NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
10 reportsClear category filterMileage unknown · Aug 28, 2026
Exterior Lighting
2016 Acura MDX. The red LED section of the inner tailgate taillight (lid light) has failed and no longer illuminates. The white backup bulb in the same assembly still works. The LED section is sealed inside the assembly and cannot be serviced, so the entire lid light must be replaced. This vehicle received safety recall M49 (N…
Read full complaint
2016 Acura MDX. The red LED section of the inner tailgate taillight (lid light) has failed and no longer illuminates. The white backup bulb in the same assembly still works. The LED section is sealed inside the assembly and cannot be serviced, so the entire lid light must be replaced. This vehicle received safety recall M49 (NHTSA 19V-256) in 2019 for moisture intrusion into the inner taillights. The same failure has now occurred again. Honda's own Part 573 report for recall FLI (NHTSA 25V-259) states that the redesigned assemblies installed under 19V-256 do not sufficiently prevent moisture intrusion, and that moisture entered through two new pathways: between the gasket and the seal ribs of the lid light, and at the interface between the gasket and the body dust sealer. My failure appears to be exactly that condition. The NHTSA VIN lookup shows zero unrepaired recalls for this VIN. When I contacted Acura, I was told the issue was repaired in 2019. That response addresses M49, not FLI. I have not been able to get confirmation of whether FLI applies to this VIN or was ever performed. Loss of the rear position lights reduces visibility and is a citable equipment violation.
NHTSA ODI #11760292
149,000 miles · Jul 31, 2026
Exterior Lighting
The contact owns a 2016 Acura MDX. The contact stated that while the vehicle was parked and attempting to open the trunk, the contact became aware that the inner driver’s side taillight was inoperable. The contact associated the failure with NHTSA Campaign Number: 19V256000 (Exterior Lighting); however, the VIN was not included.…
Read full complaint
The contact owns a 2016 Acura MDX. The contact stated that while the vehicle was parked and attempting to open the trunk, the contact became aware that the inner driver’s side taillight was inoperable. The contact associated the failure with NHTSA Campaign Number: 19V256000 (Exterior Lighting); however, the VIN was not included. The vehicle was taken to an independent mechanic. The independent mechanic stated that the taillight needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 149,000.
NHTSA ODI #11753988
99,217 miles · Apr 9, 2026
Exterior LightingInterior Lighting
The contact owns 2016 Acura MDX. The contact stated that after the State Inspection was completed, the State Inspector informed the contact that the vehicle had failed the inspection due to an inoperable driver's side tailgate light. The contact was also informed that there was moisture inside the tailgate lid light assembly, an…
Read full complaint
The contact owns 2016 Acura MDX. The contact stated that after the State Inspection was completed, the State Inspector informed the contact that the vehicle had failed the inspection due to an inoperable driver's side tailgate light. The contact was also informed that there was moisture inside the tailgate lid light assembly, and that the failure was related to NHTSA Campaign Number: 25V259000 (Exterior Lighting, Interior Lighting). The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The contact was referred the dealer for the repair. The contact was informed that there might be a reimbursement if the VIN became included in a future recall. The vehicle was not yet diagnosed or repaired. The failure mileage was 99,217.
NHTSA ODI #11730113
Mileage unknown · Jan 6, 2026
Exterior Lighting
I have a 2016 MDX. The big red light on my tailgate on the passenger side stopped working. I had been driving at night and only found out when a friend mentioned it to me. I al concerned driving due to safety issues with being less visible to other drivers. I tried changing the bulb with two new ones (correct size 7440) and it …
Read full complaint
I have a 2016 MDX. The big red light on my tailgate on the passenger side stopped working. I had been driving at night and only found out when a friend mentioned it to me. I al concerned driving due to safety issues with being less visible to other drivers. I tried changing the bulb with two new ones (correct size 7440) and it still does not work. I noticed online that there is a safety recall for such lighting issues, though it is not showing as recall for my VIN. I called Chevy Chase Acura to ask about the recall and they said there are no recalls listed for my vehicle. I made an appointment for 1/7/26 at 1:15pm anyway to have it looked at. Following that, I called Honda's recall department and they said there previously had been a recall in effect but it expired on 11/30/25. I have been out of town caring for my mother who had cancer and recently passed on 12/18/25. I was not previously aware of the recall. From my reading online, due to this being a safety recall, it should still be eligible for recall repairs up to 15 years of the car's age. I am hoping for some assistance in getting this matter resolved.
NHTSA ODI #11709254
Mileage unknown · May 24, 2025
EngineExterior Lighting
This specific vehicle has an issue with the starter and flywheel breaking up for no reason. After being replaced twice, they were broken again in three months. The suspension has also been broken many times, and even after replacing the entire four sides, it still did not fix the problem. It also produces a rubber smell when dr…
Read full complaint
This specific vehicle has an issue with the starter and flywheel breaking up for no reason. After being replaced twice, they were broken again in three months. The suspension has also been broken many times, and even after replacing the entire four sides, it still did not fix the problem. It also produces a rubber smell when driven over than 1 hour non stop
NHTSA ODI #11662888
141,000 miles · Apr 30, 2025
Exterior LightingInterior Lighting
The contact owns a 2016 Acura MDX. The contact stated that the driver's side rear taillight bulb had burned out. The contact replaced the bulb, but the failure reoccurred. The contact stated that the driver's side rear taillight failure was intermittent but was a persistent failure. The contact had taken the vehicle to an indepe…
Read full complaint
The contact owns a 2016 Acura MDX. The contact stated that the driver's side rear taillight bulb had burned out. The contact replaced the bulb, but the failure reoccurred. The contact stated that the driver's side rear taillight failure was intermittent but was a persistent failure. The contact had taken the vehicle to an independent mechanic who diagnosed the failure and determined that there was water inside the taillight assembly which caused the bulb to short circuit. The mechanic informed the contact that the taillight assembly needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 25V259000 (Exterior Lighting, Interior Lighting); however, the VIN was not included. The manufacturer was not informed of the failure. The failure mileage was approximately 141,000.
NHTSA ODI #11657737
Mileage unknown · Dec 30, 2024
Exterior Lighting
Rear inner tail light on driver side is not working (34155-TZ5-H03). There is active recall on models between 2014-2019 but when checked my VIN it shows it is not covered. I went through the detail of recall and it can be clearly seen that the damage is same as shown in the recall. I will appreciate if someone can provide how do…
Read full complaint
Rear inner tail light on driver side is not working (34155-TZ5-H03). There is active recall on models between 2014-2019 but when checked my VIN it shows it is not covered. I went through the detail of recall and it can be clearly seen that the damage is same as shown in the recall. I will appreciate if someone can provide how do we know that my VIN was not impacted as there could be subcomponent which could have led to same issues as others from this period. I will appreciate if a prompt action can be taken and my vehicle can be added to the recall list as well. Thanks!
NHTSA ODI #11633157
Mileage unknown · Sep 3, 2024
Electrical SystemExterior LightingSeats
My vehicle has been going off on its own when it is off, the lights starts to flicker on the outside and on the dashboard, the seats malfunction on its own so does the steering wheel causing the steering wheel to move up and down adjusting on its own, the car alarm will go off all the time, and I hear a noise coming from under t…
Read full complaint
My vehicle has been going off on its own when it is off, the lights starts to flicker on the outside and on the dashboard, the seats malfunction on its own so does the steering wheel causing the steering wheel to move up and down adjusting on its own, the car alarm will go off all the time, and I hear a noise coming from under the hood. It’s so bad that I have to take out the battery and leave it cause this problem will continue until the battery is dead, sometimes it will cause all the lights to come on and stay on all night, mean while the vehicle is not even turned on when all this is happening, I search couple video and websites only to see other people having the same problem with this specific type of vehicle, this problem been consistent for months and it makes the car unable to drive.
NHTSA ODI #11612452
200 miles · Dec 19, 2019
Exterior LightingPower TrainSuspension
VEHICLE ACCELERATION IS SLUGGISH AT STOP AND GO. DURING HIGHWAY SPEED, IF TRANSMISSION IS IN LOW CRUISING GEAR AND YOU NEED TO ACCELERATE, TRANSMISSION IS SLUGGISH. ISSUES WAS CORRECTED AT DEALER. DEALER FOUND 1 FAULTY TRANSMISSION COMPUTER CODE. NEW SYMPTOMS AFTER COMPUTER FIX, OVER ACCELERATION AND HARSH SHIFT POINTS. DEALER A…
Read full complaint
VEHICLE ACCELERATION IS SLUGGISH AT STOP AND GO. DURING HIGHWAY SPEED, IF TRANSMISSION IS IN LOW CRUISING GEAR AND YOU NEED TO ACCELERATE, TRANSMISSION IS SLUGGISH. ISSUES WAS CORRECTED AT DEALER. DEALER FOUND 1 FAULTY TRANSMISSION COMPUTER CODE. NEW SYMPTOMS AFTER COMPUTER FIX, OVER ACCELERATION AND HARSH SHIFT POINTS. DEALER ADVISED TO DRIVE 500 MILE AFTER COMPUTER REFLASH. INTERIOR LIGHT DO NOT DIM AFTER A FEW SECONDS. INTERIOR LIGHTS WILL NOT TURN OFF REGARDLESS OF LOCKING VEHICLE. REAR SUSPENSION HAS A 0.55 CAMBER DIFFERENCE, VEHICLE HAS 26,765 MILES. I ASKED DEALERSHIP SERVICE TO LOOK AT THIS ISSUE. DEALER NEVER ADVISED ON ISSUES.
NHTSA ODI #11290005
Mileage unknown · Nov 14, 2015
Exterior Lighting
WHEN DRIVING AT NIGHT ON COUNTRY ROADS,UP AND DOWN HILLS, A DARK LINE APPEARS ACROSS THE TOP HALF OF THE WINDSHIELD. LEAVING A VIEW OF 40 -50 FT. YOU CAN ONLY SEE THREW THE BOTTOM HALF OF WINDSHIELD. VERY DANGEROUS!! I PURCHASED THIS VEHICLE FOR ALL THE SAFETY FEATURES IT HAS ON IT BUT NOW I CAN'T DRIVE IT AT NIGHT. WENT TO D…
Read full complaint
WHEN DRIVING AT NIGHT ON COUNTRY ROADS,UP AND DOWN HILLS, A DARK LINE APPEARS ACROSS THE TOP HALF OF THE WINDSHIELD. LEAVING A VIEW OF 40 -50 FT. YOU CAN ONLY SEE THREW THE BOTTOM HALF OF WINDSHIELD. VERY DANGEROUS!! I PURCHASED THIS VEHICLE FOR ALL THE SAFETY FEATURES IT HAS ON IT BUT NOW I CAN'T DRIVE IT AT NIGHT. WENT TO DEALER AND THEY TESTED HEADLIGHTS ON A WALL WITH A BLACK LINE AND THE LIGHTS HIT 2-3 INCHES BELOW THAT LINE. WAS TOLD IT WAS FINE. I WANTED IT RAISED A BIT BUT WAS TOLD THE LIGHTS WERE JUST FINE AND CAN'T BE ADJUSTED. I HAVE READ SOME COMPLAINTS ON THIS VERY SUBJECT. I WOULD LIKE SOMEONE TO TEST DRIVE THIS CAR ON DARK, HILLY, COUNTRY ROADS THAT HAVE NO STREET LIGHTS. I ALSO FINE THAT ON HIGHWAYS, LIKE THE TURNPIKE, LOW BEAMS JUST DON'T GO REACH OUT FAR ENOUGH. I JUST WONDER IF THESE JEWEL EYE HEADLIGHTS ARE LINED UP CORRECTLY? THANK YOU FOR TAKING THE TIME TO READ THIS AND I HOPE THERE IS A SOLUTION TO THIS PROBLEM.
NHTSA ODI #10790358
Official recalls
7Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Apr 17, 2025
Honda (American Honda Motor Co.) is recalling certain 2014-2020 Acura MDX vehicles. Moisture may enter the tailgate lid light assembly and wiring harness, which can cause the interior and exterior lights to fail, including the lid lights, position lights, license plate lights and taillights.
Consequence & remedy
Consequence: Vehicle lights that fail to illuminate can decrease visibility and increase the risk of a crash.
Remedy: Dealers will inspect the wiring and install a fuse harness, replace the lid light, and repair the body dust sealer, as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Acura's customer service at 1-800-382-2238. Acura's number for this recall is FLI. Vehicles included in this recall that were previously repaired under NHTSA recall number 19V-256 will need to have the new remedy completed.
Additional source detail variants (2)
Interior Lighting
Honda (American Honda Motor Co.) is recalling certain 2014-2020 Acura MDX vehicles. Moisture may enter the tailgate lid light assembly and wiring harness, which can cause the interior and exterior lights to fail, including the lid lights, position lights, license plate lights and taillights.
Consequence: Vehicle lights that fail to illuminate can decrease visibility and increase the risk of a crash.
Remedy: Dealers will inspect the wiring and install a fuse harness, replace the lid light, and repair the body dust sealer, as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Acura's customer service at 1-800-382-2238. Acura's number for this recall is FLI. Vehicles included in this recall that were previously repaired under NHTSA recall number 19V-256 will need to have the new remedy completed.
Exterior Lighting
Honda (American Honda Motor Co.) is recalling certain 2014-2020 Acura MDX vehicles. Moisture may enter the tailgate lid light assembly and wiring harness, which can cause the interior and exterior lights to fail, including the lid lights, position lights, license plate lights and taillights.
Consequence: Vehicle lights that fail to illuminate can decrease visibility and increase the risk of a crash.
Remedy: Dealers will inspect the wiring and install a fuse harness, replace the lid light, and repair the body dust sealer, as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Acura's customer service at 1-800-382-2238. Acura's number for this recall is FLI. Vehicles included in this recall that were previously repaired under NHTSA recall number 19V-256 will need to have the new remedy completed.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Mar 28, 2019
Honda (American Honda Motor Co.) is recalling certain 2014-2019 Acura MDX and 2017-2019 Acura MDX Sport Hybrid vehicles. Moisture may enter the tailgate lid lights, possibly causing a loss of the tailgate lid lights and the taillights.
Consequence & remedy
Consequence: Loss of the taillights reduces the vehicle's visibility, increasing the risk of crash.
Remedy: Acura will notify owners, and dealers will modify the tailgate lid lights and install updated gaskets and a wiring sub-harness or will replace both tailgate lid lights. The repairs will be performed free of charge. The recall began May 7, 2019. Owners may contact Acura customer service at 1-888-234-2138. Acura's number for this recall is M49.
Additional source detail variants (2)
Exterior Lighting
Honda (American Honda Motor Co.) is recalling certain 2014-2019 Acura MDX and 2017-2019 Acura MDX Sport Hybrid vehicles. Moisture may enter the tailgate lid lights, possibly causing a loss of the tailgate lid lights and the taillights.
Consequence: Loss of the taillights reduces the vehicle's visibility, increasing the risk of crash.
Remedy: Acura will notify owners, and dealers will modify the tailgate lid lights and install updated gaskets and a wiring sub-harness or will replace both tailgate lid lights. The repairs will be performed free of charge. The recall began May 7, 2019. Owners may contact Acura customer service at 1-888-234-2138. Acura's number for this recall is M49.
Exterior Lighting:tail Lights
Honda (American Honda Motor Co.) is recalling certain 2014-2019 Acura MDX and 2017-2019 Acura MDX Sport Hybrid vehicles. Moisture may enter the tailgate lid lights, possibly causing a loss of the tailgate lid lights and the taillights.
Consequence: Loss of the taillights reduces the vehicle's visibility, increasing the risk of crash.
Remedy: Acura will notify owners, and dealers will modify the tailgate lid lights and install updated gaskets and a wiring sub-harness or will replace both tailgate lid lights. The repairs will be performed free of charge. The recall began May 7, 2019. Owners may contact Acura customer service at 1-888-234-2138. Acura's number for this recall is M49.
Jan 29, 2019
Honda (American Honda Motor Co.) is recalling certain 2016-2018 Acura MDX, 2015-2019 Acura TLX and 2015-2017 Honda Accord vehicles, equipped with a 3.5L V6 engine. Particulates in fuel may adhere to the internal components of the fuel pump, reducing its performance.
Consequence & remedy
Consequence: Reduced fuel pump performance can result in an engine stall, increasing the risk of crash.
Remedy: Honda will notify owners, and dealers will update the fuel injection engine control unit (FI-ECU) software and, if necessary, replace the fuel pump, free of charge. The recall began March 25, 2019. Owners may contact customer service at 1-888-234-2138. Acura's recall number for this recall is P3W. Honda's recall number for this recall is N3X.
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
Illustration