NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
27 reportsClear category filterMileage unknown · Aug 11, 2022
EngineFuel/propulsion SystemPower Train
On a multi-day road trip, the car had a temporary complete loss of power on two separate days. Both times this happened after several hours of driving at highway speeds on I-15 in California, outside temperatures were in the 90s. After a slight deceleration and then applying the accelerator again, there was a 'clunk' like sound …
Read full complaint
On a multi-day road trip, the car had a temporary complete loss of power on two separate days. Both times this happened after several hours of driving at highway speeds on I-15 in California, outside temperatures were in the 90s. After a slight deceleration and then applying the accelerator again, there was a 'clunk' like sound possibly from the transmission, and then a complete loss of power. The first time I tried to pull over to the breakdown lane, and then regained power after about 2-3 seconds. The second time, we were in the middle of traffic and were not able to pull over, but again after 2-3 seconds, the power came back. The engine did not rev up when applying the accelerator and there were no dashboard lights. This appeared to be either a transmission, fuel delivery, or engine management/drive by wire issue. While we luckily did not get into an accident, we did slow down significantly on the highway, requiring other drivers around us to break, or change lanes. I have made an appointment with my independent mechanic, but the car has not been inspected yet and I am not able to forcibly reproduce the issue.
NHTSA ODI #11478793
Mileage unknown · Jun 21, 2022
Fuel/propulsion System
My mechanic replaced the battery on May 9th and could smell gas but I had just fueled the vehicle. Two days later is when it got worse while driving back home I pulled over and could smell gasoline inside the vehicle as if an open gas can was sitting in the passenger seat. I stopped using the vehicle and took it to my mechanic a…
Read full complaint
My mechanic replaced the battery on May 9th and could smell gas but I had just fueled the vehicle. Two days later is when it got worse while driving back home I pulled over and could smell gasoline inside the vehicle as if an open gas can was sitting in the passenger seat. I stopped using the vehicle and took it to my mechanic and he discovered a crack in the weld on the front fuel rail. This could have harmed my family, pets or myself if it had caught on fire. In 1 hour I used a quarter tank of gas because of the high pressure pushing the gas on to the engine. Vehicle taken to Anchorage Acura and the Acura mechanic confirmed what my mechanic found. There were no warning lights or indications of anything wrong until I could smell the gas.
NHTSA ODI #11470311
Mileage unknown · Aug 20, 2021
Fuel/propulsion System
Stalling when accelerating. Safety hazard because the car basically dies temporarily and slows down. I have to pump the gas pedal for several seconds to get it going again.
NHTSA ODI #11429937
Mileage unknown · Mar 26, 2021
EngineFuel/propulsion SystemLane Departure
ENGINE LIGHT ON STATING: LEAN CODE, ALL WHEEL DRIVE SYSTEMS PROBLEM, EMMISION SYSTEM PROBLEM. THE VEHICLE WAS MOVING WHEN IT CAME ON.
NHTSA ODI #11405061
75,000 miles · Dec 26, 2020
Fuel/propulsion SystemLane DeparturePower Train
WHILE DRIVING ON LOCAL ROAD ALL OF A SUDDEN THE 3 ERRORS CAME ON THE DASH BOARD TRANSMISSION SYSTEM PROBLEM, EMISSION SYSTEM PROBLEM, AND BLIND SPOT SYSTEM PROBLEM, ENGINE LIGHT CAME ON. WHEN THIS HAPPENS THE TRANSMISSION DOESN'T SHIFT RIGHT AND GRINDING OF THE GEAR IS HEARD, CAR QUICKLY SLOW DOWN. AFTER STOPPING AND START UP AG…
Read full complaint
WHILE DRIVING ON LOCAL ROAD ALL OF A SUDDEN THE 3 ERRORS CAME ON THE DASH BOARD TRANSMISSION SYSTEM PROBLEM, EMISSION SYSTEM PROBLEM, AND BLIND SPOT SYSTEM PROBLEM, ENGINE LIGHT CAME ON. WHEN THIS HAPPENS THE TRANSMISSION DOESN'T SHIFT RIGHT AND GRINDING OF THE GEAR IS HEARD, CAR QUICKLY SLOW DOWN. AFTER STOPPING AND START UP AGAIN, ERRORS STILL THERE BUT TRANSMISSION COULD NOT SHIFT INTO HIGHER GEARS AND CAR TOPS OUT AT 30MPH. THIS HAS HAPPENED 4 TIMES IN THE LAST FEW DAYS AND WE ARE NOW SCARED TO DRIVE THE CAR LOCAL ROADS, HIGHWAY WOULD BE BAD UNTIL WE GET IT FIXED AT THE DEALERSHIP. THIS IS POTENTIALLY A VERY DANGEROUS SITUATION IF THE CAR LOSES POWER AT AN INTERSECTION.
NHTSA ODI #11384979
64,369 miles · Nov 17, 2020
EngineFuel/propulsion SystemPower Train
PURCHASED A CERTIFIED PRE-OWNED 2016 ACURA MDX SH-AWD W/ TECH A FEW WEEKS AGO & FROM DAY ONE THERE HAVE BEEN ISSUES WITH ACCELERATION OFF A COMPLETE STOP LIKE A STOP SIGN, STOP LIGHT, COMING OFF PARK OR UPON PUTTING IT INTO DRIVE. THE VEHICLE WILL NOT MOVE WHEN THE GAS PEDAL IS DEPRESSED, WILL REV HIGH THROUGH FIRST, JUMP INTO …
Read full complaint
PURCHASED A CERTIFIED PRE-OWNED 2016 ACURA MDX SH-AWD W/ TECH A FEW WEEKS AGO & FROM DAY ONE THERE HAVE BEEN ISSUES WITH ACCELERATION OFF A COMPLETE STOP LIKE A STOP SIGN, STOP LIGHT, COMING OFF PARK OR UPON PUTTING IT INTO DRIVE. THE VEHICLE WILL NOT MOVE WHEN THE GAS PEDAL IS DEPRESSED, WILL REV HIGH THROUGH FIRST, JUMP INTO 2 STILL REVVING HIGH BEFORE FINALLY MOVING WHEN IT HITS 3RD. IT IS A HUGE SAFETY ISSUE WHEN OTHER TRAFFIC IS ONCOMING AS YOU ARE EXPECTING TO "GO" & NOTHING HAPPENS WHEN PRESSING THE GAS PEDAL. THE DEALERSHIP INSPECTED THE VEHICLE UPON PURCHASE AT OUR REQUEST ON TWO OCCASIONS BUT TOLD US IT IS NORMAL & WILL ADJUST TO MY DRIVING STYLE. THIS IS NOT NORMAL.THEY SAID THEY UPDATED THE SOFTWARE BUT FOUND NOTHING WRONG WITH THE VEHICLE. I'M FEELING LIKE WE PAID FOR A LEMON & DRIVING SOMETHING WHICH IS VERY UNSAFE ESPECIALLY WITH CHILDREN IN THE CAR.
NHTSA ODI #11375095
77,000 miles · Nov 8, 2020
Electrical SystemFuel/propulsion SystemUnknown Or Other
IN THE LAST 6 MONTHS, MY SUV HAS STALLED EITHER AT A STOP LIGHT OR WHEN PARKED. IT WOULD SPUTTER ON TRYING TO RESTART. BATTERY WAS NOT AN ISSUE. THOUGHT IT WAS A STARTER ISSUE AND GOT A NEW STARTER. BUT IT HAPPENED AGAIN TODAY AND THE TOW TRUCK GUY POWERED WITH JUMP START (EVEN THOUGH IT WAS NOT A BATTERY ISSUE) AND IT START…
Read full complaint
IN THE LAST 6 MONTHS, MY SUV HAS STALLED EITHER AT A STOP LIGHT OR WHEN PARKED. IT WOULD SPUTTER ON TRYING TO RESTART. BATTERY WAS NOT AN ISSUE. THOUGHT IT WAS A STARTER ISSUE AND GOT A NEW STARTER. BUT IT HAPPENED AGAIN TODAY AND THE TOW TRUCK GUY POWERED WITH JUMP START (EVEN THOUGH IT WAS NOT A BATTERY ISSUE) AND IT STARTED.
NHTSA ODI #11373683
1 miles · Oct 9, 2020
Fuel/propulsion SystemPower TrainUnknown Or Other
CAR BEGAN TO STALL WHILE DRIVING. WOULD NOT ACCELERATE WHILE PRESSING GAS PEDAL AND SUDDENLY TURNED OFF. TRIED TO TURN IT BACK ON. WHICH IT DID TURN ON BUT IT DID SO WITH A LOT OF EFFORT FROM THE CAR. ENGINE LIGHT HAS NOW CAME ON ALONG WITH 3 MORE LIGHTS.
NHTSA ODI #11363602
64,053 miles · Mar 6, 2020
EngineFuel/propulsion SystemVehicle Speed ControlCrashInjury
TL* THE CONTACT OWNS A 2016 ACURA MDX. THE CONTACT STATED WHILE DRIVING 20 MPH, WHEN DRIVING OVER A SPEED BUMP THE VEHICLE ACCELERATED INDEPENDENTLY AND IMPACTED THE VEHICLE IN FRONT. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. AIR BAGS DID NOT DEPLOY. THE CONTACT STATED SHE WAS NOT INJURED. THE CONTACT STATED THE DRIV…
Read full complaint
TL* THE CONTACT OWNS A 2016 ACURA MDX. THE CONTACT STATED WHILE DRIVING 20 MPH, WHEN DRIVING OVER A SPEED BUMP THE VEHICLE ACCELERATED INDEPENDENTLY AND IMPACTED THE VEHICLE IN FRONT. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. AIR BAGS DID NOT DEPLOY. THE CONTACT STATED SHE WAS NOT INJURED. THE CONTACT STATED THE DRIVER OF THE OTHER VEHICLE SUSTAINED UNKNOWN INJURIES BUT WAS NOT AWARE IF MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DRIVABLE AND WAS TOWED TO AN INDEPENDENT COLLISION CENTER. THE VEHICLE FAILURE WAS NOT DIAGNOSED BY AN INDEPENDENT MECHANIC OR DEALER. THE CONTACT ALSO MENTIONED AFTER THE ACCIDENT THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 19V060000 (FUEL SYSTEM, OTHER) AT NORRIS ACURA (8559 BALTIMORE NATIONAL PIKE, ELLICOTT CITY, MD 21043) ON 10/11/2019. THE CONTACT STATED AFTER THE RECALL REMEDY THE VEHICLE HAD A FUEL LEAK. THE DEALER WAS CONTACTED, HOWEVER STATED SHE WOULD BE REASONABLE FOR DIAGNOSES AND REPAIRS FEES. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 64,053.
NHTSA ODI #11316652
50,000 miles · Aug 19, 2019
Fuel/propulsion System
TL* THE CONTACT OWNS A 2016 ACURA MDX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V060000 (FUEL SYSTEM, OTHER). THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS SERVICED AT DALLAS ACURA (4801 LEMMON AVE, DALLAS, TX 75219, (214) 692-2872), BUT THE REMEDY FAILED TO REPAIR THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 2016 ACURA MDX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V060000 (FUEL SYSTEM, OTHER). THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS SERVICED AT DALLAS ACURA (4801 LEMMON AVE, DALLAS, TX 75219, (214) 692-2872), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT MENTIONED THAT THE CHECK ENGINE INDICATOR REMAINED ILLUMINATED AFTER THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.
NHTSA ODI #11244901
Official recalls
7Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Apr 17, 2025
Honda (American Honda Motor Co.) is recalling certain 2014-2020 Acura MDX vehicles. Moisture may enter the tailgate lid light assembly and wiring harness, which can cause the interior and exterior lights to fail, including the lid lights, position lights, license plate lights and taillights.
Consequence & remedy
Consequence: Vehicle lights that fail to illuminate can decrease visibility and increase the risk of a crash.
Remedy: Dealers will inspect the wiring and install a fuse harness, replace the lid light, and repair the body dust sealer, as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Acura's customer service at 1-800-382-2238. Acura's number for this recall is FLI. Vehicles included in this recall that were previously repaired under NHTSA recall number 19V-256 will need to have the new remedy completed.
Additional source detail variants (2)
Interior Lighting
Honda (American Honda Motor Co.) is recalling certain 2014-2020 Acura MDX vehicles. Moisture may enter the tailgate lid light assembly and wiring harness, which can cause the interior and exterior lights to fail, including the lid lights, position lights, license plate lights and taillights.
Consequence: Vehicle lights that fail to illuminate can decrease visibility and increase the risk of a crash.
Remedy: Dealers will inspect the wiring and install a fuse harness, replace the lid light, and repair the body dust sealer, as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Acura's customer service at 1-800-382-2238. Acura's number for this recall is FLI. Vehicles included in this recall that were previously repaired under NHTSA recall number 19V-256 will need to have the new remedy completed.
Exterior Lighting
Honda (American Honda Motor Co.) is recalling certain 2014-2020 Acura MDX vehicles. Moisture may enter the tailgate lid light assembly and wiring harness, which can cause the interior and exterior lights to fail, including the lid lights, position lights, license plate lights and taillights.
Consequence: Vehicle lights that fail to illuminate can decrease visibility and increase the risk of a crash.
Remedy: Dealers will inspect the wiring and install a fuse harness, replace the lid light, and repair the body dust sealer, as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Acura's customer service at 1-800-382-2238. Acura's number for this recall is FLI. Vehicles included in this recall that were previously repaired under NHTSA recall number 19V-256 will need to have the new remedy completed.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Mar 28, 2019
Honda (American Honda Motor Co.) is recalling certain 2014-2019 Acura MDX and 2017-2019 Acura MDX Sport Hybrid vehicles. Moisture may enter the tailgate lid lights, possibly causing a loss of the tailgate lid lights and the taillights.
Consequence & remedy
Consequence: Loss of the taillights reduces the vehicle's visibility, increasing the risk of crash.
Remedy: Acura will notify owners, and dealers will modify the tailgate lid lights and install updated gaskets and a wiring sub-harness or will replace both tailgate lid lights. The repairs will be performed free of charge. The recall began May 7, 2019. Owners may contact Acura customer service at 1-888-234-2138. Acura's number for this recall is M49.
Additional source detail variants (2)
Exterior Lighting
Honda (American Honda Motor Co.) is recalling certain 2014-2019 Acura MDX and 2017-2019 Acura MDX Sport Hybrid vehicles. Moisture may enter the tailgate lid lights, possibly causing a loss of the tailgate lid lights and the taillights.
Consequence: Loss of the taillights reduces the vehicle's visibility, increasing the risk of crash.
Remedy: Acura will notify owners, and dealers will modify the tailgate lid lights and install updated gaskets and a wiring sub-harness or will replace both tailgate lid lights. The repairs will be performed free of charge. The recall began May 7, 2019. Owners may contact Acura customer service at 1-888-234-2138. Acura's number for this recall is M49.
Exterior Lighting:tail Lights
Honda (American Honda Motor Co.) is recalling certain 2014-2019 Acura MDX and 2017-2019 Acura MDX Sport Hybrid vehicles. Moisture may enter the tailgate lid lights, possibly causing a loss of the tailgate lid lights and the taillights.
Consequence: Loss of the taillights reduces the vehicle's visibility, increasing the risk of crash.
Remedy: Acura will notify owners, and dealers will modify the tailgate lid lights and install updated gaskets and a wiring sub-harness or will replace both tailgate lid lights. The repairs will be performed free of charge. The recall began May 7, 2019. Owners may contact Acura customer service at 1-888-234-2138. Acura's number for this recall is M49.
Jan 29, 2019
Honda (American Honda Motor Co.) is recalling certain 2016-2018 Acura MDX, 2015-2019 Acura TLX and 2015-2017 Honda Accord vehicles, equipped with a 3.5L V6 engine. Particulates in fuel may adhere to the internal components of the fuel pump, reducing its performance.
Consequence & remedy
Consequence: Reduced fuel pump performance can result in an engine stall, increasing the risk of crash.
Remedy: Honda will notify owners, and dealers will update the fuel injection engine control unit (FI-ECU) software and, if necessary, replace the fuel pump, free of charge. The recall began March 25, 2019. Owners may contact customer service at 1-888-234-2138. Acura's recall number for this recall is P3W. Honda's recall number for this recall is N3X.
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
Illustration