light was displayed, and the vehicle was driving rough and failed to properly accelerate. The vehicle was slowly driven to the nearby local dealer who examined the engine and discovered metal shavings inside the oil pan. The contact was informed that the engine rod bearings had failed. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 23V751000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 111,000.
NHTSA ODI #11659943
Mileage unknown · Apr 9, 2025
Engine And Engine Cooling
See attached document for complaint.
NHTSA ODI #11653717
55,553 miles · Mar 28, 2025
Engine And Engine Cooling
The contact owns a 2017 Acura MDX. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the timing chain. The dealer also observed that the timin…
Read full complaint
The contact owns a 2017 Acura MDX. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the timing chain. The dealer also observed that the timing chain cover was leaking. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling); the VIN was included, but the vehicle was already repaired under recall. The manufacturer was not notified of the failure. The failure mileage was 55,553.
NHTSA ODI #11651274
129,000 miles · Mar 27, 2025
Engine And Engine Cooling
The contact owns a 2017 Acura MDX. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal knocking sound. The contact stated that while driving from a complete stop onto the highway the following day, several unknown warning lights were illuminated, and a message advising to park the vehicle …
Read full complaint
The contact owns a 2017 Acura MDX. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal knocking sound. The contact stated that while driving from a complete stop onto the highway the following day, several unknown warning lights were illuminated, and a message advising to park the vehicle was displayed. The contact stated that while attempting to make a turn to drive back to the residence, the vehicle stalled in the middle of the road. The contact and her children, who were occupying the vehicle, were significantly frightened. The contact was able to restart the vehicle after several attempts; however, the vehicle made an abnormally loud grinding sound. The contact was able to drive back to the residence. The vehicle was towed to the dealer, where it was diagnosed that the engine was damaged due to rod bearing failure. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling); however, the VIN was not included. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under warranty or recall. The manufacturer referred the contact to the NHTSA Hotline for assistance in adding the VIN to the recall. The failure mileage was approximately 129,000.
NHTSA ODI #11650996
149,000 miles · Mar 10, 2025
Engine And Engine Cooling
The contact owns a 2017 Acura MDX. The contact stated that while his daughter was driving at approximately 65-70 MPH on the highway, the engine seized after pulling into a parking lot. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V751000 (Engine and Engine …
Read full complaint
The contact owns a 2017 Acura MDX. The contact stated that while his daughter was driving at approximately 65-70 MPH on the highway, the engine seized after pulling into a parking lot. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling). The vehicle was towed to an independent mechanic, who determined there was a knocking noise from the underside of the engine. The vehicle was towed to the local dealer, where it was diagnosed that the rod bearing was damaged and was fractured. The dealer informed the contact that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the local dealer and opened a case, confirming there was no open recall on the VIN. The failure mileage was approximately 149,000.
NHTSA ODI #11647453
91,000 miles · Jan 28, 2025
Engine And Engine Cooling
The contact owns a 2017 Acura MDX. The contact stated while driving 70 MPH, there was an abnormal knocking sound coming from the engine compartment, prompting the contact to discontinue driving the vehicle. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the conne…
Read full complaint
The contact owns a 2017 Acura MDX. The contact stated while driving 70 MPH, there was an abnormal knocking sound coming from the engine compartment, prompting the contact to discontinue driving the vehicle. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the connecting rod bearings, resulting in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 91,000.
NHTSA ODI #11639156
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Apr 17, 2025
Honda (American Honda Motor Co.) is recalling certain 2014-2020 Acura MDX vehicles. Moisture may enter the tailgate lid light assembly and wiring harness, which can cause the interior and exterior lights to fail, including the lid lights, position lights, license plate lights and taillights.
Consequence & remedy
Consequence: Vehicle lights that fail to illuminate can decrease visibility and increase the risk of a crash.
Remedy: Dealers will inspect the wiring and install a fuse harness, replace the lid light, and repair the body dust sealer, as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Acura's customer service at 1-800-382-2238. Acura's number for this recall is FLI. Vehicles included in this recall that were previously repaired under NHTSA recall number 19V-256 will need to have the new remedy completed.
Additional source detail variants (2)
Interior Lighting
Honda (American Honda Motor Co.) is recalling certain 2014-2020 Acura MDX vehicles. Moisture may enter the tailgate lid light assembly and wiring harness, which can cause the interior and exterior lights to fail, including the lid lights, position lights, license plate lights and taillights.
Consequence: Vehicle lights that fail to illuminate can decrease visibility and increase the risk of a crash.
Remedy: Dealers will inspect the wiring and install a fuse harness, replace the lid light, and repair the body dust sealer, as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Acura's customer service at 1-800-382-2238. Acura's number for this recall is FLI. Vehicles included in this recall that were previously repaired under NHTSA recall number 19V-256 will need to have the new remedy completed.
Exterior Lighting
Honda (American Honda Motor Co.) is recalling certain 2014-2020 Acura MDX vehicles. Moisture may enter the tailgate lid light assembly and wiring harness, which can cause the interior and exterior lights to fail, including the lid lights, position lights, license plate lights and taillights.
Consequence: Vehicle lights that fail to illuminate can decrease visibility and increase the risk of a crash.
Remedy: Dealers will inspect the wiring and install a fuse harness, replace the lid light, and repair the body dust sealer, as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Acura's customer service at 1-800-382-2238. Acura's number for this recall is FLI. Vehicles included in this recall that were previously repaired under NHTSA recall number 19V-256 will need to have the new remedy completed.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Mar 28, 2019
Honda (American Honda Motor Co.) is recalling certain 2014-2019 Acura MDX and 2017-2019 Acura MDX Sport Hybrid vehicles. Moisture may enter the tailgate lid lights, possibly causing a loss of the tailgate lid lights and the taillights.
Consequence & remedy
Consequence: Loss of the taillights reduces the vehicle's visibility, increasing the risk of crash.
Remedy: Acura will notify owners, and dealers will modify the tailgate lid lights and install updated gaskets and a wiring sub-harness or will replace both tailgate lid lights. The repairs will be performed free of charge. The recall began May 7, 2019. Owners may contact Acura customer service at 1-888-234-2138. Acura's number for this recall is M49.
Additional source detail variants (2)
Exterior Lighting
Honda (American Honda Motor Co.) is recalling certain 2014-2019 Acura MDX and 2017-2019 Acura MDX Sport Hybrid vehicles. Moisture may enter the tailgate lid lights, possibly causing a loss of the tailgate lid lights and the taillights.
Consequence: Loss of the taillights reduces the vehicle's visibility, increasing the risk of crash.
Remedy: Acura will notify owners, and dealers will modify the tailgate lid lights and install updated gaskets and a wiring sub-harness or will replace both tailgate lid lights. The repairs will be performed free of charge. The recall began May 7, 2019. Owners may contact Acura customer service at 1-888-234-2138. Acura's number for this recall is M49.
Exterior Lighting:tail Lights
Honda (American Honda Motor Co.) is recalling certain 2014-2019 Acura MDX and 2017-2019 Acura MDX Sport Hybrid vehicles. Moisture may enter the tailgate lid lights, possibly causing a loss of the tailgate lid lights and the taillights.
Consequence: Loss of the taillights reduces the vehicle's visibility, increasing the risk of crash.
Remedy: Acura will notify owners, and dealers will modify the tailgate lid lights and install updated gaskets and a wiring sub-harness or will replace both tailgate lid lights. The repairs will be performed free of charge. The recall began May 7, 2019. Owners may contact Acura customer service at 1-888-234-2138. Acura's number for this recall is M49.
Jan 29, 2019
Honda (American Honda Motor Co.) is recalling certain 2016-2018 Acura MDX, 2015-2019 Acura TLX and 2015-2017 Honda Accord vehicles, equipped with a 3.5L V6 engine. Particulates in fuel may adhere to the internal components of the fuel pump, reducing its performance.
Consequence & remedy
Consequence: Reduced fuel pump performance can result in an engine stall, increasing the risk of crash.
Remedy: Honda will notify owners, and dealers will update the fuel injection engine control unit (FI-ECU) software and, if necessary, replace the fuel pump, free of charge. The recall began March 25, 2019. Owners may contact customer service at 1-888-234-2138. Acura's recall number for this recall is P3W. Honda's recall number for this recall is N3X.
Nov 1, 2018
Honda (American Honda Motor Co.) is recalling certain 2017-2019 Acura MDX, 2017-2018 Acura MDX Sport Hybrid, 2018-2019 Honda HR-V and Honda Odyssey, and 2016 Honda HR-V vehicles. The rear brake caliper pistons may have an insufficient coating, causing gas pockets to form, reducing brake performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: A reduction of braking performance increases the risk of a crash.
Remedy: Owners will be notified, and Honda or Acura dealers will bleed the brakes, free of charge. The recall began December 11, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are C31 and L30.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
Illustration